Model 300 RD 300 kW Diesel Generator Set - Western Machinery ...
Model 300 RD 300 kW Diesel Generator Set - Western Machinery ...
Model 300 RD 300 kW Diesel Generator Set - Western Machinery ...
You also want an ePaper? Increase the reach of your titles
YUMPU automatically turns print PDFs into web optimized ePapers that Google loves.
<strong>Generator</strong> <strong>Set</strong> Design Features<strong>Model</strong> <strong>300</strong> <strong>RD</strong><strong>300</strong> <strong>kW</strong> <strong>Diesel</strong> <strong>Generator</strong> <strong>Set</strong>Standard Equipment* 4 Cycle engine.* AC synchronous 12 leadre-connectable brushless alternator.* Steel base with vibrationisolators between engine, generatorand base.* <strong>Generator</strong> mounted terminal andmeter /control box.* Circuit breaker-mounting provisions.* Connection area for main ACterminals and all control wiring* 24 volt DC engine electrical system.* 24 volt starter motor.* Battery charging alternator.* Battery rack and cables.* Flexible fuel lines.* Most metallic parts incorporate ourpowder paint primer base coat with UVinhibitive enamel top coat.* Single stage dry type air cleaner.* Corrosion resistant hardware.* Oil drain extension plumbed tobase rail for convenient connection.* Microprocessor based auto startmeter/ control panel.* Digital read out control systemrated to operate from -30º C to75º C with the following standarddisplays, shown continuously:** <strong>Generator</strong> AC voltage.** AC amperage:Phase 1-2Phase 2-3Phase 3-1** Frequency** Oil Pressure** Engine Temperature** Battery Voltage** Fuel Level (<strong>Diesel</strong> Only)* The following can be displayed usingthe scroll lock function:** Run time** Safety set point for over speed** Over crank** High water temperature** Low oil pressure* Voltage adjust rheostat* Auto/ off /run switch<strong>Generator</strong> SpecificationsManufacturer: MagneTekInsulation: The main stator, main rotor,exciter stator and exciter rotor are allinsulated with Class H materials andrated Class F per NEMA MG1 -1.65 and852757 definition. All materials are nonhygroscopicto prevent fungus growth. Apolyester and epoxy combination offersmaximum environmental protection.Main Stator: 2/3 pitch and one slotskewing minimize voltage harmonics andmeets telephone influence factor (TIF)per NEMA MG1-22.43. Twelve lead reconnectabledesign. Coated with antiabrasivesealer.Main Rotor: Four pole single piecelamination with full amortisseur windingsand coil supports. Winding is precisionwet layer wound with epoxy resin anddynamically balanced to two mil in twoplanes. Production over speed tested at125% for 15 minutes. All materials arenon-hygroscopic to prevent fungusgrowth.Exciter: Brushless, three phase, six-polerotor, and production over speed tested at125% operating speed.Rotating Diode: Sealed full wave withmetal oxide surge suppressorBearing: Double-sealed, permanentlylubricated, 50,000 hour B-10 lifeincluding magnetic pull.Drive Coupling: Positive alignment,flexible drive discs.Automatic Voltage RegulatorSpecificationsOperation: Volts per hertz, three phasesensing with overload and loss of sensingprotection.Construction: Solid state, modular: fullysealed and potted design providescomponent protection from corrosiveenvironments and vibration.Voltage Regulation: +/- 1% voltageregulation no load to full rated load: +/-1/2% voltage regulation at steady stateconditions.Radio Interference (RFI): Integral filterprovides suppression of conductedelectromagnetic interference to levelsmeeting most commercialrequirements.Voltage Selections and Full LoadAmperages at Standby RatingThree Phase60 Hz Amperage 50 Hz Amperage120/208 1042 110/190 1064120/240 902 120/208 971277/480 451 230/400 505347/600 361 240/415 487*Single Phase60 Hz Amperage 50 Hz Amperage120/240 979 110/220 1095All voltages listed are available and/orre-connectable with the exception of thethree phase, 60 Hz, 347/600 voltgenerator which is application specific.For other voltages, contact your EMPSdistributor. All output amperage ratingslisted above are at standby rating.*Single Phase amperage based onstandard generator and unity powerfactor. For full single phase output usegenerator model MTG49.Application andPerformance DataMagneTek Alternator <strong>Model</strong> MTG45 isstandard with this package. Largergenerators may be required to meetcertain application specificrequirements such as Single Phase,Motor Starting and Non Linear Loads.The Maximum <strong>Generator</strong> ratingavailable in this package is MTG52.
Change language