Model 150 QD 150 kW Diesel Generator Set - Western Machinery ...

Technical SpecificationsModel 150 QD150 kW Diesel Generator SetEngine SpecificationsManufacturerJohn DeereModel(150) 6081ATypeIn line 4 StrokeAspiration Turbo/ Air to Air Inter cooledCylinders 6Displacement 496 In 3 . (8.1 L)Bore and Stroke, 4.57 in x 4.92 in.(116 mm x 125 mm)Compression Ratio 16.5:1Minimum C.C.A. at 5°C 800RPM 1800 rpm 1500 rpmBHP Minimum REQ’Dat Rated kW 228 205BMEP 202 psi 218 psiGenerator Set DerationFactorsTemperature:2.5% for every 5° F above 105° F2.5% for every 9°C above 41°CAltitude1% for every 7500 feet above7500 feet1% for every 2286 meters above2286 metersCooling SystemHigh Ambient 105°F (41°C) SystemCoolant Capacity with Radiator45 qt. (42.6 L)Maximum restriction on discharge side ofradiator.5 In wc (125 Pa)1800 rpm 1500 rpmCoolant Flow71 GPM 55 GPM(268.8 LPM) (208.2 LPM)Heat Rejectionto Coolant atFull Load5940 Btu/min 5170 Btu/min)(627 MJ/min) (545 MJ/min)Air SystemMaximumAir IntakeRestriction1800 rpm 1500 rpm30 In wc(7.5 kPa)Radiator CoolingAir Flow 14000 cfm 12600 cfm(396.2 m 3 /min) (356.6 m 3 /min)CombustionAir Flow 565 cfm 509 cfm(16 m 3 /min) (14.4 m 3 /min)GeneratorCoolingAir Flow 2348 cfm 1957 cfm(66.4 m 3 /min) (55.4 m 3 /min)Exhaust SystemExhaust OutletConnection5.0 in. SAE FlangeMaximum Allowable Back Pressure40.9 In wc (10.2 kPa)Exhaust Gas Flowat StandbyRating 1480 cfm 1210 cfm(41.9 m 3 /min)(34.2 m 3 /min)Exhaust Temp atStandby Rating1015°F 1060°F(546°C) (571°C)Fuel SystemConsumption at Standby Rating:Load 1800 RPMkW US gal/h Litre/h1/4 37 3.1 11.71/2 75 5.8 20.03/4 112 8.4 29Full 150 11 38Load 1500 RPMkW US gal/h Litre/h1/4 33 2.6 9.81/2 67 4.9 173/4 101 7 25Full 135 9.3 32Governor TypeMechanicalGovernor Regulation:+/- 3-5% Steady StateGeneratorManufacturerModelMotor Starting KVA,240/480 Volt WYE at35% Voltage Dip,100%Voltage RecoveryMaximum MotorStarting KVA,35% Voltage DipOversized GeneratorMTG47ReactancesMagneTekMTG38360 SKVA780 SKVA480 V 400 Vat 105°C rise 60Hz 50HzSynchronous Xd 3.11 2.63Direct AxisTransient X'd .231 .196Direct AxisSubtransient X’d .151 .128Zero Sequence Xo .0027 .0023Lubrication SystemEngine Oil Capacity with FiltersOil Filter Type8.25 US gal. (32 L)Spin OnEngine Exhaust EmissionsCertification ValuesExhaustEmissions (g/bhp-hr.)*CARB 150QDHC: 1 .6CO: 8.5 1.2NOx: 6.9 6.5PM: .4 .2* California Air Resources BoardStandards.Smoke Opacity (%)Acceleration 20 14Lugging 15 6Peak 50 21

Model 150 QD150 kW Diesel Generator SetOptions:Generator* Upsized* Tropical winding protection* Space heater* Series boost* UL listed mainline circuitbreakerControl* Remote alarm annunciator* Emergency stop* Multi-point dry contact board.* NFPA 110 Compliance* Low Temperature DisplayHeaterEngine* Battery/Battery heater* Battery charger* Engine pre-heater* Fuel/ water separator* Isochronous governorGenerator Set* EMPS automatic transfer switch* Industrial silencer* Residential silencer* Critical silencer* Weather protectiveenclosure* Sound attenuation* Sub-base fuel tank58 Elliott Power DriveP.O. Box 403Lexington, TN 38351Tel: 901-967-9393Fax: 901-968-0161Distributed by:All specifications subject to change without notice. Printed in the USAUpdated 2/00