Model 300 RD 300 kW Diesel Generator Set - Western Machinery ...

Model 300 RD300 kW Diesel Generator SetGenerator Set RatingThree Phase 60 Hz 50 HzkW/KVA kW/KVAContinuousStandby 150°C 300/375 280/350Prime Power 105°C 275/344 255/319Single Phase 60 Hz 50 HzkW/KVA kW/KVAContinuousStandby 150°C 235/235 241/241Prime Power 105°C 201/201 201/201Quality Power Producing Equipmentis our business at Elliott MagneTek Power Systems, Inc.. Ourpower systems offer solutions to requirements for reliable,quality electrical power.• 100% full load tested.• Performance supported by prototype testing.• 12 lead re-connectable AC synchronous generators.• Solid state automatic voltage regulator.• 50 or 60 Hz operational.• Standard Digital Control Panel meeting standards set byNFPA-110.Product FeaturesSystem Reliability and Longevitybegin with design experience andintegrity. EMPS was formed by twocompanies with over one hundredyears experience producing state-ofthe-art power generation equipment.This experience is designed into ourgenerator sets.Single Source Responsibility:Product service, support and partsavailable through EMPS network ofdistributors.Accessories and Flexibilityare designed into EMPS’ generator setsat the factory level to meet specificapplication needs.Organizational Commitmentto innovative, leading edge technologyand environmentally friendly electricalproducts and services.

Generator Set Design FeaturesModel 300 RD300 kW Diesel Generator SetStandard Equipment* 4 Cycle engine.* AC synchronous 12 leadre-connectable brushless alternator.* Steel base with vibrationisolators between engine, generatorand base.* Generator mounted terminal andmeter /control box.* Circuit breaker-mounting provisions.* Connection area for main ACterminals and all control wiring* 24 volt DC engine electrical system.* 24 volt starter motor.* Battery charging alternator.* Battery rack and cables.* Flexible fuel lines.* Most metallic parts incorporate ourpowder paint primer base coat with UVinhibitive enamel top coat.* Single stage dry type air cleaner.* Corrosion resistant hardware.* Oil drain extension plumbed tobase rail for convenient connection.* Microprocessor based auto startmeter/ control panel.* Digital read out control systemrated to operate from -30º C to75º C with the following standarddisplays, shown continuously:** Generator AC voltage.** AC amperage:Phase 1-2Phase 2-3Phase 3-1** Frequency** Oil Pressure** Engine Temperature** Battery Voltage** Fuel Level (Diesel Only)* The following can be displayed usingthe scroll lock function:** Run time** Safety set point for over speed** Over crank** High water temperature** Low oil pressure* Voltage adjust rheostat* Auto/ off /run switchGenerator SpecificationsManufacturer: MagneTekInsulation: The main stator, main rotor,exciter stator and exciter rotor are allinsulated with Class H materials andrated Class F per NEMA MG1 -1.65 and852757 definition. All materials are nonhygroscopicto prevent fungus growth. Apolyester and epoxy combination offersmaximum environmental protection.Main Stator: 2/3 pitch and one slotskewing minimize voltage harmonics andmeets telephone influence factor (TIF)per NEMA MG1-22.43. Twelve lead reconnectabledesign. Coated with antiabrasivesealer.Main Rotor: Four pole single piecelamination with full amortisseur windingsand coil supports. Winding is precisionwet layer wound with epoxy resin anddynamically balanced to two mil in twoplanes. Production over speed tested at125% for 15 minutes. All materials arenon-hygroscopic to prevent fungusgrowth.Exciter: Brushless, three phase, six-polerotor, and production over speed tested at125% operating speed.Rotating Diode: Sealed full wave withmetal oxide surge suppressorBearing: Double-sealed, permanentlylubricated, 50,000 hour B-10 lifeincluding magnetic pull.Drive Coupling: Positive alignment,flexible drive discs.Automatic Voltage RegulatorSpecificationsOperation: Volts per hertz, three phasesensing with overload and loss of sensingprotection.Construction: Solid state, modular: fullysealed and potted design providescomponent protection from corrosiveenvironments and vibration.Voltage Regulation: +/- 1% voltageregulation no load to full rated load: +/-1/2% voltage regulation at steady stateconditions.Radio Interference (RFI): Integral filterprovides suppression of conductedelectromagnetic interference to levelsmeeting most commercialrequirements.Voltage Selections and Full LoadAmperages at Standby RatingThree Phase60 Hz Amperage 50 Hz Amperage120/208 1042 110/190 1064120/240 902 120/208 971277/480 451 230/400 505347/600 361 240/415 487*Single Phase60 Hz Amperage 50 Hz Amperage120/240 979 110/220 1095All voltages listed are available and/orre-connectable with the exception of thethree phase, 60 Hz, 347/600 voltgenerator which is application specific.For other voltages, contact your EMPSdistributor. All output amperage ratingslisted above are at standby rating.*Single Phase amperage based onstandard generator and unity powerfactor. For full single phase output usegenerator model MTG49.Application andPerformance DataMagneTek Alternator Model MTG45 isstandard with this package. Largergenerators may be required to meetcertain application specificrequirements such as Single Phase,Motor Starting and Non Linear Loads.The Maximum Generator ratingavailable in this package is MTG52.