PowerLine - Simland Trading Ltd

PowerLineSwitch Fuses OSTechnical DataTechnical Data According to IEC 60947 for OS Switch-Disconnector-FusesS01382AIO TestO OFFINODescriptionOS MiniSwitch size A 16 20 25 32Rated insulation voltage Pollution degree 3 V 1 000 1 000 1 000 1 000Dielectric strength 50 Hz 1min. kV 10 10 10 10Rated impulse withstand voltage kV 12 12 12 12Rated thermal current in ambient 40 ˙C / In open air A / W 16/3,5 20/3,5 25/3,5 32/3,5max. fuse power dissipation 1) In enclosure A / W 16/3,5 20/3,5 25/3,5 32/3,5In enclosure with solid links A 32 32 32 32...with minimum cable cross section Cu mm 2 2,5 2,5 4 6Rated operational voltage AC-20 and DC-20 V 1 000 1 000 1 000 1 000Rated operational current, AC-21A up to 500 V A 16 20 25 32690 V A 16 20 25 32Rated operational current, AC-22A up to 500 V A 16 20 25 32690 V A 16 20 25 32Rated operational current, AC-23A up to 500 V A 16 20 25 32690 V A 16 20 25 32Rated operational current / poles in series 48 V A 16 / 2 20 / 2 25 / 2 32 / 2DC-21A 110-220 V A 16 / 2 20 / 2 25 / 2 32 / 2440 V A 16 / 4 20 / 4 25 / 4 32 / 4Rated operational current / poles in series 48 V A 16 / 2 20 / 2 25 / 2 32 / 2DC-22A 110-220 V A 16 / 2 20 / 2 25 / 2 32 / 2440 V A 16 / 4 20 / 4 25 / 4 32 / 4Rated operational current / poles in series 48 V A 16 / 2 20 / 2 25 / 2 32 / 2DC-23A 110-220 V A 16 / 2 20 / 2 25 / 2 32 / 2440 V A 16 / 4 20 / 4 25 / 4 32 / 4Rated operational power, AC-23 2) 230 V kW 4 5,5 6 8The kW-ratings are accurate for 400 V kW 7,5 10 11 14three-phase 1500 R.P.M. standard 415 V kW 7,5 10 12 15asynchronous motors. 500 V kW 9 12 14 18690 V kW 11 15 22 25Rated breaking capacity in category AC-23 up to 500 V A 256 256 256 256690 V A 256 256 256 256Rated breaking capacity / poles in series up to 220 V A 128 / 2 128 / 2 128 / 2 128 / 2in category DC-23 440 V A 128 / 4 128 / 4 128 / 4 128 / 4Rated conditional short-circuit current r.m.s. The cut-off currents refer to 80 kA, 415 V kA 9 9 9 9and corresponding max. allowed cut-off single phase fuse tests. 100 kA, 500 V kA 7,5 7,5 7,5 7,5current, peak value. Fuse selection tables on request. 50 kA, 690 V kA 6 6 6 6Rated short-time withstand current, 1s. R.M.S. -value kA 1 1 1 1Rated capacitor power The capacitor rating of the 400 V kVAr 5 10 12 15switch-fuse is limited by 415 V kVAr 5 10 12 15the fuse link. 690 V kVAr 8 15 20 25Power loss / pole With rated current, without fuse W 0,8 1,3 1,3 2Mechanical endurance Divide by two for operation cycles Oper. 20 000 20 000 20 000 20 000Fuse types, IEC 269-2 DIN 43620, Neozed DIN49522 D 01 - - -NFC - - 10x38 14x51BS 88 - A1 - A1, A2, F1-size / distance of fuse-link bolts mm - M4 / 44,5 - M4/44,5 (A1)M4/73 (A2)Weight without accessories 3-pole switch fuses kg 0,7 0,7 0,7 0,74-pole switch fuses kg 0,9 0,9 0,9 0,9Built-in terminal size Cu mm 2 0,5...10 0,5...10 0,5...10 0,5...10Terminal bolt size Metric thread diameter x length mmTerminal tightening torque Counter torque required Nm 2 2 2 2Fuse-links bolts tightening torque Nm - 2 - 2Operating torque Typical for 3-pole switch fuses Nm 3 3 3 3*= Utilization category B1)Ambient temperature 60 ˚C: derating 20%. Mounting on “ceiling”: derating10%. Mounting on wall, horizontal fuses: derating 8%.5/64 Automation Technologies1SKC000013C0201

PowerLineSwitch Fuses OSOrdering DeailsFront operated switch fuses OS 32...160, DIN-typeFuse standards DIN 43620, IEC 60269-2-1SEC IRated impulse withstand voltage (U imp) 12 kVOS 40 MiniMechanism between the polesIncluding a black handle OHB65J5 with I-0 and ON-OFF -indication (IP65) and a shaft OXP5X150 (length150 mm, mounting depth H=153...210 mm). Protected tunnel terminals, IP20, cable size 0.5... 10 mm 2 .S01382AIO TestO OFFINORated Rated Fuse No. of Type Code Ordering Details Weightop. current op. power type/size poles Type No. 1 PC/kgAC-20...23 AC-23< 690V 400/500/690V[A] [kW]40 20/25/30 000 3 OS 40 D12000 1SCA022615R8150 0,840 20/25/30 000 4 1) OS 40 D22000N1 1SCA022647R2020 1,0OS 32D_...63D_Mechanism between the polesIncluding a black handle OHB65J6 with I-0 and ON-OFF -indication (IP65) and a shaft OXP6X161 (length161 mm, mounting depth H=141...260 mm). Protected tunnel terminals, IP20, cable size 2.5É25 mm2.Terminal shroud OSS63G1 needed for maintaining IP20 rating for wire sizes

PowerLineSwitch Fuses OS, AccessoriesOrdering Deails (continued)Auxiliary contacts, IP20Auxiliary contacts for OS MiniAuxiliary/test contacts, mounting to the switch mechanism.The type includes one change over contact.Technical data:U e= 24V,/ I e(DC12) =6A; U e= 250V/ I e( AC 15) = 3A, I e( DC12) =0.1A; U e= 440V/ I e( AC 15) = 2ADescription Type Order number WeightType No.1 pc/kgOA4B1C 1SCA022193R0150 0,03Auxiliary contacts for OS Mini and for OS 30...200Snap-on mounting to the switch, IP20, cable cross section 0.75...2 x 2.5 mm 2 .Early-break type. I th= 16A, U i= 690V. Rated operational currents, AC 15 : 6A/230V, 4A/400V, 2A/690V.All n.o. contacts are provided with a positive opening feature.For OS Mini:Max. 6 auxiliary contacts mountable onto the side with the mounting frame OSZ4. Mounting frame has tobe ordered separately.For OS 30...63:Max. 6 auxiliary contacts mountable onto the side. No frames needed. Max. 2 auxiliary contacts mountablebetween the poles, which can be used as Test-contacts, see a function chart below.For OS 100...200:Max. 6 auxiliary contacts per switch side mountable on to the side. No frames needed. Max. 3 auxiliarycontacts mountable between the poles, of which two contacts can be used as Test-contacts and onecontact is used as Test -indication contact.Description Recomm. Type Code Order number Weightquantity Type No. 1 pc/kg1 N.O. 10 OA1G 10 1SCA022353R4970 0.031 N.C. 10 OA3G 01 1SCA022456R7410 0.03Auxiliary contact frames for OS MiniFor OA1G10 and OA3G01 auxiliary contactsFrame for auxiliary contacts and for fuse monitor. Max. 6 auxiliary contacts (type OA_G_) can be fitted- Mounting on the left side of the switchType Code Order number WeightType No.1 pc/kgOSZ4 1SCA022530R0200 0,0614 13 22 21Fuse Monitor- includes the auxiliary contacts 1NO + 1NC. Snap-on fitting on to the switch fuse. See brochure OFM20GBREMARK. For OS Mini the frame for fuse monitor and auxiliary contacts type OSZ4 has to be orderedseparately. See auxiliary contacts.Rated voltage Type Order number Weight(v ac) Type No. 1 pc/kg100...260 OFM 260 1SCA022459R8560 0.14380...690 OFM 690 1SCA022459R8480 0.14FusesMounting accessories for fuse monitorIncludes 6 pcs crimp terminals.Suitable for Flat terminal Type Order Number Weightswitches size [mm] Type No. 1 pc/kgOS Mini, OS 30...160 2.8 - 0.8 OS Z4 1SCA022530 R0200 0.06Automation Technologies5/691SKC000013C0201

NNNNPowerLineSwitch Fuses OS, AccessoriesOrdering Deails (continued)Terminal shroudsFor OS 100..200, all shrouds provided with knock-outs- For up and down connectionsSingle pole terminal shroud, IP20. Snap-on fitting. For cable lug connections, L = 67,5, transparent.Type Code Order number WeightType No.1 PC/[kg]OSS 160T1 1SCA022502R8830 0.015Neutral LinksFor OS Mini and OS 32...63,detachable, mounting on the side of the switch or on to the mounting plate or DIN-rail.Max. wire Dimensions Mounting Type Code Order number WeightHXWXD [mm] holes Type No. 1 PC[kg]16 mm 2 Cu 39 41 40 Ø 4.2, distance 32 OESAZX 171 1SCA022197R2580 0.15For OS 30...200,detachable, mounting on to the base plate or DIN-rail.Max. wire Dimensions Mounting Type Code Order number WeightHXWXD [mm] holes Type No. 1 PC[kg]35 mm 2 Cu 39 44 45 Ø 4.2, distance 35 OSZ 2 1SCA022481R3800 0.07For OS 100...200_03,detachable, mounting on the top of the mechanism.It does not increase the foot print area of a three pole switch. N-terminal distance to L1-terminal = identicalto phase-to-phase terminal distance.Description Type Code Order number WeightType No.1 PC/[kg]Terminal width 20 mm OSN 160W 1SCA022561R0810 0.165/70 Automation Technologies1SKC000013C0201

IIPowerLineSwitch Fuses OESATechnical DataTechnical Data According to IEC 60947 for OESA Switch-Disconnector-FuseslOlOS00607AO OFFNOS00609AOFFOFF OONODescriptionOESA_PLSwitch size A 200 250 315 400 630 800Rated insulation voltage Pollution degr. 3 V 1 000 1 000 1 000 1 000 1 000 1 000Dielectric strength 50 Hz 1min. kV 10 10 10 10 10 10Rated impulse withstand voltage kV 12 12 12 12 12 12Rated thermal current in ambient 40 ˙C / In open air ˙ A / W 200/22 250/32 315/32 400/45 630/60 800/65max. fuse power dissipation 1) In enclosure A / W 200/22 250/23, 315/32 400/34, 600/45, 720/55In enclosure 230/27 360/37 570/50with solid links A 280 315 400 450 700 910...with minimum cable cross section Cu mm2 95 120 185 240 2x185 2x240Rated operational voltage AC-20 and DC-20 V 1 000 1 000 1 000 1 000 1 000 1 000Rated operational current, AC-21A up to 500 V A 200 250 315 400 630 800690 V A 200 250 315 400 630 800Rated operational current, AC-22A up to 500 V A 200 250 315 400 630 800690 V A 200 250 315 400 630 800Rated operational current, AC-23A up to 500 V A 200 250 315 400 630 720690 V A 200 250 315 400 630 720Rated operational current / poles in series 48 V A 200/2 250/2 315/2 400/2 630/2 800/2DC-21A 110-220 V A 200/2 250/2 315/2 400/2 630/2 800/2440 V A 200/2 250/2 315/2 400/2 630/2 800/2500-750 V 200/3 250/3 315/3 400/3 630/3 800/31000V 200/4 250/4 315/4 400/4 630/4 800/4Rated operational current / poles in series 48 V A 200/2 250/2 315/2 400/2 630/2 800/2DC-22A 110-220 V A 200/2 250/2 315/2 400/2 630/2 800/2440 V A 200/2 250/2 315/2 400/2 630/2 800/2500-750 V 200/3 250/3 315/3 400/3 630/3 800/31000 V 200/4 250/4 315/4 400/4 630/4 800/4Rated operational current / poles in series 48 V A 200/2 250/2 315/2 400/2 630/2 800/2DC-23A 110-220 V A 200/2 250/2 315/2 400/2 630/2 800/2440 V A 200/2 250/2 315/2 400/2 630/2 800/2500-750 V 200/3 250/3 315/3 400/3 630/3 800/31000 V - - - - 630/4 800/4Rated operational power, AC-23 2) The kW-ratings are 230 V kW 57 70 90 110 180 200accurate for three- 400 V kW 100 132 160 210 315 350phase 1500 R.P.M. 415 V kW 110 140 180 230 340 380standard asynch- 500 V kW 140 170 220 280 400 470ronous motors. 690 V kW 180 230 290 330 540 600Rated breaking capacity in category AC-23 up to 500 V A 2000 2000 3200 3200 5760 5760690 V A 2000 2000 3200 3200 5760 5760Rated breaking capacity / poles in series up to 220 V A 1000/2 1000/2 1600/2 1600/2 3200/2 3200/2in category DC-23 440 V A 1000/2 1000/2 1600/2 1600/2 3200/2 3200/2500-750 V 1000/3 1000/3 1600/3 1600/3 3200/3 3200/31000 V - - - - 3200/4 3200/4Rated conditional short-circuit current r.m.s. The cut-off currents 80 kA, 415 V kA 40 40 40 40 75 75and corresponding max. allowed cut-off refer to single phase 100 kA, 500 kA 40 40 40 40 75 75current, peak value. fuse tests. Fuse 50 kA, 690 V kA 35 35 35 35 60 60select. tables on req.Rated short-time withstand current, 1s. R.M.S. -value kA 8 8 10 10 16 16Rated capacitor power The capacitor rating 400 V kVAr 90 105 145 180 250 310of the switch-fuse is 415 V kVAr 100 115 160 200 270 340limit. by the fuse link. 690 V kVAr 160 190 250 325 450 550Power loss / pole With rated current, W 5 11 13 30 55 77without fuse.Mechanical endurance Divide by two for Oper. 16 000 16 000 16 000 16 000 10 000 10 000operation cyclesFuse types, IEC 269-2 DIN 43620 - 0-1 - 0-2 3 3FusesBS 88 B1-B2 B1-B3 3) B1-B3 B1-B4 C1-C2 C1-C3- size / distance mm M8/111 M8/111 M8/111 M8/111 M10/133, M10/133,of fuse-link bolts 184 184Weight without accessories 3-pole switch fuses kg 6.9 6.9 7.3 7.8 15.5 17.04-pole switch fuses kg 7.9 7.9 8.3 8.8 19.0 21.0Terminal bolt size diameter x length mm M10x40 M10x40 M10x40 M10x40 M12x40 M12x40Terminal tightening torque Counter torque required Nm 30...44 30...44 30...44 30...44 50...75 50...75Fuse-links bolts tightening torque Nm 15 15 15 15 40 40Operating torque Typical for 3-pole Nm 22 22 22 22 28 28switch fuses1)Ambient temperature 60 ˚C: derating 20%. Mounting on ‘ ceiling’ : derating 10%. Mounting on wall, horizontal fuses: derating 8%.2)Some fuse links limit these figures further. Starting current characteristics must be considered separately3)Maximum fuse body diameter Ø 55 mm .Automation Technologies5/711SKC000013C0201

PowerLineSwitch Fuses OESAOrdering DeailsDIN-pattern250A and 400A switches include terminal bolt kit, black, IP 65, OHB125J12 handle with I-O/ON-OFF -indication and shaft OXP12X250, length 250 mm. 630A and 800A switches include terminal bolt kit,black, IP 65, OHB145J12 handle with I-O/ON-OFF -indication and shaft OXP12X250, lenght 250 mm.S00607AOlO OFFINOSwitch fuses without handle and shaft, please complete the type number with code: -2 .Example: OESA 630 D3PL-2 = delivery without handle and shaft.Rated I thRated op. current No. Type Code Ordering Details Weightop. (open) Rated op. power in category of Type No. 1 pc/kgvoltage [A] AC 23A IEC 947 PolesAC23/ [A/kW][V]230v/400v/415v/500v/500v/690v690 250 250/250/250/250/250 3 OESA 250 D3PL 1SCA 022208 R6160 7.3690 250 250/250/250/250/250 4 1) OESA 250 D4PL 1SCA 022207 R4590 8.2690 400 400/400/400/400/400 3 OESA 400 D3PL 1SCA 022258 R2220 8.3690 400 400/400/400/400/400 4 1) OESA 400 D4PL 1SCA 022226 R9590 9.4690 630 630/630/630/630/630 3 OESA 630 D3PL 1SCA 022282 R2210 16.0690 630 630/630/630/630/630 4 1) OESA 630 D4PL 1SCA 022282 R2800 21.0690 800 800/800/800/800/800 3 OESA 800 D3PL 1SCA 022282 R2630 18.0690 800 800/800/800/800/800 4 1) OESA 800 D4PL 1SCA 022282 R2470 24.0BS-patternOESA 200...400 include terminal bolt kit, IP 20 -fuse cover,black, IP 65, OHB125J12 handle with I-O/ON-OFF -indication and shaft OXP12X250, length 250 mm.OESA 630...800 include terminal bolt kit,IP 20 - fuse cover,black, IP 65, OHB145J12 handle with I-O/ON-OFF -indication and shaft OXP12X250, length 250 mm.S00609AlOOFFOFF OOINOSwitch fuses without handle and shaft, please complete the type number with code: -2 .Example: OESA 630 B3PL1-2 = delivery without handle and shaft.Rated I thRated op. current No. Type Code Ordering Details Weightop. (open) Rated op. power in category of Type No. 1 pc/kgvoltage [A] AC 23A IEC 947 PolesAC23/ [A/kW][V]230v/400v/415v/500v/500v/690v690 200 200/200/200/200/200 3 OESA 200 D3PL1 1SCA 022274 R8130 7.1690 200 57/100/110/140/180 4 1) OESA 200 D4PL1 1SCA 022274 R9370 8.2690 315 315/315/315/315/315 3 OESA 315 D3PL1 1SCA 022279 R7420 7.9690 315 90/100/100/220/290 4 1) OESA 315 D4PL1 1SCA 022279 R7260 8.9690 400 400/400/400/400/400 3 OESA 400 D3PL1 1SCA 022260 R8470 8.3690 400 110/210/230/280/330 4 1) OESA 400 D4PL1 1SCA 022261 R0610 9.4690 630 630/630/630/630/630 3 OESA 630 D3PL1 1SCA 022289 R9000 16.0690 630 180/315/430/400/540 4 1) OESA 630 D4PL1 1SCA 022289 R9690 21.0690 800 800/800/800/720/720 3 OESA 800 D3PL1 1SCA 022289 R5190 18.0690 800 800/800/800/800/800 4 1) OESA 800 D4PL1 1SCA 022289 R5510 24.05/72 Automation Technologies1SKC000013C0201

23PowerLineSwitch Fuses OESA, AccessoriesOrdering DeailsS00469AO OFFINOOptional handles, front operatedPlastic handles, IP 65, Indication 1-0 / ON-OFFPadlockable with 3 padlocks in OFF- position, door interlock in ON- position (defeatable), door drilling Ø53mm. The shaft has to be ordered separately.Colour Handle Shaft diam. Suitable for Type Code Order Details Weightlength mm mm switch sizes Type No. 1pc/kgBlack 125 12 OESA 200...400 OHB 125J12 1SCA022381R1560 0,2Black 145 12 OESA 200...800 OHB 145J12 1SCA022381R2110 0,2Black 175 12 OESA 200...800 OHB 175J12 1SCA022381R2450 0,2Extended shaftsShaft diameter 12 mm. A package includes 10 pieces.S01275A21 13Ol83 7363 5343 331383 7363 5343 3323 13S00536AS00047AShaft Front op. Suitable for Type Code Order Details Weightlength mm H / mm switch sizes Type No. 1pc/kg250 230…340 OESA 200…400 OXP12x250 1SCA022325R6980 0.3255…325 OESA 630…800395 375…485 OESA 200…400 OXP12x395 1SCA022042R5990 0.5400…470 OESA 630…800535 515…625 OESA 200…400 OXP12x535 1SCA022042R6110 0.7540˚610 OESA 630…800Auxiliary contact sets, IP 20Cable cross section min. 0.5 mm 2 , max. 2 x 2.5 mm 2 . Insulation voltage 690 V. Thermal current I th= 10 A.Performance data according IEC 947-5-1 U e/ I e(AC12):120V/8A, 240V/6A, 400V/4A, 415V/4A,480V/3A, 500V/3A, 690V/2A, (DC12): 125V/1.1A, 250V/0.55A, 440V/0.31A, 500V/0.27A, 600V/0.2A.Auxiliary Suitable for Type Code Order Details Weightcontact switch sizes Type No. 1pc/kg1no+1nc OESA 200...800 OZXK 1 1SCA022131R8690 0,09S00490A2no+2nc OESA 200...800 OZXK 2 1SCA022131R8850 0,124no+4nc OESA 200...800 OZXK 31) 1SCA022131R9070 0,172no OESA 200...800 OZXK 4 1SCA022131R9230 0,09lO21 1321 13Fuse covers for OESA_PLSoo606A S00605ASutable for Suitable for Type Code Order Details WeightSwitch types switch sizes TypeNo. 1pc/kgOESA 200 B*, 250 D, 250 B* 3 OESAZX 190 1SCA022265R0750 0,164 OESAZX 191 1SCA022265R0910 0,20OESA 315 B*, 400 D, 400 B*, 315 BM 3 OESAZX 192 1SCA022265R1130 0,184 OESAZX 193 1SCA022265R1300 0,22OESA 630 D, 630 B* 3 OESAZX 194 1SCA022265R1560 0,284 OESAZX 195 1SCA022265R1720 0,34OESA 800 D, 800 B* 3 OESAZX 196 1SCA022265R1990 0,304 OESAZX 197 1SCA022265R2110 0,36Fuses*) BS- type switches include a fuse shroud as standard**) Door interlocking in ON-position means that the door can’t be opened, when the handle is in ON-position. This can be defeated to allowauthorized personnel access for inspection. Handles padlockable in all positions are available on request.Automation Technologies5/731SKC000013C0201

PowerLineSwitch Fuses OESA, AccessoriesOrdering Deails (continued)Terminal shroudsS01044AS01280AS00908A14 13 22 21S01279AS00042AS00954ASuitable For Quantity for full No. Type Code Order Details Weightswitch types protection [pcs] poles [kg]OESA 200...400 3 6 OESAZX 119 1SCA022103R2450 0,054 8OESA 630...800 3 6 OESAZX 102 1SCA022090R6740 0,094 8Fuse MonitorIncluding the auxiliary contacts 1NO + 1NC. Snap-on fitting on to the switch fuse. See brochure OFM20GB.Rated voltage Type Code Order Details Weight[Vac]1 p/kg100...260 OFM 260 1SCA022459R8560 0.14380...690 OFM 690 1SCA022459R8480 0.14Mounting accessories for fuse monitorIncludes 6 pcs crimp terminals.Suitable for switches Flat termina Type Code Order Details Weightsize [mm]1 p/kgOESA 200...800 6.3 - 0.8 OFMZX 4 1SCA022475R9750 0,02Neutral linksDetachable, mounting on the top of the switchThe three pole foot print area does not increase. N-terminal distance to L1-terminal = identical to phase-tophaseterminal distance.For switch sizes OESA 200...400_3PLI thTerminal size Type Code Order Details Weight(WxD) [mm 2 ]; bolt size1 p/kg400 25x5; M10 OESAZX 282 1SCA022565R5320 0,53For switch sizes OESA 630...800_3PLI thTerminal size Type Code Order Details Weight(WxD) [mm 2 ]; bolt size1 p/kg800 40x6; M12 OESAZX 283 1SCA022565R5410 0,72S00586ADetachable, mounting on the side of the switchI thMax. cable cross Type Code Order Details Weightsection/Cu mm 21 p/kg400 240 OESAZX 85 1SCA022082R3110 1800 240 OESAZX 88 1SCA022083R2010 15/74 Automation Technologies1SKC000013C0201

FuseLineHRC Fuse links, type gG, 500VOrdering DetailsHRC Fuse links, universal fuses, gG, up to 500VType code includes one fuse link, but the delivery batch is acc. to the table: Packing quantity.S01354AS01353AS01352AS01351AS01350AOFAF000gG100AOFAF00gG160AOFAF0gG160AOFAF1gG315AOFAF2gG400AIEC- I nPh Packingsize [A] [W] quantityType Order number Weight[pcs][kg]000 2 3,9 9 OFAF000H2 1SCA022627R0230 0,124 1,5 9 OFAF000H4 1SCA022627R0310 0,126 1,6 9 OFAF000H6 1SCA022627R0400 0,1210 1,1 9 OFAF000H10 1SCA022627R0580 0,1216 1,8 9 OFAF000H16 1SCA022627R0660 0,1220 2,4 9 OFAF000H20 1SCA022627R0740 0,1225 2,4 9 OFAF000H25 1SCA022627R0820 0,1232 2,7 9 OFAF000H32 1SCA022627R0910 0,1235 3,0 9 OFAF000H35 1SCA022627R1040 0,1240 3,4 9 OFAF000H40 1SCA022627R1120 0,1250 3,9 9 OFAF000H50 1SCA022627R1210 0,1263 4,7 9 OFAF000H63 1SCA022627R1390 0,1280 5,7 9 OFAF000H80 1SCA022627R1470 0,12100 6,7 9 OFAF000H100 1SCA022627R1550 0,1200 125 8,4 3 OFAF00H125 1SCA022627R1630 0,18160 10,6 3 OFAF00H160 1SCA022627R1710 0,180 6 1,8 3 OFAF0H6 1SCA022627R1800 0.2110 1,5 3 OFAF0H10 1SCA022627R1980 0.2116 2,5 3 OFAF0H16 1SCA022627R2010 0.2120 3,5 3 OFAF0H20 1SCA022627R2100 0.2125 3,5 3 OFAF0H25 1SCA022627R2280 0.2132 3,2 3 OFAF0H32 1SCA022627R2360 0.2135 3,5 3 OFAF0H35 1SCA022627R2440 0.2140 4,2 3 OFAF0H40 1SCA022627R2520 0.2150 5,1 3 OFAF0H50 1SCA022627R2610 0.2163 6,2 3 OFAF0H63 1SCA022627R2790 0.2180 7,1 3 OFAF0H80 1SCA022627R2870 0.21100 8,7 3 OFAF0H100 1SCA022627R2950 0.21125 11,0 3 OFAF0H125 1SCA022627R3090 0.21160 11,7 3 OFAF0H160 1SCA022627R3170 0.21200 15,0 3 OFAF0H200 1SCA022629R5140 0.30224 16,2 3 OFAF0H224 1SCA022629R5220 0.30250 17,8 3 OFAF0H250 1SCA022627R3170 0.301 16 2,5 3 OFAF1H16 1SCA022627R3250 0,2820 3,5 3 OFAF1H20 1SCA022627R3330 0,2825 3,3 3 OFAF1H25 1SCA022627R3410 0,2832 3,2 3 OFAF1H32 1SCA022627R3500 0,2835 3,5 3 OFAF1H35 1SCA022627R3680 0,2840 4,2 3 OFAF1H40 1SCA022627R3760 0,2850 5,1 3 OFAF1H50 1SCA022627R3840 0,2863 6,2 3 OFAF1H63 1SCA022627R3920 0,2880 7,1 3 OFAF1H80 1SCA022627R4060 0,28100 8,7 3 OFAF1H100 1SCA022627R4140 0,28125 11,0 3 OFAF1H125 1SCA022627R4220 0,40160 11,7 3 OFAF1H160 1SCA022627R4310 0,40200 14,5 3 OFAF1H200 1SCA022627R4490 0,40224 15,9 3 OFAF1H224 1SCA022627R4570 0,40250 19,7 3 OFAF1H250 1SCA022627R4650 0,40315 26,0 3 OFAF1H315 1SCA022627R4730 0,40355 26,4 3 OFAF1H355 1SCA022701R4520 0,402 35 3,5 3 OFAF2H35 1SCA022627R4810 0.4240 5,1 3 OFAF2H40 1SCA022627R4900 0.4250 6,0 3 OFAF2H50 1SCA022627R5030 0.4263 7,1 3 OFAF2H63 1SCA022627R5110 0.4280 8,6 3 OFAF2H80 1SCA022627R5200 0.42100 10,6 3 OFAF2H100 1SCA022627R5380 0.42125 11,9 3 OFAF2H125 1SCA022627R5460 0.42160 14,0 3 OFAF2H160 1SCA022627R5540 0.42200 15,4 3 OFAF2H200 1SCA022627R5620 0.42224 19,1 3 OFAF2H224 1SCA022627R5710 0.42250 22,5 3 OFAF2H250 1SCA022627R5890 0.42300 24,0 3 OFAF2H300 1SCA022627R5970 0.63315 26,2 3 OFAF2H315 1SCA022627R6010 0.63355 27,5 3 OFAF2H355 1SCA022627R6190 0.63400 30,2 3 OFAF2H400 1SCA022627R6270 0.63425 33,0 3 OFAF2H425 1SCA022706R3900 0.63500 44,0 3 OFAF2H500 1SCA022701R4610 0.63FusesAutomation Technologies5/751SKC000013C0201

FuseLineHRC Fuse links, type gG, 500VOrdering Details (continued)HRC Fuse links, universal fuses, gG, up to 500VType code includes one fuse link, but the delivery batch is acc. to the table: Packing quantity.S01355AS01356A S01362AOFAF3gG630A4gG1250AOFAF4a/gG1250AIEC- I nPh Packingsize [A] [W] quantityType Order number Weight[pcs][kg]3 250 17,9 1 OFAF3H250 1SCA022627R6350 0.63300 20 1 OFAF3H300 1SCA022627R6430 0.63315 22,4 1 OFAF3H315 1SCA022627R6510 0.63355 23,5 1 OFAF3H355 1SCA022627R6600 0.63400 30,1 1 OFAF3H400 1SCA022627R6780 0.63425 33,0 1 OFAF3H425 1SCA022627R6860 1.00450 36 1 OFAF3H450 1SCA022627R6940 1.00500 44,0 1 OFAF3H500 1SCA022627R7080 1.00630 47,5 1 OFAF3H630 1SCA022627R7160 1.00800 56,9 1 OFAF3H800 1SCA022627R7240 0.904 400 31 1 OFAF4H400 1SCA022627R7320 2.0500 35 1 OFAF4H500 1SCA022627R7410 2.0630 44 1 OFAF4H630 1SCA022627R7590 2.0800 70 1 OFAF4H800 1SCA022627R7670 2.01000 85 1 OFAF4H1000 1SCA022627R7750 2.01250 93 1 OFAF4H1250 1SCA022627R7830 2.04a 500 33 1 OFAF4AH500 1SCA022637R3980 2.0630 43 1 OFAF4AH630 1SCA022637R4010 2.0800 58 1 OFAF4AH800 1SCA022637R4100 2.01000 71 1 OFAF4AH1000 1SCA022637R4280 2.01250 85 1 OFAF4AH1250 1SCA022637R4360 2.05/76 Automation Technologies1SKC000013C0201

FuseLineHRC Fuse links, type aM, 500VOrdering Details (continued)HRC Fuse-Links, aM, up to 500VS01558AOFAF3aM630AFusesS01559AS01560AOFAF1aM315AOFAF2aM400AIEC- I nPh Packingsize [A] [W] quantityType Order number Weight[pcs][kg]1 16 0,97 3 OFAF1AM16 1SCA022697R6330 0.2820 1,2 3 OFAF1AM20 1SCA022697R6410 0.2825 1,4 3 OFAF1AM25 1SCA022697R6500 0.2832 1,9 3 OFAF1AM32 1SCA022697R6680 0.2835 2 3 OFAF1AM35 1SCA022697R6760 0.2840 2,3 3 OFAF1AM40 1SCA022697R6840 0.2850 2,9 3 OFAF1AM50 1SCA022697R6920 0.2863 3,6 3 OFAF1AM63 1SCA022697R7060 0.2880 4,6 3 OFAF1AM80 1SCA022697R7140 0.28100 5,8 3 OFAF1AM100 1SCA022697R7220 0.28160 10,4 3 OFAF1AM160 1SCA022697R7490 0.30200 14,2 3 OFAF1AM200 1SCA022697R7570 0.30224 16,0 3 OFAF1AM224 1SCA022697R7650 0.30250 17,5 3 OFAF1AM250 1SCA022697R7730 0.30315 22,1 3 OFAF1AM315 1SCA022697R7810 0.302 35 1,8 3 OFAF2AM35 1SCA022697R8110 0.3240 2,1 3 OFAF2AM40 1SCA022697R8200 0.3250 2,7 3 OFAF2AM50 1SCA022697R8380 0.3263 3,4 3 OFAF2AM63 1SCA022697R8460 0.3280 4,4 3 OFAF2AM80 1SCA022697R8540 0.32100 5,5 3 OFAF2AM100 1SCA022697R8620 0.32125 6,4 3 OFAF2AM125 1SCA022697R8710 0.32160 9,3 3 OFAF2AM160 1SCA022697R8890 0.32200 11,3 3 OFAF2AM200 1SCA022697R8970 0.32224 16,0 3 OFAF2AM224 1SCA022697R9010 0.32250 16,8 3 OFAF2AM250 1SCA022697R9190 0.32300 21,0 3 OFAF2AM300 1SCA022697R9270 0.40315 23,1 3 OFAF2AM315 1SCA022697R9350 0.40355 26,0 3 OFAF2AM355 1SCA022697R9430 0.40400 29,7 3 OFAF2AM400 1SCA022697R9510 0.40500 34,4 3 OFAF2AM500 1SCA022697R9600 0.403 250 16 1 OFAF3AM250 1SCA022697R9780 0.45300 21 1 OFAF3AM300 1SCA022697R9860 0.45315 21 1 OFAF3AM315 1SCA022697R9940 0.45355 26,5 1 OFAF3AM355 1SCA022698R0010 0.45400 29,1 1 OFAF3AM400 1SCA022698R0100 0.45425 33 1 OFAF3AM425 1SCA022698R0280 0.60450 37 1 OFAF3AN450 1SCA022698R0360 0.60500 42 1 OFAF3AM500 1SCA022698R0440 0.60630 42 1 OFAF3AM630 1SCA022698R0520 0.60800 55 1 OFAF3AM800 1SCA022701R4790 0.60Automation Technologies5/771SKC000013C0201

FuseLineHRC Fuse links, type aM, 690VOrdering Details (continued)HRC Fuse-Links, aM, up to 690VS01561AOFAA1aM250AS01565AS01563AOFAA00aM100AS01564AS01562AOFAA000aM63AIECsizeI n[A]Ph[W]PackingquantityType Order number Weight[pcs][kg]000 2 0,08 9 OFAA000AM2 1SCA022660R7640 0.124 0,18 9 OFAA000AM4 1SCA022660R8020 0.126 0,26 9 OFAA000AM6 1SCA022660R8110 0.1210 0,46 9 OFAA000AM10 1SCA022660R8290 0.1216 0,72 9 OFAA000AM16 1SCA022660R8370 0.1220 0,92 9 OFAA000AM20 1SCA022660R8450 0.1225 1,2 9 OFAA000AM25 1SCA022660R8530 0.1232 1,5 9 OFAA000AM32 1SCA022660R8610 0.1235 1,6 9 OFAA000AM35 1SCA022660R8700 0.1240 1,8 9 OFAA000AM40 1SCA022660R8880 0.1250 2,3 9 OFAA000AM50 1SCA022660R8960 0.1263 2,9 9 OFAA000AM63 1SCA022660R9000 0.1200 80 3,6 3 OFAA00AM80 1SCA022701R1770 0.18100 5,2 3 OFAA00AM100 1SCA022701R1850 0.18125 7,5 3 OFAA00AM125 1SCA022701R1930 0.181 50 2,9 3 OFAA1AM50 1SCA022701R2070 0.2863 3,6 3 OFAA1AM63 1SCA022701R2150 0.2880 4,6 3 OFAA1AM80 1SCA022701R2230 0.28100 5,8 3 OFAA1AM100 1SCA022701R2310 0.28125 7,5 3 OFAA1AM125 1SCA022701R2400 0.30160 10,4 3 OFAA1AM160 1SCA022701R2580 0.30200 14,2 3 OFAA1AM200 1SCA022701R2660 0.30250 17,5 3 OFAA1AM250 1SCA022701R2740 0.302 125 6,4 3 OFAA2AM125 1SCA022701R2820 0.32160 9,3 3 OFAA2AM160 1SCA022701R2910 0.32200 11,3 3 OFAA2AM200 1SCA022701R3040 0.32250 16,8 3 OFAA2AM250 1SCA022701R3120 0.32315 23,1 3 OFAA2AM315 1SCA022701R3210 0.40355 25 3 OFAA2AM355 1SCA022701R3390 0.40400 29,7 3 OFAA2AM400 1SCA022701R3470 0.403 315 21 1 OFAA3AM315 1SCA022701R3550 0.45355 24,5 1 OFAA3AM355 1SCA022701R3630 0.45400 29,1 1 OFAA3AM400 1SCA022701R3710 0.45500 42 1 OFAA3AM500 1SCA022701R3800 0.60OFAA2aM400AOFAA3aM500A5/78 Automation Technologies1SKC000013C0201

SlimLineSwitch FusesDescriptionSlimLine a family of low voltage apparatusesFamily presentationSlimLine is a family of 3 pole and 4 pole switching devices in tier form for either horizontal or verticalinstallation in switchboards.The 3 frame sizes 50 mm, 100 mm and 200 mm are of a modular design, and can therefore easily becombined in a switchboard column.Compact designThe compact design of SlimLine offer space saving solution for the end user. This results in a costattractive switchboard system used in a large number of applications.Properties:• Type tested in accordance with IEC EN 60947/3• 160 A Ð 630 A for DIN NH HRC fuse links, in accordance with DIN VDE 0636 part 21and 22, IEC 269-1/EN60269-1• 63 A to 630 A for BS fuse links (Separate BS catalogue available)• 3 pole, 4 pole AC- and 2 pole DC version• Developed for plug-in switchboard systems• Horizontal or vertical installation• Front cover interlocked in “ON” position• IP41 degree of protection from the front• Intelligent Tier Switch (ITS) for remote monitoring• Maintenance free• High degree of personal safety• Modular design• Cable termination for cable lugs or cable clamps• Various depths• Plug in / out under voltage• Available with Electronic Fuse Monitoring (EFM)Advantages:• Compact design --> space saving --> total cost saving• Easy and fast to install• Low powerlosses --> high loading capacity• Wide range of accessories• True indication of switch positionAreas of applications• Motor control centers• Distribution boards– in building industry, shipping and oil and gaDIN version: SR-00 160ABS 88 version: SR-M 160AFusesDIN version: SR-1 250ABS 88 version: SR-M 250ADIN version: SR-2 400ASR-3 630ABS 88 version: SR-M 630AAutomation Technologies5/791SKC000013C0201

The Family members are:SlimLineSwitch FusesDescription (continued)SR-BSwitch-disconnector/load breakswitch with operating mechanism.Size 00, 1, 2, 3.AC 23 B, 690 VSR-ESwitch-fuse-disconnector withoperating mechanism.DIN fuses: Size 00, 1, 2, 3.AC 22 B, 500 VAC 21 B, 690 VSR-MSwitch-fuse-disconnector withoperating mechanism.Interuption on both sides of the fuses.DIN fuses: Size 00, 1, 2, 3.BS 88 fuses: 63 A, 100 A, 200 A, 400 A.AC 23 B, 690 VDC 22 B, 230 VDCSR-SPBusbar section switch withoperating mechanism for use betweentwo busbar systems in parallel.DIN fuses: Size 3.AC 23 B, 690 VSR-SSBusbar section switch withoperating mechanism for use betweentwo busbar systems in series.DIN fuses: Size 3.AC 23 B, 690 V4 Pole AC version• The 4th pole neutral switch (N)is located at the top of an SR-M3-pole unit.• The neutral switch is fully rated.• The neutral switch is switched“First in” and “Last out”.• Common cable shroud for the4th pole (N) for all sizes.2 Pole DC version• The SR-M DC is ratedup to 500 V DC.All SR versions are available for 3 busbar phase distances50 mm Distance between phases5 mm busbar60 mm Distance between phases5 or 10 mm busbar185 mm Distance between phases10 mm busbar5/80 Automation Technologies1SKC000013C0201

SlimLineSwitch FusesIntelligent Tier Switch (ITS)ITSSlimLine ITS ( Intelligent Tier Switch) is a SR with built incurrent, voltage and temperature sensors. Electronics forsignal conditioning and fieldbus interface is integrated tosupport LON bus.The ITS measures the following:• Current pr. phase• Voltage• Power• Temperature• Power factorThe ITS monitor the following:• Fuse status • Switch positionBased on these data the ITS gives alarms if fuses are blownor temperature or current exceeds your configured thresholds(over current).Fieldbus support to ITS:The fieldbus suppported is LonWorks with LonMarkcompatible network variables. The physicallayer is FTT10.How to interface the ITS:Use off-the-shelf hardware and software such as the iLonfrom Echelon, Internet Explorer from Microsoft and Palmyfrom MAC S.R.L.• For a local application use the Palmy and a LCL104 (if relaysignals are wanted).• For an Internet application use the iLon and InternetExplorer in addition.The local application:Daisy chain the ITS using prefabricated cables. Connectpower at one point. Connect the Palmy and install the ITSusing straightforward menus.The internet application:Use an iLon for internet/intranet connectivity. Get : IP-adress,subnetmask and default gateway from your computer networkadministrator. Download this to the iLon using the windowsaccessory HyperTerminal and the serial cable. Connectthe iLon to the daisy chain and to your computer network(Ethernet). Start viewing the measured values etc. on anyPC or Workstation in your network using Internet Explorer orNetscape. Webpage can be taylor made by ABB on request.AkWOPEN /CLOSEDVPF¡CSlimLine ITS, depth 200 or 400 mm:The SR-E ITS apparatus (SR-M BS ITS) are available in twoalternative depths:200 mm: Standard apparatus depth with triple CT’s on thecable terminal side.400 mm: Standard apparatus depth 200 mm + contactextension 200 mm with integrated 3 CT’s.FusesAutomation Technologies5/811SKC000013C0201

SlimLineSwitch FusesIntelligent Tier Switch ITS (continued)Palmy display unit:Local interface withthe Palmy MMIRelayblock LCL 104:Common alarms indicated onrelay contactsLON-busiLON Internet application:Remote interface with the iLon andstandard web-browsers such as IEor NetscapeEthernet5/82 Automation Technologies1SKC000013C0201

SlimLineSwitch FusesTechnical dataTYPE Size SR-E SR-M SR-B SR-M-DC SR-SS/SPRated operational 500 690 500 690 690 230 500 500 690voltage Ue (V)00 160 100 160 100 160 160 - -Rated operational 1 250 250 250 250current I e (A) 2 400 400 400 4003 630 630 630 630 630Rated insulation 1000 1000 1000 - 1000voltage U i (V)Rated impulsewithstand voltage 8000 8000 8000 - 8000Uimp (v)Fuse protected65 50 65 50short circuit making1001) 1001) 1001) 1001)(kArms)50 2) 60 50Fuse protected shortcircuit withstand 100 100 100 - 100(kArms)Rated making and AC22B AC23B AC23B DC23B DC21B AC23Bbreaking capacity :Rated frequency (Hz) 50 / 60 50 / 60 50 / 60 - 50 / 6000 2000 / 300 2000 / 300 2000 / 300 2000 / 300 2000 / 300Durability: 1 1600 / 200 1600 / 200 1600 / 200 1600 / 200 1600 / 200Total / With current 2 / 3 1000 / 200 1000 / 200 1000 / 200 1000 / 200 1000 / 200Degree of protectionfrom the front acc. IP 41 IP 41 IP 41 IP 41 IP 41to IEC / EN 60529Rated current with fuses must be reduced according to IEC 60439 when mounting switches into cubicles.1) Personal safe. (Welded switching contacts allowed).2) With maximum rated backup fuses.Powerlosses in SlimLineSize 00 1 2 3Rated Current (A) 160 250 400 630SR-E (W) 32,4 57,9 77,7 170,7SR-M (W) 38,7 72,9 113,7 214,5SR-B (W) 37,8 71,1 110,7 209,1FusesThe values given include all three phases, but without fuses.Automation Technologies5/831SKC000013C0201

SlimLineSwitch FusesAccessoriesCurrent transformer for SlimLine, 1 phase CT’sOrder code MBS No of Class VA Ratingtype PhasesSR-00NHSN718042P1015 ASR 201.3 1 1 3,75 150 / 1 With clampsNHSN718042P5015 ASR 201.3 1 1 3,75 150 / 5 With clampsNHSN718043P1015 ASG 210.3 1 1 3,75 150 / 1 With cables = 300 mmNHSN718043P5015 ASG 210.3 1 1 3,75 150 / 5 With cables = 300 mm1SEB000073-A1SEB000073-CFor SR-00 contact extension:NHSN718042P1015 ASR 201.3 1 / 3 1 3,75 150 / 1 With clampsNHSN718042P5015 ASR 201.3 1 / 3 1 3,75 150 / 5 With clamps1SEB000074-ASR-1NHSN718044P1025 ASR 42.45 1 1 7,5 250 / 1 With cables = 300 mmNHSN718044P5025 ASR 42.45 1 1 7,5 250 / 5 With cables = 300 mm1SEB000074-CFor SR-1 contact extension :NHSN718044P1025 ASR 42.45 1 / 3 1 7,5 250 / 1 With cables = 300 mmNHSN718044P5025 ASR 42.45 1 / 3 1 7,5 250 / 5 With cables = 300 mm1SEB000075-ASR-2 / 3NHSN718045P1040 ASK 31.3 1 / 3 1 10 400 / 1 With clampsNHSN718045P5040 ASK 31.3 1 / 3 1 10 400 / 5 With clampsNHSN718046P1040 ASK 31.3 1 / 3 0,5 5 400 / 1 With clampsNHSN718046P5040 ASK 31.3 1 / 3 0,5 5 400 / 5 With clampsNHSN718045P1060 ASK 31.3 1 / 3 1 10 600 / 1 With clampsNHSN718045P5060 ASK 31.3 1 / 3 1 10 600 / 5 With clampsNHSN718046P1060 ASK 31.3 1 / 3 0,5 5 600 / 1 With clampsNHSN718046P5060 ASK 31.3 1 / 3 0,5 5 600 / 5 With clamps1SEB000075-CFor SR-2/3 contact extension:NHSN718047P1030 ASK 41.4 1 / 3 1 10 300 / 1 With clampsNHSN718047P1040 ASK 41.4 1 / 3 1 10 400 / 1 With clampsNHSN718047P5030 ASK 41.4 1 / 3 1 10 300 / 5 With clampsNHSN718047P5040 ASK 41.4 1 / 3 1 10 400 / 5 With clampsNHSN718047P1050 ASK 41.4 1 / 3 1 10 500 / 1 With clampsNHSN718047P1060 ASK 41.4 1 / 3 1 10 600 / 1 With clampsNHSN718047P5050 ASK 41.4 1 / 3 1 10 500 / 5 With clampsNHSN718047P5060 ASK 41.4 1 / 3 1 10 600 / 5 With clamps5/84 Automation Technologies1SKC000013C0201

SlimLineSwitch FusesAccessories (continued)Current transformer for SlimLine, 3 phase CT’sOrder code MBS No of Class VA Ratingtype Phases1SEB000073-BSR-001SEP304462R0001 ASRD 210.3 3 1 1 50/1 With clamps1SEP304462R0002 ASRD 210.3 3 1 1 50/5 With clamps1SEP304462R0003 ASRD 210.3 3 1 1,5 100/1 With clamps1SEP304462R0004 ASRD 210.3 3 1 1,5 100/5 With clamps1SEP304462R0005 ASRD 210.3 3 1 2,5 150 / 1 With clamps1SEP304462R0006 ASRD 210.3 3 1 2,5 150 / 5 With clamps1SEP304462R0013 ASRD 210.3 3 0,5 1,5 100/1 With clamps1SEP304462R0014 ASRD 210.3 3 0,5 1,5 100/5 With clamps1SEP304462R0015 ASRD 210.3 3 0,5 2,5 150 / 1 With clamps1SEP304462R0016 ASRD 210.3 3 0,5 2,5 150 / 5 With clamps1SEB000073-DFor SR-00 contact extension:NHSN718042P1015 ASR 201.3 1 / 3 1 3,75 150 / 1 With clampsNHSN718042P5015 ASR 201.3 1 / 3 1 3,75 150 / 5 With clamps1SEB000074-BSR-11SEP408073R0001 Kit of Cu ext.bars for 3 phase CT’s ( 3xASK 231.5 )NHSN718048P1025 ASK 231.5 3 1 5 250 / 1 With clampsNHSN718048P5025 ASK 231.5 3 1 5 250 / 5 With clampsNHSN718049P1025 ASK 231.5 3 0,5 5 250 / 1 With clampsNHSN718049P5025 ASK 231.5 3 0,5 5 250 / 5 With clampsFor SR-1 contact extension:NHSN718044P1025 ASR 42.45 1 / 3 1 7,5 250 / 1 With cables = 300 mmNHSN718044P5025 ASR 42.45 1 / 3 1 7,5 250 / 5 With cables = 300 mm1SEB000074-D1SEB000075-BSR-2 / 31SEP407988R0001 Kit of Cu ext.bars for 3 phase CT’s ( 3xASK 31.3 )NHSN718045P1040 ASK 31.3 1 / 3 1 10 400 / 1 With clampsNHSN718045P5040 ASK 31.3 1 / 3 1 10 400 / 5 With clampsNHSN718046P1040 ASK 31.3 1 / 3 0,5 5 400 / 1 With clampsNHSN718046P5040 ASK 31.3 1 / 3 0,5 5 400 / 5 With clampsNHSN718045P1060 ASK 31.3 1 / 3 1 10 600 / 1 With clampsNHSN718045P5060 ASK 31.3 1 / 3 1 10 600 / 5 With clampsNHSN718046P1060 ASK 31.3 1 / 3 0,5 5 600 / 1 With clampsNHSN718046P5060 ASK 31.3 1 / 3 0,5 5 600 / 5 With clampsFuses1SEB000075-DFor SR-2/3 contact extension :NHSN718047P1030 ASK 41.4 1 / 3 1 10 300 / 1 With clampsNHSN718047P1040 ASK 41.4 1 / 3 1 10 400 / 1 With clampsNHSN718047P5030 ASK 41.4 1 / 3 1 10 300 / 5 With clampsNHSN718047P5040 ASK 41.4 1 / 3 1 10 400 / 5 With clampsNHSN718047P1050 ASK 41.4 1 / 3 1 10 500 / 1 With clampsNHSN718047P1060 ASK 41.4 1 / 3 1 10 600 / 1 With clampsNHSN718047P5050 ASK 41.4 1 / 3 1 10 500 / 5 With clampsNHSN718047P5060 ASK 41.4 1 / 3 1 10 600 / 5 With clampAutomation Technologies5/851SKC000013C0201

SlimLineSwitch FusesOrdering DetailsType designation Item description Order code WeightPer UnitSR-E 50 mmSR-E Switch fuse – 50 mm busbar distanceSR E00-50 3P 160A 50 mm 3 pole NHP 100220R6003 4,0SR E00-50 3P EFM 160A 50 mm 3 pole w/electr. fuse mon. NHP 100220R6013 4,0SR E1-50 3P 250A 50 mm 3 pole NHP 100221R6003 6,9SR E1-50 3P EFM 250A 50 mm 3 pole w/electr. fuse mon. NHP 100221R6013 6,9SR E2-50 3P 400A 50 mm 3 pole NHP 100232R6003 16,5SR E2-50 3P EFM 400A 50 mm 3 pole w/electr. fuse mon. NHP 100222R6013 16,5SR E3-50 3P 630A 50 mm 3 pole NHP 100223R6003 16,8SR E3-50 3P EFM 630A 50 mm 3 pole w/electr. fuse mon. NHP 100223R6013 16,8SR-M 50 mmSR-M Switch fuse – 50 mm busbar distanceSR M00-50 3P 160A 50 mm 3 pole NHP 100230R6003 4,1SR M00-50 3P EFM 160A 50 mm 3 pole w/electr. fuse mon. NHP 100230R6013 4,1SR M1-50 3P 250A 50 mm 3 pole NHP 100231R6003 6,9SR M1-50 3P EFM 250A 50 mm 3 pole w/electr. fuse mon. NHP 100231R6013 6,9SR M2-50 3P 400A 50 mm 3 pole NHP 100232R6003 16,5SR M2-50 3P EFM 400A 50 mm 3 pole w/electr. fuse mon. NHP 100232R6013 16,5SR M3-50 3P 630A 50 mm 3 pole NHP 100233R6003 16,8SR M3-50 3P EFM 630A 50 mm 3 pole w/electr. fuse mon. NHP 100233R6013 16,8SR-M 50 mm 4-poleSR-M Switch fuse 4-pole – 50 mm busbar distanceSR M00-50 4P 160A 50 mm 4 pole 1SEP102030R6001 6,2SR M00-50 4P EFM 160A 50 mm 4 pole w/electr. fuse mon. 1SEP102030R6003 6,2SR M1-50 4P 250A 50 mm 4 pole 1SEP102031R6001 9,0SR M1-50 4P EFM 250A 50 mm 4 pole w/electr. fuse mon. 1SEP102031R6003 9,0SR M2-50 4P 400A 50 mm 4 pole 1SEP102032R6001 18,5SR M2-50 4P EFM 400A 50 mm 4 pole w/electr. fuse mon. 1SEP102032R6003 18,5SR M3-50 4P 630A 50 mm 4 pole 1SEP102033R6001 18,8SR M3-50 4P EFM 630A 50 mm 4 pole w/electr. fuse mon. 1SEP102033R6003 18,8SR-M 50 mm DCSR-M Switch fuse 2-pole DC – 50 mm busbar distanceSR M00-50 DC 160A 50 mm 2 pole NHP 100830R6003 3,8SR M00-50 DC EFM 160A 50 mm 2 pole w/electr. fuse mon. NHP 100830R6013 3,8SR M1-50 DC 250A 50 mm 2 pole NHP 100830R6003 6,4SR M1-50 DC EFM 250A 50 mm 2 pole w/electr. fuse mon. NHP 100830R6013 6,4SR M2-50 DC 400A 50 mm 2 pole NHP 100830R6003 14,4SR M2-50 DC EFM 400A 50 mm 2 pole w/electr. fuse mon. NHP 100830R6013 14.4SR M3-50 DC 630A 50 mm 2 pole NHP 100830R6003 14,7SR M3-50 DC EFM 630A 50 mm 2 pole w/electr. fuse mon. NHP 100830R6013 14,7SR-B 50 mmSR-B Switch disconnector – 50 mm busbar distanceSR B00-50 3P 160A 50 mm 3 pole NHP 100240R6003 4,1SR B1-50 3P 250A 50 mm 3 pole NHP 100241R6003 7,6SR B2-50 3P 400A 50 mm 3 pole NHP 100242R0003 16,5SR B3-50 3P 630A 50 mm 3 pole NHP 100243R6003 16,8SR-SP 50 mmSR-S Bus-section Switch – 50 mm busbar distanceSR SP3-50 3P 630A 50 mm 3 pole – busbars in parallel NHP 100253R6003 14,2SR SS3-50 3P 630A 50 mm 3 pole – busbars in series NHP 100253R6006 14,5SR-SS 50 mm5/86 Automation Technologies1SKC000013C0201

SlimLineSwitch FusesOrdering Details (continued)Type designation Item description Order code WeightPer UnitSR-E 60 mmSR-E Switch fuse – 60 mm busbar distanceSR E00-60 3P 160A 60 mm 3 pole NHP 101020R6003 4,0SR E00-60 3P EFM 160A 60 mm 3 pole w/electr. fuse mon. NHP 101020R6013 4,0SR E1-60 3P 250A 60 mm 3 pole NHP 101021R6003 6,9SR E1-60 3P EFM 250A 60 mm 3 pole w/electr. fuse mon. NHP 101021R6013 6,9SR E2-60 3P 400A 60 mm 3 pole NHP 101032R6003 16,5SR E2-60 3P EFM 400A 60 mm 3 pole w/electr. fuse mon. NHP 101022R6013 16,5SR E3-60 3P 630A 60 mm 3 pole NHP 101023R6003 16,8SR E3-60 3P EFM 630A 60 mm 3 pole w/electr. fuse mon. NHP 101023R6013 16,8SR-M 60 mmSR-M Switch fuse – 60 mm busbar distanceSR M00-60 3P 160A 60 mm 3 pole NHP 101030R6003 4,1SR M00-60 3P EFM 160A 60 mm 3 pole w/electr. fuse mon. NHP 101030R6013 4,1SR M1-60 3P 250A 60 mm 3 pole NHP 101031R6003 6,9SR M1-60 3P EFM 250A 60 mm 3 pole w/electr. fuse mon. NHP 101031R6013 6,9SR M2-60 3P 400A 60 mm 3 pole NHP 101032R6003 16,5SR M2-60 3P EFM 400A 60 mm 3 pole w/electr. fuse mon. NHP 101032R6013 16,5SR M3-60 3P 630A 60 mm 3 pole NHP 101033R6003 16,8SR M3-60 3P EFM 630A 60 mm 3 pole w/electr. fuse mon. NHP 101033R6013 16,8SR-M 60 mm 4-poleSR-M Switch fuse 4-pole – 60 mm busbar distanceSR M00-60 4P 160A 60 mm 4 pole 1SEP102130R6001 6,2SR M00-60 4P EFM 160A 60 mm 4 pole w/electr. fuse mon. 1SEP102130R6003 6,2SR M1-60 4P 250A 60 mm 4 pole 1SEP102131R6001 9,0SR M1-60 4P EFM 250A 60 mm 4 pole w/electr. fuse mon. 1SEP102131R6003 9,0SR M2-60 4P 400A 60 mm 4 pole 1SEP102132R6001 18,5SR M2-60 4P EFM 400A 60 mm 4 pole w/electr. fuse mon. 1SEP102132R6003 18,5SR M3-60 4P 630A 60 mm 4 pole 1SEP102133R6001 18,8SR M3-60 4P EFM 630A 60 mm 4 pole w/electr. fuse mon. 1SEP102133R6003 18,8SR-M 60 mm DCSR-M Switch fuse 2-pole DC – 60 mm busbar distanceSR M00-60 DC 160A 60 mm 2 pole NHP 101130R6003 3,8SR M00-60 DC EFM 160A 60 mm 2 pole w/electr. fuse mon. NHP 101130R6013 3,8SR M1-60 DC 250A 60 mm 2 pole NHP 101131R6003 6,4SR M1-60 DC EFM 250A 60 mm 2 pole w/electr. fuse mon. NHP 101131R6013 6,4SR M2-60 DC 400A 60 mm 2 pole NHP 101132R6003 14,4SR M2-60 DC EFM 400A 60 mm 2 pole w/electr. fuse mon. NHP 101132R6013 14.4SR M3-60 DC 630A 60 mm 2 pole NHP 101133R6003 14,7SR M3-60 DC EFM 630A 60 mm 2 pole w/electr. fuse mon. NHP 101133R6013 14,7SR-B Switch disconnector – 60 mm busbar distanceSR B00-60 3P 160A 60 mm 3 pole NHP 101040R6003 4,1SR B1-60 3P 250A 60 mm 3 pole NHP 101041R6003 7,6SR B2-60 3P 400A 60 mm 3 pole NHP 101042R0003 16,5SR B3-60 3P 630A 60 mm 3 pole NHP 101043R6003 16,8FusesSR-B 60 mmNote!10 mm thickness as standard.5 mm delivered on request.Automation Technologies5/871SKC000013C0201

SlimLineSwitch FusesOrdering Details (continued)Type designation Item description Order code WeightPer UnitSR-E 185 mmSR-E Switch fuse – 185 mm busbar distanceSR E00-185 3P 160A 185 mm 3 pole NHP 100420R6003 4,0SR E00-185 3P EFM 160A 185 mm 3 pole w/electr. fuse mon. NHP 100420R6013 4,0SR E1-185 3P 250A 185 mm 3 pole NHP 100421R6003 6,9SR E1-185 3P EFM 250A 185 mm 3 pole w/electr. fuse mon. NHP 100421R6013 6,9SR E2-185 3P 400A 185 mm 3 pole NHP 100422R6003 16,5SR E2-185 3P EFM 400A 185 mm 3 pole w/electr. fuse mon. NHP 100422R6013 16,5SR E3-185 3P 630A 185 mm 3 pole NHP 100423R6003 16,8SR E3-185 3P EFM 630A 185 mm 3 pole w/electr. fuse mon. NHP 100423R6013 16,8SR-M 185 mmSR-M Switch fuse – 185 mm busbar distanceSR M00-185 3P 160A 185 mm 3 pole NHP 100430R6003 4,1SR M00-185 3P EFM 160A 185 mm 3 pole w/electr. fuse mon. NHP 100430R6013 4,1SR M1-185 3P 250A 185 mm 3 pole NHP 100431R6003 6,9SR M1-185 3P EFM 250A 185 mm 3 pole w/electr. fuse mon. NHP 100431R6013 6,9SR M2-185 3P 400A 185 mm 3 pole NHP 100432R6003 16,5SR M2-185 3P EFM 400A 185 mm 3 pole w/electr. fuse mon. NHP 100432R6013 16,5SR M3-185 3P 630A 185 mm 3 pole NHP 100433R6003 16,8SR M3-185 3P EFM 630A 185 mm 3 pole w/electr. fuse mon. NHP 100433R6013 16,8SR-M 185 mm 4-poleSR-M Switch fuse 4-pole – 185 mm busbar distanceSR M00-185 4P 160A 185 mm 4 pole 1SEP102330R6001 6,2SR M00-185 4P EFM 160A 185 mm 4 pole w/electr. fuse mon. 1SEP102330R6003 6,2SR M1-185 4P 250A 185 mm 4 pole 1SEP102331R6001 9,0SR M1-185 4P EFM 250A 185 mm 4 pole w/electr. fuse mon. 1SEP102331R6003 9,0SR M2-185 4P 400A 185 mm 4 pole 1SEP102332R6001 18,5SR M2-185 4P EFM 400A 185 mm 4 pole w/electr. fuse mon. 1SEP102332R6003 18,5SR M3-185 4P 630A 185 mm 4 pole 1SEP102333R6001 18,8SR M3-185 4P EFM 630A 185 mm 4 pole w/electr. fuse mon. 1SEP102333R6003 18,8SR-M 185 mm DCSR-M Switch fuse 2-pole DC – 185 mm busbar distanceSR M00-185 DC 160A 185 mm 2 pole NHP 100930R6003 3,8SR M00-185 DC EFM 160A 185 mm 2 pole w/electr. fuse mon. NHP 100930R6013 3,8SR M1-185 DC 250A 185 mm 2 pole NHP 100931R6003 6,4SR M1-185 DC EFM 250A 185 mm 2 pole w/electr. fuse mon. NHP 100931R6013 6,4SR M2-185 DC 400A 185 mm 2 pole NHP 100932R6003 14,4SR M2-185 DC EFM 400A 185 mm 2 pole w/electr. fuse mon. NHP 100932R6013 14.4SR M3-185 DC 630A 185 mm 2 pole NHP 100933R6003 14,7SR M3-185 DC EFM 630A 185 mm 2 pole w/electr. fuse mon. NHP 100933R6013 14,7SR-B Switch disconnector – 185 mm busbar distanceSR B00-185 3P 160A 185 mm 3 pole NHP 100440R6003 4,1SR B1-185 3P 250A 185 mm 3 pole NHP 100441R6003 7,6SR B2-185 3P 400A 185 mm 3 pole NHP 100442R0003 16,5SR B3-185 3P 630A 185 mm 3 pole NHP 100443R6003 16,8SR-B 185 mm5/88 Automation Technologies1SKC000013C0201

SlimLineSwitch FusesOrdering Details (continued)Contact extension 50 mmContact extension 185 mmCurrent transformerType designation Item description Order code WeightPer UnitACCESSORIES Size 00SR-00 Contact terminal singlefor 2, 3 and 4 pole NHP 403974R0001 0,04SR-00 Contact extension for 50 mm NHP 100011R0001 1,6SR-00 Contact extension for 185 mm NHP 100803R0001 1,7SR-00 Contact extension for 50 mm 4P NHP 101364R0001 2,0SR-00 Current transformer (150/1A) ASR 201.3, 3,75 VA, Cl. 1 NHSN718042P1015 0,1SR-00 Current transformer (150/5A). ASR 201.3, 3,75 VA, Cl. 1 NHSN718042P5015 0,1SR-00 Current transformer (150/1A). ASG 201.3, 3,75 VA, Cl. 1 NHSN718043P1015 0,1SR-00 Current transformer (150/5A). ASG 201.3, 3,75 VA, Cl. 1 NHSN718043P5015 0,1SR-00 A-meter 0-150-180/1A NHSN714003P0150 0,1SR-00 A-meter 0-150-180/5A NHSN714003P1150 0,1SR-00 Auxiliary switch 1NO+1NC NHP 404640R0001 0,05SR-00 Auxiliary switch 2NO+2NC NHP 404640R0002 0,1SR-00 Front cover with handle SR-M NHP 302073R6001 0,4SR-00 Front cover with handle SR-E NHP 302073R6002 0,4SR-00 Front cover with handle SR-B NHP 302073R6003 0,4SR-00 Cable terminal shroud NHP 405670R0001 0,1AmmeterCable terminal shroudSize 00ACCESSORIES Size 1SR-1 Cable clamp, single for 2, 3 and 4 pole NHP 406123R0001 0,1SR-1 Cable clamp, double for 2, 3 and 4 pole NHP 404323R0001 0,1SR-1 Contact extension for 50 mm NHP 100014R0001 2,3SR-1 Contact extension for 185 mm NHP 100855R0001 2,4SR-1 Contact extension for 50 mm 4P NHP 101376R0001 2,7SR-1 Current transformer (250/1A) ASR 42.45 7,5 VA, Cl.1. NHSN718044P1025 0,2SR-1 Current transformer (250/5A) ASR 42.45 7,5 VA, Cl.1. NHSN718044P5025 0,2SR-1 Kit of Cu ext.bars for 3 phase CT’s Prepared for 3 x ASK 231.5 1SEP408073R0001 0,2SR-1 Current transformer 250/1 A ASK 231.5 5VA, Cl.1 NHSN718048P1025 0,2SR-1 Current transformer 250/5 A ASK 231.5 5VA,Cl.1 NHSN718048P5025 0,2SR-1 Current transformer 250/1 A ASK 231.5 5VA, Cl.0,5 NHSN718049P1025 0,2SR-1 Current transformer 250/5 A ASK 231.5 5VA, Cl.0,5 NHSN718049P5025 0,2Auxiliary switchDouble cableclamp size 1Single cable clampsize 1SR-1 3-phase CT Cable Kit of 3 pcs GLBS200526R0001 0,2terminal shroud, 50-120mm2SR-1 3-phase CT Cable terminal Kit of 3 pcs GLBS200526R0003 0,2shroud, 150-240 mm2SR-1 A-meter 0-150-180/1A NHSN714003P0250 0,1SR-1 A-meter 0-150-180/5A NHSN714003P1250 0,1SR-1/2/3 A-meter bracket NHP 200829R0001 0,05SR-1 Auxiliary switch 1NO+1NC NHP 404641R0001 0,1SR-1 Auxiliary switch 2NO+2NC NHP 404641R0002 0,1SR-1 Front cover with handle SR-M NHP 302073R6004 0,4SR-1 Front cover with handle SR-E NHP 302073R6005 0,4SR-1 Front cover with handle SR-B NHP 302073R6006 0,4SR-1 Cable terminal shroud for NHP 405670R0003 0,1double clampsSR-1 Cable terminal shroud cable lug NHP 405670R0004 0,1SR-1 Cable terminal shroud universal NHP 405670R0006 0,1FusesCable term. shroud size 1Automation Technologies5/891SKC000013C0201

SlimLineSwitch FusesOrdering Details (continued)Type designation Item description Order code WeightPer UnitACCESSORIES Size 2SR-2/3 Cable clamp, double for 2 and 3 pole NHP 406124R0001 0,05SR-2/3 Cable clamp, double for 4th pole NHP 406124R0002 0,05SR-2/3 Contact extension for 50 mm NHP 100495R0001 8,3SR-2 /3Contact extension for 185 mm NHP 100886R0001 8,4SR-2/3 Contact extension for 50 mm 4P 1SEP101861R0001 9,2Double cable clamp size 2/3SR-2 Current transformer (400/1A) ASK 31.3 10 VA, Cl.1. NHSN718045P1040 0,3SR-2 Current transformer (400/5A) ASK 31.3 10 VA, Cl.1. NHSN718045P5040 0,3SR-2 Current transformer (400/1A) ASK 31.3 5 VA, Cl.0,5. NHSN718046P1040 0,3SR-2 Current transformer (400/5A) ASK 31.3 5 VA, Cl.0,5. NHSN718046P5040 0,3SR-2/3 Kit of Cu ext.bars for 3 phase CT’s Prepared for 3 x ASK 1SEP407988R000131.3SR-2 Current transf for Contact Ext. (300/1A) ASK 41.4, 10 VA Cl.1. NHSN718047P1030 0,3SR-2 Current transf for Contact Ext. (400/1A) ASK 41.4, 10 VA Cl.1. NHSN718047P1040 0,3SR-2 Current transf for Contact Ext. (300/5A) ASK 41.4, 10 VA Cl.1. NHSN718047P5030 0,3SR-2 Current transf for Contact Ext. (400/5A) ASK 41.4, 10 VA Cl.1. NHSN718047P5040 0,3Ammeter bracketSR-2 A-meter 0-150-180/1A NHSN714003P0400 0,1SR-2 A-meter 0-150-180/5A NHSN714003P1400 0,1SR-1/2/3 A-meter bracket NHP 200829R0001 0,05SR-2/3 Auxiliary switch 1NO+1NC NHP 404721R0001 0,05SR-2/3 Auxiliary switch 2NO+2NC NHP 404721R0002 0,05SR-2 Front cover with handle SR-M NHP 302073R6007 0,7SR-2 Front cover with handle SR-E NHP 302073R6008 0,7SR-2 Front cover with handle SR-B NHP 302073R6009 0,7SR-2/3 Cable terminal shroud NHP 405670R0005 0,1ACCESSORIES Size 3SR-2/3 Cable clamp, double for 2 and 3 pole NHP 406124R0001 0,05SR-2/3 Cable clamp, double for 4th pole NHP 406124R0002 0,05SR-2/3 Contact extension for 50 mm NHP 100495R0001 8,3SR-2 /3 Contact extension for 185 mm NHP 100886R0001 8,4SR-SP3 Contact extension NHP 100495R0002 9,3SR-2/3 Contact extension for 50 mm 4P 1SEP101861R0001 9,2SR-3 Current transformer (600/1A) ASK 31.3 10 VA, Cl.1. NHSN718045P1060 0,3SR-3 Current transformer (600/5A) ASK 31.3 10 VA, Cl.1. NHSN718045P5060 0,3SR-3 Current transformer (600/1A) ASK 31.3 5 VA, Cl.0,5 NHSN718046P1060 0,3SR-3 Current transformer (600/5A) ASK 31.3 5 VA, Cl.0,5. NHSN718046P5060 0,3SR-2/3 Kit of Cu ext.bars for 3 phase CT’s Prepared for 3 x ASK 1SEP407988R0001 31.3SR-3 Current transf for Contact Ext. (500/1A) ASK 41.4, 10 VA Cl.1 NHSN718047P1050 0,3SR-3 Current transf for Contact Ext. (500/1A) ASK 41.4, 10 VA Cl.1 NHSN718047P1060 0,3SR-3 Current transf for Contact Ext. (500/5A) ASK 41.4, 10 VA Cl.1 NHSN718047P5050 0,3SR-3 Current transf for Contact Ext. (600/5A) ASK 41.4, 10 VA Cl.1 NHSN718047P5060 0,3Cable term. shroud, size 2/3SR-3 A-meter 0-150-180/1A NHSN714003P0600 0,1SR-3 A-meter 0-150-180/5A NHSN714003P1600 0,1SR-1/2/3 A-meter bracket NHP 200829R0001 0,05SR-2/3 Auxiliary switch 1NO+1NC NHP 404721R0001 0,05SR-2/3 Auxiliary switch 2NO+2NC NHP 404721R0002 0,05SR-3 Front cover with handle SR-M NHP 302073R6010 0,7SR-3 Front cover with handle SR-E NHP 302073R6011 0,7SR-3 Front cover with handle SR-B NHP 302073R6012 0,7SR-2/3 Cable terminal shroud NHP 405670R0005 0,15/90 Automation Technologies1SKC000013C0201

SlimLineSwitch FusesOrdering Details (continued)Type designation Item description Order code WeightPer UnitCassette systemCassette systemSR - SlimLine cassette 185mm/500mm NHP 101604R0001 12,7SR - SlimLine cassette 185mm/1000mm NHP 101604R0002 21,2SR - SlimLine cassette 185mm/1500mm NHP 101604R0003 30,0SR - SlimLine cassette 185mm/2000mm NHP 101604R0004 38,0SR - SlimLine cassette 60mm/500mm NHP 101604R0011 12,7SR - SlimLine cassette 60mm/1000mm NHP 101604R0012 21,2SR - SlimLine cassette 60mm/1500mm NHP 101604R0013 30,0SR - SlimLine cassette 60mm/2000mm NHP 101604R0014 38,0SR - IP20 busbar cover 500mm NHP 407062R0001 1,5SR - IP20 busbar cover 1000mm NHP 407062R0002 2,8SR - IP20 busbar cover 1500mm NHP 407062R0003 4,1SR - IP20 busbar cover 2000mm NHP 407062R0004 5,4SR - Single IP20 busbar cover 200mm NHP 101474P0001 0,5Service moduleFront cover keyCable terminal keyService moduleSR - Service module top/bottom seg. plate NHP 101155R0001 0,2SR - Service module mount. plate 100mm NHP 405897R0001 0,8SR - Service module mount. plate 200mm NHP 405897R0002 1,5SR - Service module mount. plate 300mm NHP 405897R0003 2,2SR - Service module mount. plate 400mm NHP 405897R0004 2,9SR - Front blind cover 100mm hinged NHP 101323R6001 1,4SR - Front blind cover 200mm hinged NHP 101323R6002 2,5SR - Front blind cover 300mm hinged NHP 101323R6003 3,6SR - Front blind cover 400mm hinged NHP 101323R6004 4,7SR - Front blind cover 100mm hinged NHP 101323R0011 4,7w/ 60 mm co.SR - Front blind cover 200mm hinged NHP 101323R0012 2,5w/ 160 mm co.SR - Front blind cover 300mm hinged NHP 101323R0013 3,6w/ 160 mm co.SR - Front blind cover 400mm hinged NHP 101323R0014 4,7w/ 160 mm co.SR - Busbar connection module NHP 101194R0001 2,260mm/400ASR - Busbar connection module NHP 101193R0001 3,4185mm/400ACable terminal torque keyVentilated blind coverReplacement toolCommon accessoriesSR - Main controller MC50 NHP 303821R0001 0,2SR - Cable terminal key (tool) NHSN950001P0006 0,6SR - Cable terminal torque key (tool) NHSN950001P0002 2,0SR - Extension for torque key NV1 NHSN950001P0001 0,4SR - Front cover key GMN 436770P0022 0,1SR - Replacement tool for size 00, 1, 2 & 3 1SEP304128R0001 1,2SR - Ventilated blind cover 50mm IP41 NHP 405609R6001 0,8SR - Module guide rails 200mm NHP 200947R0002 1,3SR - Module guide rails 400mm NHP 200947R0003 1,8SR - Module guide rails 400mm, MNS NHP 200947R0001 1,1SR - SLM Blind cover 12,5 mm1SEP407947R6001SR - SLM Blind cover 25 mm1SEP407947R6002SR - SLM Blind cover 37,5 mm1SEP407947R6003SR - Cable terminal shroud 4th pole 1SEP407775R0001 0,1SR - Marking labels, 50 pcs 1SEP407969R0001 0,06FusesModule guide railsAutomation Technologies5/911SKC000013C0201

SlimLineSwitch FusesOrdering Details (continued)Type designation Item description Order code WeightPer UnitSlimLine SR00ITSFor DIN / NH Fuse links w/ 50 mm Busbar distanceSR E00-50 3P IT2 160A 50mm 3-pole ITS for cable NHP 100220R6043 4,0lugs Depth 200 mmSR E1-50 3P IT2 250A 50mm 3-pole ITS for cable NHP 100221R6043 6,9lugs Depth 200 mmSR E2-50 3P IT2 400A 50mm 3-pole ITS for cable NHP 100222R6043 16,5lugs Depth 200 mmSR E3-50 3P IT2 630A 50mm 3-pole ITS for cable NHP 100223R6043 16,8lugs Depth 200 mmSR E00-50 3P IT4 160A 50mm 3-pole ITS for cable NHP 100220R6033 5,8lugs Depth 400 mmSR E1-50 3P IT4 250A 50mm 3-pole ITS for cable NHP 100221R6033 9,5lugs Depth 400 mmSR E2-50 3P IT4 400A 50mm 3-pole ITS for cable NHP 100222R6033 25,9lugs Depth 400 mmSR E3-50 3P IT4 630A 50mm 3-pole ITS for cable NHP 100223R6033 26,2lugs Depth 400 mmPalmy display unitFor DIN / NH Fuse links w/ 185 mm Busbar distanceSR E00-185 3P IT2 160A 50mm 3-pole ITS for cable NHP 100420R6043 4,0lugs Depth 200 mmSR E1-185 3P IT2 160A 50mm 3-pole ITS for cable NHP 100421R6043 6,9lugs Depth 200 mmSR E2-185 3P IT2 160A 50mm 3-pole ITS for cable NHP 100422R6043 16,5lugs Depth 200 mmSR E3-185 3P IT2 160A 50mm 3-pole ITS for cable NHP 100423R6043 16,8lugs Depth 200 mmSR E00-185 3P IT4 160A 50mm 3-pole ITS for cable lugs. NHP 100420R6033 5,8Depth 400 mmSR E1-185 3P IT4 160A 50mm 3-pole ITS for cable lugs NHP 100421R6033 9,5Depth 400 mmSR E2-185 3P IT4 160A 50mm 3-pole ITS for cable lugs NHP 100422R6033 25,9Depth 400 mmSR E3-185 3P IT4 160A 50mm 3-pole ITS for cable lugs NHP 100423R6033 26,2Depth 400 mmRelayblock LCL 104ITS EquipmentSR-ITS Palmy display1SEP304318R0002SR-ITS Relayblock LCL 104 with cableconn. Palmy-LCL 1041SEP304318R0003SR-ITS Palmy mount.plate w/ cut out Metal plate in Aluzink 1SEP408122R0001SR- ITS Cable connection SR ITS Palmy L=3000 mm 1SEP407929R0001 0,1SR-ITS Cable connection SR ITS - SR ITS, L=500 mm 1SEP407797R0001 0,1SR-ITS iLON web server 1SEP304319R0001 0,7iLon web serverExplanation:SR E / M / B 00 / 1 / 2 / 3 ITS 50 / 185 DC / 3P / 4P EFM DepthFamily Type Size Intelligent Distance Number Electronic 200/400 mmTier between of poles fuseSwitch fases monitoring5/92 Automation Technologies1SKC000013C0201

EasyLineFuse SwitchsDescriptionA new generation designed for youProduct presentationEasyLine is the new complete generation of fuse switchdisconnectors including the following members:3 Pole· XLP 000 100 Amp· XLP 00 160 Amp· XLP 1 250 Amp· XLP 2 400 Amp· XLP 3 630 Amp4 Pole· SLP 00 160 Amp· SLP 1 250 Amp· SLP 2 400 Amp· SLP 3 630 AmpProperties of the EasyLine XLP:· Compact XLP 000· Typetested according to EN IEC 60947- 3· Fullfills BGV A2· Easy to recycle / EN ISO 14001 standards· Quick- make operation device· Integrated IP 20 cable termination· IP 30 degree of protection from the front· Replacement compatible to similar types inthe market· Voltage measuring from the front· V- 0 plastic materialsAdvantages of the EasyLine XLP:· Easy to install· Easy to snap on DIN rails· Easy to operate· Easy to understand· Modern cable terminals· Modern and functional design· Additional arc protection shroud in frontcover- increased personal safety· Wide range of modern cable clamps andaccessories· Electronice fuse monitoring· Wide range of busbar adaptersApplications of EasyLine fuse protection:· Installation· Switchboards· Distribution systems· OEM’sBusbar adapters for XLP 00 and XLP 160 mm Busbar systemDesigned for 60 mm busbar distanceCu/ Al 5/ 10x10,12, 20, 25 or 30 mm.3 pieces of distance shoes for 5 mm busbars are included with the adapter.Adapter 60 mm for cable connection below : A 60 - DownAdapter 60 mm for cable above : A 60 - UpDistribution system for standard Busbars type SF- 60The busbar system type SF- 60 is designed to take busbars of different cross sections,and it is type tested to VDE- 0660, section 50 and IEC 439- 1.The SF- 60 Busbar system features:Busbar width: 12 - 30 mmBusbar thickness: 5 - 10 mmCentre distance between busbars: 60 mmFuses40 mm Busbar system for XLP 00Cu 12x5 or 12x10 mm.Adapter 95 mm depth to busbars : A 40/ 9540 mm Busbar system for Striebel & John switchboardsSpecially designed for the Striebel & John Busbar system 250 A and 360 ACu 12x5 or 12x10 mm.Adapter 75 mm depth to busbars, cable connection below : A 40/ 75Adapter 120 mm depth to busbars, cable connection below : A 40/ 120Automation Technologies5/931SKC000013C0201

EasyLineFuse SwitchesAccessories DescriptionCable clamps and boltsXLP 00Type Conductor cross section min-m Ordering detailsBusbars Conductor Rm/Sm Re/Se Torque Type No.HxWmm flexible mm 2 mm 2 mm 2 Nm**Cage Clamps (cc) 1.5 - 25 1.5 - 35 1.5 - 35 3.2 Included in the switchXLP 00Type Conductor cross section min-m Ordering detailsBusbars Conductor Rm/Sm Re/Se Torque Type No.HxWmm flexible mm 2 mm 2 mm 2 Nm**Bridge Clamp (BC)Triple Clamp (TC)Single Prism Clamp (SPC)Feeding Clamp (FC) 6BCBolt M8x16 DIN 933Bolt M8x16 DIN 933 forCable lug DIN 46234Bolt M8x16 DIN 933 forCable lug DIN 462354 x 201.5- 351.0- 101.5- 1625 - 5025- 7010 - 9516 - 701.5- 501.0- 101.5- 1625- 7025- 9510 - 9516 - 701.5- 501.0- 101.5- 1625- 7025- 9510 - 9516 - 703.23.53.510101SEP 407733 R00011SEP407787R00011SEP407732R00011SEP407811R0001NHP 400940R0006XLP 1Type Conductor cross section min-m Ordering detailsBusbars Conductor Rm/Sm Re/Se Torque Type No.HxWmm flexible mm 2 mm 2 mm 2 Nm**Bridge Clamp (BC)Single Prism Clamp (SPC)Double Prism Clamp (DPC)Bolt M8x16 DI.33Bolt M8x16 DIN 933 forCable lug DIN 46234Bolt M8x16 DIN 933 forCable lug DIN 46235XLP 2/3Bridge Clamp (BC)Single Prism Clamp (SPC)Double Prism Clamp (DPC)Bolt M8x16 DIN 933Bolt M8x16 DIN 933 forCable lug DIN 46234Bolt M8x16 DIN 933 forCable lug DIN 4623510 x1910 x4026 x 1450 x 1216- 7016- 7095- 1502x70 -2x9510- 24016- 24016- 30070- 24016- 24025- 952x35 -2x12010- 24016- 30016- 9516- 9595- 185*2x70 -2x12010- 24016- 24016- 30050- 18516- 24025- 702x35 -2x15010- 24016- 30016- 9516- 9595- 1502x70 -2x12010- 24016- 24016- 30050- 18516- 24025- 702x35 -2x150/2x50 -2x18510- 24016- 30010101010141422251SEP407733R00021SEP407732R0002NHP403631R0001NHP403625R0001Type Conductor cross section min-m Ordering detailsBusbars Conductor Rm/Sm Re/Se Torque Type No.HxWmm flexible mm 2 mm 2 mm 2 Nm**1SEP407953R00011SEP407954R00011SEP407956R0001NHP403626R0001Note: tested according to standard: EN IEC 60947- 1 and DIN VDE 0295.Explanations:Flexible: Multi strandedSe: Sector shaped solidSm: Sector shaped strandedRe: Round solidRm: Round stranded*) The Sm (sector shaped stranded) 150 mm2 and 185 mm2 have to be round formed before insertedin the Prism Clamp.**) For correct Torque (Nm) values, please study the installation description delivered with the devices.5/94 Automation Technologies1SKC000013C0201

EasyLineFuse SwitchesAccessories Description (continued)Electronic Fuse MonitortThe fuse monitor is a fuse blown monitoring and indication device.It will be automatically reset after the blown fuse has been replacedand the green LED turns on again.The matrix below show all possible cases of indication.Status XLP EFM Led Green Led Red NO contact 13. 14 NC contact 11. 12Fuse status Voltage on phases Illuminated dark Illuminated dark open closed open closedSwitch closed:Switch closed:Fuse OKFuse OKFuse OKFuse BlownFuse BlownFuse BlownPhases OK1 Phases loss2, 3 Phases lossPhases OK1 Phases loss2, 3 Phsses lossxx (L1)x (L1,L2)xxxxxx (L1)xxxx (L2,L3)xxxxx (L2,L3)xx (L1)xx (L1)xxxx (L2,L3)xSwitch Open:Fuse OKFuse OKFuse BlownFuse BlownPhases OKPhases lossPhases OKPhases lossxxxxxxxxxxxxxxxxx (L1):x (L2, L3):The case if Phase L1 is lostThe case if Phase L2 or L3 both are lostThe fuse monitor is connected to the gripping lugs of the fuses.Technical data :Minimum operation voltage: 400V - 15%Maximum operation voltage: 690V - 12%Uimp over a blown fuse:12,3 kVUimp between phases:9.8 kVUimp between main circuit/relay contacts.:9.8 kVDielectric test voltage input / output:3.5 kV / 50 Hz / 1 minuteElectrostatic Discharge: EN61000-4-2 +/- 4 kVElectrical Fast Transient: EN61000-4-4 +/- 2 kVConducted Fast Transient:EN61000-4-6 10Vrms / 150kHz Ð 80 MHzConnector: MSTB 2,5/4 - ST - 5,08Wire size:AWG 22-12 / 0.2-2.5mm2EMC tested:YesFusesRelay:Nominal current:Nominal switching capacity:Maximum switching voltage:8 amp2000VA, AC1440V AC, 250V DCNote:· Insulated gripping lugs can not be used.· The fuse monitor requires that the supply side of the XLP should be on top of the switch.Automation Technologies5/951SKC000013C0201

EasyLineFuse SwitchesTechnical Data3 PoleDescription XLP 000 XLP 00 XLP 1 XLP 2 XLP 3Fuse size acc. to DIN 43620 /00000123IEC / EN 60269- 2- 1Rated operational voltage UeRated operational current IeThermal current w/ fuse link lthRated insulation voltage UiRated impulse withstand voltage UimpFuse protected short circuit makingVAAVVkArmsMax. W=21 mm400 500 69080 100 50100690600050400 500 690125 160 1251601000800050400 500 690250 2002501000800050400 500 690400 3154001000800050400 500 690630 5006301000800050Rated making and breaking capacity :Rated frequencyPower loss at Ith without fuse link/ phaseHzWAC23B AC22B AC21B50/601.4AC23B AC22B AC21B50/603.5AC23B AC22B AC21B50/607.5AC23B AC22B AC21B50/6013AC23B AC22B AC21B50/6024Electrical durability300200200200200Mechanical durabilityDegree of protection from the frontacc. to IEC / EN 60529 ClosedOpenClosed1700IP20IP301400IP20IP301400IP20IP30800IP20IP30800IP20IP304 PoleDescription SLP 00 SLP 1 SLP 2 SLP 3Fuse size acc. to DIN 43620 /00123IEC / EN 60269- 2- 1Rated operational voltage UeV400400400400Rated operational current IeA160250400630Rated insulation voltage UiV1000100010001000Rated impulse withstand voltage UimpV8000800080008000Fuse protected short circuit makingkArms50505050Rated making and breaking capacity :400VacAC22BAC22BAC22BAC22BRated frequencyHz50/6050/6050/6050/60Degree of protection from the frontOpenIP10IP10IP10IP10acc. to IEC / EN 60529 ClosedClosedIP30IP30IP30IP30The products are designed and tested in accordance with IEC / EN 60947- 3.Additionally, all development and production activities are in compliance with the QualitySystem Standard EN ISO 9001 and Environmental Standards EN ISO 14001.5/96 Automation Technologies1SKC000013C0201

EasyLineFuse Switches, XLPOrdering DetailsXLP 000 ApparatusDescription Designation Ordering details Pack. WeightType No. Unit 1 pc/kgXLP 000-6CC 100 A Fuse switch disconnector incl.6 CC 1SEP 201428 R0001 1 0.46XUP 000-6CC 100 A Fuse Base incl. 6 CC1SEP 201432 R0001 1 0.34XLP 00 ApparatusDescription Designation Ordering details Pack. WeightType No. Unit 1 pc/kgXLP 00XLP 00-6BCXLP 00-PMNS-3BCXLP 00-EFM 6BCXLP 00-PMNS-EFM-3BC160 A without clamps, bolts160 A incl. 6 BC160 A Prepared for MNS adapter incl. 3 BC160 A incl. El. Fuse Mon. incl 6 BC160 A Pr. f. MNS Adp. incl. El. Fuse Mon.incl. 3 BC1SEP 101890 R00011SEP 101890 R00021SEP 101890 R03021SEP 101890 R00121SEP 101890 R03121 0. 551 0. 631 0. 641 0. 681 0. 64XLP 1 with AdapterDescription Designation Ordering details Pack. WeightType No. Unit 1 pc/kgXLP 00-A60/60-3BC-DownXLP 00-A60/60-3BC-UpXLP 00-A40/95-3BCXLP 00-A40/75-3BCXLP 00-A40/75-3M8XLP 00-A40/120-3BCXLP 00-A40/120-3M8160 A incl. A60/ 60 Adapter incl. 3 BC, cable down160 A incl. A6060 Adapter incl. 3 BC, cable up160 A incl. A40/ 95 Adapter incl. 3 BC160 A incl. A40/ 75 Adapter incl. 3 BC160 A incl. A40/ 75 Adapter incl. 3 M8 bolts160 A incl. A40/ 120 Adapter incl. 3 BC160 A incl. A40/ 120 Adapter incl. 3 M8 bolts1SEP 101916 R00011SEP 101917 R00011SEP 101889 R00021SEP 101898 R00021SEP 101898 R00041SEP 101899 R00021SEP 101899 R00041 0. 951 0. 951 1.11 11 11 1.21 1.2XLP 1 ApparatusDescription Designation Ordering details Pack. WeightType No. Unit 1 pc/kgXLP 1XLP 1- 6BCXUP 1XUP 1- 6BCXLP 1- EFM- 6BCXLP 1 with AdapterDescription Designation Ordering details Pack. WeightType No. Unit 1 pc/kgXLP 1-A60/85-3BC-DownXLP 1-A60/85-3BC-UpXLP 1-A40/120-3BCXLP 1-A40/120-3M10250 A without clamps250 A incl. 6 BC250 A Fuse Base without clamps, bolts250 A incl. 6 BC250 A incl. El. Fuse Mon. incl 6 BC250 A incl. A60/ 85 Adapter incl. 3 BC, cable down230 A incl. A60/ 85 Adapter incl. 3 BC, cable up250 A incl. A40/ 120 Adapter incl. 3 BC250 A incl. A40/ 120 Adapter incl. 3 M10bolts1SEP 101891 R00011SEP 101891 R00021SEP 101895 R00011SEP 101895 R00021SEP 101891 R00121SEP 101918 R00011SEP 101919 R00011SEP 101912 R00021SEP 101912 R00041 1.61 1.81 1.11 1.31 1. 971 2. 471 2. 471 2.81 2. 75XLP 2 ApparatusDescription Designation Ordering details Pack. WeightType No. Unit 1 pc/kgXLP 2XLP 2- 6BCXLP 2- EFM- 6BC400 A / without clamps , bolts400 A incl. 6 BC400 A incl. El. Fuse Monitoring incl 6 BC1SEP 101892 R00011SEP 101892 R00021SEP 101892 R00121 2.51 3. 021 3.2XLP 3 ApparatusDescription Designation Ordering details Pack. WeightType No. Unit 1 pc/kgXLP 3XLP 3- 6BCXLP 3- EFM- 6BCExplanations:XLP = Basic Fuse switch disconnectorXUP = Basic Fuse base without front coverApparatus sizePMNS = Prepared for MNS adapterAxx/ yy = A: Adapter xx: Busbardist. yy Depth mm.EFM = Electronic Fuse Monitoring6CC = 6 pcs Cage Clamps ( XLP 000 )3BC = 3 pcs Bridge Clamps3TC = 3 pcs Trippel Clamp3FC = 3 pcs Feeding Clamp3M8 = 3 pcs Bolts M83M10 = 3 pcs Bolts M10630 A / without clamps , bolts630 A incl. 6 BC630 A incl. El. Fuse Monitoring incl 6 BC1SEP 101975 R00011SEP 101975 R00021SEP 101975 R0012XLP 00 PMNS EFM 3BC Up1 3.71 4. 251 4.4FusesAutomation Technologies5/971SKC000013C0201

EasyLineFuse Switches, XLP AccessoriesOrdering Details (continued)Description Designation Ordering details Pack. WeightType No. Unit 1 pc/kgCommon AccessoriesMicro auxiliary switchAuxiliary switch NCAuxiliary switch NOPadlock deviceXLP 000 AccessoriesXLP 000 Front cover (spare part)XLP 000 DIN rail snap on kit, 1pc.XLP 000 DIN rail snap on kit, 10pcs.XLP 000 DIN rail snap on kit, 50pcs.XLP 000 DIN rail snap on kit, 100pcs.XLP 000 Front frame f / 1 XLPXLP 000 Front frame f / 2 XLPXLP 000 Front frame f / 3 XLPXLP 00 AccessoriesXLP 00 Front cover (spare part)XLP 00 Adapter MNSXLP 00 Adapter A60/ 60- DownXLP 00 Adapter A60/ 60- UpXLP 00 Adapter A40/ 75XLP 00 Adapter A40/ 120XLP 00 Front frame f / 1 XLPXLP 00 Front frame f / 2 XLPXLP 00 Front frame f / 3 XLPXLP 00 Electronic Fuse Monitoring kitXLP 00 Cable shroudXLP 00 Snap on kit for double DIN railXLP 00 Bridge Clamp (BC)XLP 00 Single Prism Clamp (SPC)XLP 00 Triple Clamp (TC)XLP 00 Feeding Clamp (FC)XLP 00 Bolt M8 x 16 w/ washXLP 1 AccessoriesXLP 1 Front cover (spare part)XLP 1 Adapter A60/ 85- DownXLP 1 Adapter A60/ 85- UpXLP 1 Adapter A40/ 120XLP 1 Front frame f/ 1 XLPXLP 1 Front frame f/ 2 XLPXLP 1 Electronic Fuse Monitoring kitXLP 1 Cable shroudXLP 1 Bridge Clamp (BC)XLP 1 Single Prism Clamp (SPC)XLP 1 Double Prism Clamp (DPC)XLP 1 Bolt M10 x 20 w/ washerXLP 2 AccessoriesXLP2 Front coverXLP2 Front frame f/ 1 XLP2XLP2 Electronic Fuse MonitoringXLP2/ 3 Cable shroudXLP2/ 3 Bridge Clamp (BC)XLP2/ 3 Single Prism Clamp (SPC)XLP2/ 3 Double Prism Clamp (DPC)XLP2/ 3 Bolt M12 w/ wash.XLP 3 AccessoriesXLP3 Front coverXLP3 Frontframe f/ 1 XLP3XLP3 Electronic Fuse MonitoringXLP2/ 3 Cable shroudXLP2/ 3 Bridge Clamp (BC)XLP2/ 3 Single Prism Clamp (SPC)XLP2/ 3 Double Prism Clamp (DPC)XLP2/ 3 Bolt M12 w/ wash.XLP 000, 00, 1, 2 and 3 - 6A / 150VXLP 00, 1, 2 and 3 - 10A / 690VXLP 00, 1, 2 and 3 - 10A / 690VXLP 00, 1, 2 and 3For 60 mm busbar distance 5 or 10 mm, cable downFor 60 mm busbar distance 5 or 10 mm, cable up1,5- 50 mm 21,5- 70 mm 21,0- 10 mm 225 - 95 mm 2For 60 mm busbar distance 5 or 10 mm, cable downFor 60 mm busbar distance 5 or 10 mm, cable up16- 95 mm 216- 185 mm 22 x 70- 120 mm 216- 300mm 225- 240mm 22x35- 150mm 2 sm, 2x35- 50mm 2 re,2x35- 70mm 2 rm , 2x50- 185mm 2 se16- 300mm 225- 240mm 22x35- 150mm 2 sm, 2x35- 50mm 2 re,2x35- 70mm 2 rm , 2x50- 185mm 2 se1SEP 407742 R00011SEP 407742 R00021SEP 407742 R00031SEP 407786 R00011SEP 304222 R00011SEP 407740 R00011SEP 407740 R00101SEP 407740 R00501SEP 407740 R01001SEP 407741 R00011SEP 407741 R00021SEP 407741 R00031SEP 101873 R0001GLBS500162 R00011SEP 101915 R00011SEP 101910 R00011SEP 101909 R00011SEP 101909 R00021SEP 407792 R00011SEP 407792 R00021SEP 407792 R00031SEP 304233 R00011SEP 407793 R00011SEP 407897 R00011SEP 407733 R00011SEP 407732 R00011SEP 407787 R00011SEP 407811 R0001NHP 400940 R00061SEP 101883 R00011SEP 201456 R00011SEP 201451 R00011SEP 201449 R00011SEP 407815 R00011SEP 407815 R00021SEP 304279 R00011SEP 407793 R00021SEP 407733 R00021SEP 407732 R0002NHP 403631 R0001NHP 403625 R00011SEP 101982 R00011SEP 407951 R00011SEP 101983 R00011SEP 407952 R00011SEP 407953 R00011SEP 407954 R00011SEP 407956 R0001NHP 403626 R00011SEP 101984 R00011SEP 407955 R00011SEP 101985 R00011SEP 407952 R00011SEP 407953 R00011SEP 407954 R00011SEP 407956 R0001NHP 403626 R00011 0,011 0.021 0.021 0.171 0. 00610 0.0650 0.3100 0.61 0.021 0. 0251 0.031 0.171 0.61 0.381 0.38111 0.021 0.031 0.041 0.091 0.031 0.243 0.043 0.093 0.153 0.293 0.041 0.51 0.741 0.7411 0.041 0.061 0.371 0.13 0.113 0.173 0.443 0.091 0.651 0.41 0.251 0.183 0.263 0.53 0.363 0.181 0.91 0. 0551 0.351 0.183 0.263 0.53 0.363 0.185/98 Automation Technologies1SKC000013C0201

EasyLineFuse Switches, SLPOrdering DetailsSLP 4 PoleDescription Designation Ordering details Pack. WeightType No. Unit 1 pc/kgSLP 00 4 pole160ANHP 100844 R0001 1 1.2SLP K1 4 pole250ANHP 100799 R0001 1 4.0SLP K2 4 pole400ANHP 100838 R0001 1 7.6SLP K3 4 pole630ANHP 100838 R0002 1 8.1SLP AccessoriesDescription Designation Ordering details Pack. WeightType No. Unit 1 pc/kgCover IP 30 4 poleSLP 00NHP 100991P 0001 1 0.04Cover IP 30 4 poleSLP K1NHP 100993P 0001 1 0.06Cover IP 30 4 poleSLP K2NHP 100992P 0001 1 0.06Cover IP 30 4 poleSLP K3NHP 100992P 0001 1 0.06Auxiliary contact bSLP 2/ 3NHP L045270 R0001 1 0.01Auxiliary switch hSLP 2/ 3NHP L045353 R0001 1 0.04Front fixing deviceSLP 00NHP L045155 R0001 1 0.02SLP AccessoriesDescription Designation Torque Ordering details Pack. WeightNm Type No. Unit 1 pc/kgSingle cable clamp,Al/ Cu 70- 150 mm 2Double cable clamps,Al/ Cu 2x( 70x150) mm 2Single cable clamp,Al/ Cu 16- 150 mm 2SLP K1SLP K1SLP K1101010NHP 403628 R0002NHP 403631 R0002NHP 403627 R0002111Single cable clamp,SLP K2 and SLP- K3 20 NHP 403677 R0002 1 0.4616 Ð 240 mm 2Single cable clamp,SLP K2 and SLP- K3 30 NHP 403630 R0001 1 0.85Al/ Cu 95 - 240 mm 2Double cable clamps,Al/ Cu 2x95 Ð 240 mm 2Cable lug connectionAl/ Cu 240mm 2 (M10x20) andbusbar connection 35 mm2 (M10x20)Cable lug connectionAl/ Cu 300 mm 2 (M12x30)SLP K2 and SLP- K3SLP K1SLP K2 and SLP- K3302525NHP 403633 R0001NHP 403625 R0002NHP 403626 R0002111FusesSF - 60 Busbar systemDescription Designation Ordering details Pack. WeightType No. Unit 1 pc/kgBusbar carrierCover f/ busbar carrierCable connection moduleCover for cable connection moduleCover for busbarCover for busbar5-10 x 12-30 mm5-10 x 12-30 mm12-30 x 5 mm12-30 x 10 mmGHV 240849R0001GHV 240849R0004GHV 240849R0034GHV 204849R0036NHSN320001P0001NHSN320001P00021 10.11 0.031 0.621 0.151 0.071 0.084Automation Technologies5/991SKC000013C0201

SLBMFuse SwitchesTechnical Data / Ordering DetailsDescription SLBM BSL250 400 630 800 1) 1200 2) 1600 3) 1600 2000 4)For HRC fuse links acc. to DIN 43620/IEC 269-2-1Rated operational voltage UeRated operational current IeRated insulation voltage UiRated impulse withstand voltage UimpFuse protected short circuit makingRated short time withstand current 1 sec.Rated making and breaking capacityBreaking current Ic at cos j = 0.95Rated frequencyMax. cable cross section to be connectedDitto with splice for two parallel cablesDegree of protection from the front acc. toIEC 529SizeVAVVkArmskArmsAHzmm2mm2OpenClosed16902501000800050AC 22B502402x240IP 10IP201-26904001000800050AC 22B502402x240IP 10IP2036906301000800050AC 22B502402x240IP 10IP201-26908001000800050AC 22B502404x240IP 10IP20369012001000800050AC 22B502406x240IP 10IP20369016001000800050AC 22B502406x240IP 10IP2050016001000800040AC 20B2440502402x240IP 10 5)IP2050020001000800040AC 2202400502402x240IP 10 5)IP201) Two SLBM 400 A in parallel2) Two SLBM 630 A in parallelTypetested acc. to IEC 60947-33) Three SLBM 630 A in parallel4) Two BSL 1600 A in parallel5) Without IP 20 protecting coverTypetested acc. to IEC 60947-3SLBMDescription Ordering details Pack. WeightType No. Unit 1 pc/kgSLBM 250 (busbar distance 210 mm)NHPL 046201 R0001 9.3SLBM 400 (busbar distance 210 mm)NHPL 046202 R0001 9.3SLBM 630 (busbar distance 210 mm)NHPL 046203 R0001 9.5SLBM 800 (busbar distance 210 mm)NHPL 046204 R0001 19.4SLBM 1200 (busbar distance 210 mm)NHPL 046205 R0001 19.8SLBM 1600 (busbar distance 210 mm)NHPL 046206 R0001 29.8SLBM 250 (busbar distance 185/210 mm)SLBM 400 (busbar distance 185/210 mm)SLBM 630 (busbar distance 185/210 mm)BSL 1600 (busbar distance 210 mm)BSL 2000 (busbar distance 210 mm)Hood for cable terminationsSplices for 400/630 AKit for mounting 2xSLBM 400A = 800AKit for mounting 2xSLBM 630A = 1200AKit for mounting 3xSLBM 630A = 1600ACable termination 1 x 300 mm 2 .Cable termination 2 x 240 mm 2 .Protecting cover for:BSL 1600BSL 2000Earthing cover, type JSLNHPL 046251 R0001NHPL 046252 R0001NHPL 046253 R0001NHPL 013603 R0001NHPL 013604 R0001NHPL 046212 R0001NHPL 046210 R0001NHPL 046290 R0001NHPL 046291 R0001NHPL 046292 R0001NHP 402098 R0003NHP 402098 R0001NHP 040094 R0001NHP 040094 R0002NHP 038409 R00019.39.39.315.031.50.414.14.16.10.71.42.24.14.1Spare partsDescription Ordering details Pack. WeightType No. Unit 1 pc/kgCover compl. for SLBM 250Cover compl. for SLBM 400Cover compl. for SLBM 630NHPL 046213 R0001NHPL 046214 R0001NHPL 046216 R00011.81.81.85/100 Automation Technologies1SKC000013C0201

InLineFuse SwitchesDescriptionFamily presentationInLine is the new generation of vertical fuse rails and fuse switchdisconnectors from ABB.ABB has a long history in producing these types of devices, andthe first generation was introduced already in 1967. The InLinefamily consists of fuse rails, single-, and triple pole operated fuseswitch disconnectors and incoming/outgoing units.Areas of applications• Cable distribution cabinets (CDC)• Low voltage distribution in secondary transformersubstations• Distribution boards for industry, housing and office buildingsInplanInPlan is a software tool for planning and designing InLineapplications. It may be used to have:- Front view diagram- Single line diagram- Material listThese can all be printed and used for documentation and offerswhere InLine is used.Applications• Cable distribution cabinets• Low voltage distribution in transformer secondarysubstations• Switchboards for industries• InstallationsFusesAutomation Technologies5/1011SKC000013C0201

InLineFuse Switches,Description (continued)Properties• Fully type tested in accordance with IEC 60947-3• Compact 48 and 98 mm width• 185mm busbar distance• For flat or IP20 z-profile busbar• Wide range of accessories• Possibility of top, bottom or side cable connection• IP20 from the front• Available with Electronic Fuse Monitoring (EFM)• Current metering on both the cable and busbar side• Safe live installation with IP20 system• V0 – flame retardant materialsAdvantages• Complete range for all applications• Modern and sturdy design• Flexibility-snap on solutions5/102 Automation Technologies1SKC000013C0201

InLineFuse SwitchesTechnical DataXUBM Fuse railsXUBM00 XUBM1 XUBM2 XUBM3For HRC fuse links acc. toIEC 60269-2-1. 00 1 2 3Rated operational voltage Ue (V) 690 690 690 690Rated operational current Ie (A) 160 250 400 630Rated insulation voltage Ui (V) 1000 1000 1000 1000Conditional short circuit current– with fuse links. (kArms) 50 50 50 50Rated frequency. (Hz) 50-60 50-60 50-60 50-60Degree of protection from thefront acc. to IEC 60529. *) IP 20 IP 20 IP 20 IP 20*) With fuse protection cover or isolated gripping lugsg lugsXLBM Fuse switch disconnectorXLBM00 XLBM1 XLBM2 XLBM3For HRC fuse links acc. toIEC 60269-2-1. 00 1 2 3Rated operational voltage Ue (V) 400 500 690 400 500 690 400 500 690 400 500 690Rated operational current Ie (A) 160 160 125 250 250 200 400 400 315 630 630 500Thermal current w/fuse link lth (A) 160 250 400 630Rated insulation voltage Ui (V) 1000 1000 1000 1000Rated impulse withstandvoltage Uimp (kV) 8 8 8 8Fuse protected short circuitwithstand (kArms) 50 50 50 50Fuse protected short circuitmaking (kArms) 50 50 50 50Rated making and breaking AC23B AC22B AC21B AC23B AC22B AC21B AC23B AC22B AC21B AC23B AC22B AC21Bcapacity:Rated frequency. (Hz) 50-60 50-60 50-60 50-60Power losses at Ith withoutfuse-link (W) 16,1 16,9 36,8 75,4FusesDegree of protection from Open IP 20 IP 20 IP 20 IP 20the front acc. to IEC 60529. Closed IP 30 IP 30 IP 30 IP 30Automation Technologies5/1031SKC000013C0201

InLineFuse SwitchesApparatus and AccessoriesXUBM fuse railXUBM00-100 XUBM00 XUBM1/2/3Fuse link NH00 NH00 NH1/2/3Rated current 160 A 160 A 250 A400 A630 AModule width 50 mm 50 mm 100 mmCable Al / Cu mm2 1) 1,5 - 95 1,5 - 95 95 - 240Cable terminal 2) 3 x M8 3 x M8 3 x M12Order code 1SEP101836R0001 1SEP102111R0101 XUBM1 1SEP102111R0101XUBM2 1SEP102112R0101XUBM3 1SEP102113R01011. Cable lugs in accordance with DIN 46235 and DIN 46239.2. Cable clamps are available as accessories.XLBM fuse switch disconnectorXLBM00-3P-100 XLBM00-1P XLBM00-3P XLBM1/2/3-1P XLM1/2/3-3PFuse link NH00 NH00 NH00 NH1/2/3 NH1/2/3Rated current 160 A 160 A 160 A 250 A 250 A400 A 400 A630 A 630 AModule width 50 mm 50 mm 50 mm 100 mm 100 mmCable Al / Cu mm 2 1) 1,5 - 95 1,5 - 95 1,5 - 95 95 - 240 95 - 240Cable terminal2)3 x M8 3 x M8 3 x M8 3 x M12 3 x M12Order code 1SEP101818R0001 1SEP102140R0101 1SEP102140R0121 XLBM1 1SEP102141R0101 XLBM1 1SEP102141R0121XLBM2 1SEP102142R0101 XLBM2 1SEP102142R0121XLBM3 1SEP102143R0101 XLBM3 1SEP102143R0121XLBM3 1SEP102143R0101 XLBM3 1SEP102143R01211. Cable lugs in accordance with DIN 46235 and DIN 46239.2. Cable clamps are available as accessories.5/104 Automation Technologies1SKC000013C0201

InLineFuse SwitchesApparatus and Accessories (continued)IP20 Z-busbars, type BZZ-busbars for 400/630 A. The busbar kit includes:• Busbar L1, L2 and L3• Two busbar holdersThe Z-busbars are completely IP20 protected.Type Rated current Width Order codeBZ 400 ABZ 400A/284 400 A 284 mm 1SEP824063R0001BZ 400A/536 400 A 536 mm 1SEP824064R0001BZ 400A/851 400 A 851 mm 1SEP824065R0001BZ 400A/1201 400 A 1201 mm 1SEP824066R0001BZ 630 ABZ 630A/284 630 A 284 mm 1SEP824067R0001BZ 630A/536 630 A 536 mm 1SEP824068R0001BZ 630A/851 630 A 851 mm 1SEP824069R0001BZ 630A/1201 630 A 1201 mm 1SEP824070R0001XUBM-Z and XLBM-Z may be hooked on:• Z busbars type BZ• Standard flat busbars, Al/CuXLBM-Z fuse railsXUBM00-Z XUBM1/2/3-Z XUBM1/2/3-ZSFuse link NH00 NH1/2/3 NH1/2/3Rated current 160 A 250 A 250 A400 A 400 A630 A 630 AModule width 50 mm 100 mm 150 mmCable Al / Cu mm2 1,5 - 95 95 - 240 50 - 300Cable terminal 3 x M8 3 x M12 ClampsOrder code 1SEP102110R0201 XUBM 1 1SEP102111R0201 XUBM 1 1SEP102111R0405XUBM 2 1SEP102112R0201 XUBM 2 1SEP102112R0405XUBM 3 1SEP102113R0201 XUBM 3 1SEP102113R0405FusesAutomation Technologies5/1051SKC000013C0201

InLineFuse SwitchesApparatus and Accessories (continued)XUBM 1pole-Z fuse switch disconnectorXLBM00-1P-Z XLBM1/2/3–1P–Z XLBM1/2/3-1P-ZS XLBM1/2/3-1P-Z2SFuse link NH00 NH1/2/3 NH1/2/3 NH1/2/3Rated current 160 A 250 A 250 A 250 A400 A 400 A 400 A630 A 630 A 630 AModule width 50 mm 100 mm 150 mm 208Cable Al / Cu mm2 1,5 - 95 95 - 240 50 - 300 2 x 50 - 300Cable terminal 3 x M8 3 x M12 Clamps ClampsOrder code 1SEP102140R0201 XLBM1 1SEP102141R0201 XLBM1 1SEP102141R0401 XLBM1 1SEP102141R0501XLBM2 1SEP102142R0201 XLBM2 1SEP102142R0401 XLBM2 1SEP102142R0501XLBM3 1SEP102143R0201 XLBM3 1SEP102143R0401 XLBM3 1SEP102143R0501XUBM 3pole-Z fuse switch disconnectorXLBM00-3P-Z XLBM1/2/3-3P-Z XLBM1/2/3-3P-ZS XLBM1/2/3-3P-Z2SFuse link NH00 NH1/2/3 NH1/2/3 NH1/2/3Rated current 160 A 250 A 250 A 250 A400 A 400 A 400 A630 A 630 A 630 AModule width 50 mm 100 mm 150 mm 208 mmCable Al / Cu mm2 1,5 - 95 95 - 240 50 - 300 2 x 50 - 300Cable terminal 3 x M8 3 x M12 Clamps ClampsOrder code 1SEP102140R0221 XLBM1 1SEP102141R0221 XLBM1 1SEP102141R0421 XLBM1 1SEP102141R0521XLBM2 1SEP102142R0221 XLBM2 1SEP102142R0421 XLBM2 1SEP102142R0521XLBM3 1SEP102143R0221 XLBM3 1SEP102143R0421 XLBM3 1SEP102143R05215/106 Automation Technologies1SKC000013C0201

InLineFuse SwitchesApparatus and Accessories (continued)Cable terminationConductor cross section min-maxType of Conductor Rm/Sm Re/Se Torque Order codeclamp/bolt flexible mm 2 mm 2 (Nm)mm 2XLBM / XUBM00Bridge Clamp (BC) 1,5 – 50 1,5 – 50 1,5 – 50 3,5 1SEP407733R0001Single Prism Clamp(SPC) 1,5 – 95 1,5 – 95 1,5 – 95 3,5 1SEP407732R0005XLBM / XUBM1/2/3Rm:Re:16 - 35 + 16 - 70 +50 - 185 70 - 150V-clamp kit 95 – 240 25 1SEP304446R0001Sm:Se:35 - 50 + 35 - 70 +70 - 240 95 - 300Rm:Re:2 x 50 - 185 2 x 70 240Double V-clamp kit 2 x 95 – 240 25 1SEP304457R0001Sm:Se:2 x 95 - 240 2 x 120 - 300Double cable lug kit 2 x 95 – 240 2 x 70 – 240 2 x 70 – 240 25 1SEP304502R0001FusesAutomation Technologies5/1071SKC000013C0201

InLineFuse SwitchesOrdering DetailsXUBM / XLBMOrder numder Type Description Weightdesignationunit/kgFuse rail - XUBM1SEP102110R0101 XUBM00 160A incl. 3M8 1,51SEP101836R0001 XUBM00-100 160A 100mm busbardist. incl. 3M8 1,01SEP102100R0101 XUBM00-R 160A wo. contact shrouds, incl. 3M8 1,31SEP102111R0101 XUBM1 250A incl. 3M12 2,91SEP102101R0101 XUBM1-R 250A wo. contact shrouds, incl. 3M12 2,51SEP102112R0101 XUBM2 400A incl. 3M12 3,41SEP102102R0101 XUBM2-R 400A wo. contact shrouds, incl. 3M12 3,11SEP102113R0101 XUBM3 630A incl. 3M12 3,91SEP102103R0101 XUBM3-R 630A wo. contact shrouds, incl. 3M12 3,6XUBM2Fuse switch disconnector - XLBM 1pole1SEP102140R0101 XLBM00-1P 160A 1 pole, incl. 3M8 2,21SEP102140R0111 XLBM00-1P-EFM 160A 1pole, incl. EFM, incl. 3M8 2,31SEP102141R0101 XLBM1-1P 250A 1 pole, incl. 3M12 4,21SEP102141R0111 XLBM1-1P-EFM 250A 1pole, incl. EFM, incl. 3M12 4,41SEP102142R0101 XLBM2-1P 400A 1 pole, incl. 3M12 4,71SEP102142R0111 XLBM2-1P-EFM 400A 1pole, incl. EFM, incl. 3M12 4,91SEP102143R0101 XLBM3-1P 630A 1 pole, incl. 3M12 5,21SEP102143R0111 XLBM3-1P-EFM 630A 1pole, incl. EFM, incl. 3M12 5,4Fuse switch disconnector - XLBM 3pole1SEP102140R0121 XLBM00-3P 160A 3pole, incl. 3M8 2,31SEP101818R0001 XLBM00-3P-100 160A 3pole, 100mm busbardist. incl. 3M8 1,61SEP102140R0131 XLBM00-3P-EFM 160A 3pole, incl. EFM, incl. 3M8 2,41SEP102141R0121 XLBM1-3P 250A 3pole, incl. 3M12 4,31SEP102141R0131 XLBM1-3P-EFM 250A 3pole, incl. EFM, incl. 3M12 4,51SEP102142R0121 XLBM2-3P 400A 3pole, incl. 3M12 4,81SEP102142R0131 XLBM2-3P-EFM 400A 3pole, incl. EFM, incl. 3M12 5,01SEP102143R0121 XLBM3-3P 630A 3pole, incl. 3M12 5,31SEP102143R0131 XLBM3-3P-EFM 630A 3pole, incl. EFM, incl. 3M12 5,5XLBM2-1PXLBM2-3P5/108 Automation Technologies1SKC000013C0201

InLineFuse SwitchesOrdering Details (continued)XUBM / XLBM with hooked clamps for IP20 Z- busbar systemsOrder numder Type Description Weightdesignationunit/kgFuse rail - XUBM with hooked clamp (Z)1SEP102110R0201 XUBM00-Z 160A w. hooked clamp, incl. 3M8 1,71SEP102111R0201 XUBM1-Z 250A w. hooked clamp, incl. 3M12 3,21SEP102111R0405 XUBM1-ZS 250A w. hooked clamp, side connection, incl. 3 clamps 3,21SEP102112R0201 XUBM2-Z 400A w. hooked clamp, incl. 3M12 3,81SEP102112R0405 XUBM2-ZS 400A w. hooked clamp, side connection, incl. 3 clamps 3,71SEP102113R0201 XUBM3-Z 630A w. hooked clamp, incl. 3M12 4,21SEP102113R0405 XUBM3-ZS 630A w. hooked clamp, side connection, incl. 3M12 4,1XUBM2-ZFuse switch disconnector - XLBM 1pole with hooked clamp (Z)1SEP102140R0201 XLBM00-1P-Z 160A 1pole, w. hooked clamp, incl. 3M8 2,41SEP102140R0211 XLBM00-1P-EFM-Z 160A 1 pole, incl. EFM, w. hooked clamp, incl. 3M8 2,51SEP102141R0201 XLBM1-1P-Z 250A 1pole, w. hooked clamp, incl. 3M12 4,51SEP102141R0211 XLBM1-1P-EFM-Z 250A 1pole, incl. EFM, w. hooked clamp, incl. 3M12 4,71SEP102141R0401 XLBM1-1P-ZS 250A 1pole, w. hooked clamp, side connection, incl. 3 clamps 4,51SEP102141R0501 XLBM1-1P-Z2S 250A 1pole, w. hooked clamp, 5,8double side connection, incl. 6 clamps 6,31SEP102143R0201 XLBM3-1P-Z 630A 1pole, w. hooked clamp, incl. 3M12 5,51SEP102143R0211 XLBM3-1P-EFM-Z 630A 1pole, incl. EFM, w. hooked clamp, incl. 3M12 5,71SEP102143R0401 XLBM3-1P-ZS 630A 1pole, w. hooked clamp, side connection, incl. 3 clamps 5,41SEP102143R0501 XLBM3-1P-Z2S 630A 1pole, w. hooked clamp, 6,7double side connection, incl. 6 clampsXLBM2-3P-ZSFuse switch disconnector - XLBM 3pole with hooked clamp (Z)1SEP102140R0221 XLBM00-3P-Z 160A 3pole, w. hooked clamp, incl. 3M8 2,51SEP102140R0231 XLBM00-3P-EFM-Z 160A 3pole, incl. EFM, w. hooked clamp, incl. 3M8 2,61SEP102141R0221 XLBM1-3P-Z 250A 3pole, w. hooked clamp, incl. 3M12 4,61SEP102141R0231 XLBM1-3P-EFM-Z 250A 3pole, incl. EFM, w. hooked clamp, incl. 3M12 4,81SEP102141R0421 XLBM1-3P-ZS 250A 3pole, w. hooked clamp, side connection, incl. 3 clamps 4,61SEP102141R0521 XLBM1-3P-Z2S 250A 3pole, w. hooked clamp, 5,8double side connection, incl. 6 clamps1SEP102142R0221 XLBM2-3P-Z 400A 3pole, w. hooked clamp, incl. 3M12 5,21SEP102142R0231 XLBM2-3P-EFM-Z 400A 3pole, incl. EFM, w. hooked clamp, incl. 3M12 5,41SEP102142R0421 XLBM2-3P-ZS 400A 3pole, w. hooked clamp, side connection, incl. 3 clamps 5,11SEP102142R0521 XLBM2-3P-Z2S 400A 3pole, w. hooked clamp, 6,3double side connection, incl. 6 clamps1SEP102143R0221 XLBM3-3P-Z 630A 3pole, w. hooked clamp, incl. 3M12 5,61SEP102143R0231 XLBM3-3P-EFM-Z 630A 3pole, incl. EFM, w. hooked clamp, incl. 3M12 5,81SEP102143R0421 XLBM3-3P-ZS 630A 3pole, w. hooked clamp, side connection, incl. 3 clamps 5,51SEP102143R0521 XLBM3-3P-Z2S 630A 3pole, w. hooked clamp, 6,7double side connection, incl. 6 clampsFLS 160Modules with hooked clamp (Z)1SEP731800R0001 LB 160 160A load break switch1SEP731802R0001 LB250 250A load break switch1SEP731804R0001 LB 400 400A load break switch1SEP731806R0001 LB 630 630A load break switch1SEP731808R0001 FLS 160 160A switch fuse1SEP731810R0001 FLS 250 250A switch fuse1SEP731812R0001 FLS 400 400A switch fuse1SEP731814R0001 FLS 630 630A switch fuse1SEP731816R0001 LS 160 160A load break switch-sectionallizer1SEP731818R0001 LS 250 250A load break switch-sectionallizer1SEP731820R0001 LS 400 400A load break switch-sectionallizer1SEP731822R0001 LS 630 630A load break switch-sectionallizer1SEP731824R0001 FSS 160 160A switch fuse -sectionallizer1SEP731826R0001 FSS 250 250A switch fuse -sectionallizer1SEP731828R0001 FSS 400 400A switch fuse -sectionallizer1SEP731830R0001 FSS 630 630A switch fuse -sectionallizer1SEP731530R0001 LDL 63/3 63A diazed unit w. 3 groups1SEP731594R0001 AKZD 95 Direct incomer 0,11SEP731521R0001 AKKZ 300 Direct incomer 0,4FusesBZ 400A/1201Kit of IP20 Z-busbars1SEP824063R0001 BZ 400A/284 400A/284mm, incl. IP20 busbars&holders1SEP824064R0001 BZ 400A/536 400A/536mm, incl. IP20 busbars&holders1SEP824065R0001 BZ 400A/851 400A/851mm, incl. IP20 busbars&holders1SEP824066R0001 BZ 400A/1201 400A/1201mm, incl. IP20 busbars&holders1SEP824067R0001 BZ 630A/284 630A/284mm, incl. IP20 busbars&holders1SEP824068R0001 BZ 630A/536 630A/536mm, incl. IP20 busbars&holders1SEP824069R0001 BZ 630A/851 630A/851mm, incl. IP20 busbars&holders1SEP824070R0001 BZ 630A/1201 630A/1201mm, incl. IP20 busbars&holdersAutomation Technologies5/1091SKC000013C0201

InLineFuse SwitchesOrdering Details (continued)AccessoriesMicro auxiliary switchauxiliary switch NCDouble adapter 100Cable shroudLabel holderDouble adapter M12Double adapter M12Plug in CTNH2 Fuse linkOrder numder Type Description Weightdesignationunit/kgCommon accessoriesNHSN950001P0006 Insulated hexagon key NV6 0,11SEP407742R0001 Micro auxiliary switch 6A/150V 0,011SEP407742R0002 Auxiliary switch NC 10A/690V 0,021SEP407742R0003 Auxiliary switch NO 10A/690V 0,02Accessories XUBM/XLBM00-1001SEP304058R0001 00-100 Cable shroud for clamps, H=106mm 0,021SEP304061R0001 00-100 Cable shroud extended for cable lugs, H=150mm 0,051SEP304068R0001 00-100 Label holder 0,011SEP304105R0001 00-100 Phase barrier kit Kit incl. 3 pcs. 0,051SEP304056R0001 00-100 Prism clamp kit Kit incl. 3 pcs. 0,11SEP304060R0001 00-100 Micro switch 0,011SEP304064R0001 00-100 Single adapter for 60mm busbar distance 0,31SEP304066R0001 00-100 Single adapter 100 to 185mm busbar dist. 0,41SEP304065R0001 00-100 Double adapter 100 to 185mm busbar dist. 0,71SEP304059R0001 00-100 Hooked clamp Kit incl. 3 pcs. 0,03Accessories XUBM/XLBM001SEP201543R0001 XUBM00 Fuse protection cover 0,31SEP304442R0001 XUBM00 Phase barrier kit Kit incl. 2 pcs. 0,051SEP408124R0001 XUBM00 Cable shroud 0,21SEP408126R0001 XLBM00 Cable shroud, H=185mm 0,151SEP408128R0001 XLBM00 Cable shroud short, H=64 mm 0,11SEP408139R0001 XLBM00 Label holder 0,11SEP408141R0001 XLBM00 A-meter house for A-meter 48x48 mm 0,05NHSN714003P1150 Max A-meter QB48, 0-150-180/5A 0,11SEP408149R0001 CT rear side inst. kit 160/5A 2,5VA cl.1 0.61SEP407733R0001 00 Bridge clamp (3BC) 1,5-50mm2 Kit incl. 3 pcs. 0,041SEP407732R0005 00 Single prism clamp (3PC) 1,5-95mm2 Kit incl. 3 pcs. 0,091SEP304072R0001 00 Single adapter M12 to M8 for 185mm busbar dist. 0,41SEP304071R0001 00 Double adapter M12 to M8 for 185mm busbar dist. 0,71SEP304069R0001 00 Spare way cover 0,2Accessories for XUBM/XLBM 1, 2, 31SEP201499R0001 XUBM1,2,3 Fuse protection cover 0,351SEP304395R0001 XUBM1,2,3 Phase barrier kit Kit incl. 2 pcs. 0,151SEP408125R0001 XUBM1,2,3 Cable shroud 0,251SEP408127R0001 XLBM1,2,3 Cable shroud 0,21SEP408140R0001 XLBM1,2,3 Label holder 0,11SEP408142R0001 XLBM1,2,3 Double adapter M12 for A-meter 72x72 mm 0,05NHSN714004P2206 Max A-meter QB72, 0-150-180/5A 0,2NHSN714004P2210 Max A-meter QB72, 0-400-480/5A 0,2NHSN714004P2212 Max A-meter QB72, 0-600-720/5A 0,21SEP408149R0002 CT rear side inst. kit 250A/5A 3,75VA cl.1 Kit incl. 3 CT’s 1,31SEP408149R0003 CT rear side inst. kit 400A/5A 5VA cl.1 Kit incl. 3 CT’s 1,31SEP408149R0004 CT rear side inst. kit 600A/5A 5VA cl.1 Kit incl. 3 CT’s 1,31SEP408149R0005 CT rear side inst. kit 600A/5A 5VA cl.1 0,11SEP408149R0007 CT terminal inst. kit 250/5A 3,75VA cl.0.5 Kit incl. 1 CT 0,61SEP408149R0008 CT terminal inst. kit 400/5A 5VA cl.1 Kit incl. 1 CT 0,61SEP408149R0009 CT terminal inst. kit 600/5A 5VA cl.1 Kit incl. 1 CT 0,61SEP408149R0010 CT terminal inst. kit 600/5A 5VA cl.0,5 Kit incl. 1 CT 0,6NHPL046270R0002 Plug in A-meter, front cover inst 100-200/5A 0,2NHPL046270R0001 Plug in A-meter, front cover inst. 200-400/5A 0,2NHSN718050P2525 Plug in CT for front cover inst. A-meter 200/5A 3,5VA cl.3 0,1NHSN718050P2540 Plug in CT for front cover inst. A-meter 400/5A 5 VA cl.3 0,1NHPL046265R0001 NH2 Fuse link 400V/100A for plug in CT 0,5NHPL046266R0001 NH2 Fuse link 400V/125A for plug in CT 0,5NHPL046267R0001 NH2 Fuse link 400V/160A for plug in CT ,5NHPL046268R0001 NH2 Fuse link 400V/200A for plug in CT 0,5NHPL046269R0001 NH2 Fuse link 400V/224A for plug in CT 0,5NHPL046272R0001 NH2 Fuse link 400V/250A for plug in CT 0,5NHPL046273R0001 NH2 Fuse link 400V/315A for plug in CT 0,5NHPL046274R0001 NH2 Fuse link 400V/335A for plug in CT 0,5NHPL046275R0001 NH2 Fuse link 400V/400A for plug in CT 0,51SEP407946R0001 XLBM1,2,3 LED Fuse indicator (LFM) Kit incl. 3 pcs. 0,02NHSN722068P0002 1,2,3 Huckepack Temporary supply outlet 0,251SEP304446R0001 1,2,3 V-clamp kit Kit incl. 3 pcs. 0,451SEP304457R0001 1,2,3 Double V-clamp kit Kit incl. 3 pcs. 0,451SEP304502R0001 1,2,3 Double cable lug kit Kit incl. 3 pcs. 0,451SEP304080R0001 1,2,3 Spare way cover 0,315/110 Automation Technologies1SKC000013C0201

FastLineFuse SwitchesDescriptionThe distribution system FastLine is a modular system consisting of a busbarassembly plate with plug in modules as incomer and outgoing circuits.Properties of FastLine• Complete distribution system up to 2500 A• Very fast and easy assembly• Modular design• Personal safety, IP 20• Modern cable connection technology for AI and Cu cables• Integrated IP 20 degree of protection• Flexibility by use within several areas• Typetested in accordance with IEC / EN 60947- 3• Developed and produced in accordance to ISO 9001• Easy to recycle in accordance with ISO 14001 standardsAreas of application• Cable distribution cabinets (CDC)• Installation• Low voltage distribution in transformer substations• Switchboards for industry, housing and office buildings• FastLine is also approved for horizontal assemblyFastPlan (software for FastLine)FastPlan is a software for planning and document applications where FastLine/SLK is being used. With FastPlan you have the possibility to make a fast andsimple arrangement where the result is:• Front view drawing• Single line diagram• Material listThese can all be printed and used for documentation, requests, offers,orders or circuit list in cabinets, secondary substations or installations.FastPlan may be installed on PC’s having Windows® 95/ 98/ 2000 orthe NT operating system. One of the challenges of distributing softwarehas been to keep track of the users and ensure that the latest programupdates are being sent out.In FastPlan we will solve this problem by sending out the first release onCD. All future updates will automatically be made via the Internet.FastPlan is available free of charge and may be used by both sales people and customers.aFastLine - A LEGO system for the smart engineerThe FastLine distribution system is a modular system consisting of :• Busbar assembly plates type FS, FD, FM or FST• Direct incomer modules• Incomer modules with disconnecting function• Fuse switch disconnector modules• Fuse switch modules, single poles• SLK- E adapters for ISOMAXFuses1: FS busbar assembly platebolted into a cable distributioncabinet2: Plus the module into the FS, FD,FM or FST busbar assembly plate3: Connect the cables4: Hook the front cover with fuses on thebase and switch in to ON positionAutomation Technologies5/1111SKC000013C0201

FastLineFuse SwitchesHow to feed the busbar platesFS, FD, FMFrom front by use of:• Direct incomer modules• Modules with disconnectingfunction• Circuit breaker in adapter• Fuse switch disconnecterFSTFrom front by use of:• Direct incomer module• With disconnection function• Circuit breaker in adapter• FST- linksFS - SR/ SL• From side R (right) or L (left)by your own cu- barsor cables.• 2xFST with FST links S/ Brear side connection.FS - R• From rear side by your own cubarsor cables.FST- R• From rear side by your owncu bars or cables.5/112 Automation Technologies1SKC000013C0201

FastLineFuse SwitchesModule typesFuse switch disconnector mudulesSLK 160 SLK 400 SLK 630Fuse linkRated currentModule widthCable Al / CuCable terminalOrder codeNH 00160 A50 mm10-95 mm 2ClampsNHP 139224 R0001NH 1 - 2400 A50 mm95-240 mm 2ClampsNHP 139225 R0001NH 3630 A50 mm2x 120-300 mm 2ClampsNHP 139235 R0001SLK 160 SLK 40 SLK 630Cable terminalsingle 70-240 mm 2Earthing front coverKJK 95Earthing front coverKJS 240Cable terminalsingle 120-300 mm 2Cable terminal double2 x 120-300 mm 2Fuse switch modules, single polesSLKD 63 SLKD 160Fuse linkRated currentModule widthCable Al / CuCable terminalOrder codeSpecial descriptionDiazed D II-25 A/D III-63 A63 A50 mm6-50 mm 2ClampsNHP 139225 R0001NH 00160 A50 mm10-95 mm 2ClampsNHP 139238 R0001FusesAutomation Technologies5/1131SKC000013C0201

FastLineFuse SwitchesModule types (continued)Service modulesSM 200 MM230 MM 400/230 S 230 SJ 230Rated currentModule widthOrder codeSpecial description200 A150 mmNHP 139237 R0001Module foryour ownarrangement16 A50 mmNHT F001990 R0001Module for230 V systemThe module includes:3 Fuseholders1 Contact 16A w/ earth1 Voltmeter 0- 250 Vw/ switch16 A50 mmNHT F001990 R0002Module for400 V systemThe module includes:3 Fuseholders1 Contact 16A w/ earth1 Voltmeter 0- 500 Vw/ switch16 A50 mmNHT F001990 R0002Module for230 V systemThe module includes:2 Fuseholders2 Contact 16A w/ earth16 A50 mmNHT F001990 R0002Module for230 V systemThe module includes:2 Fuseholders2 Contact 16A w/ earth1 Earthfailure switchSLK 0 E adapters for ISOMAXModule Sutable for Order CodewidthISOMAX typeAdapter S1Adapter S2Adapter S3Adapter S5Adapter S6Adapter S7100 mm100 mm150 mm150 mm250 mm250 mm3 P S1 N 125/ R 125 FFC3 P S1 N 125/ R125 FFC3 P S2 N 160/ R160 FFC3 P S3 N 250/ R3 P S5 N 400/ 250 FF3 P S6 N 630/ 400 LI, FF3 P S7 N 1250/ 630 LI, FF3 P S6 N 800/ 800 LI, FF1250 LI, FF3 P S7 N 1600/1600 LI, FFNHP 101371R0001NHP 101432R0001NHP 101433R0001NHP 101437R0001NHP 101438R0001NHP 101439R0001The SLK- E adapters are designed for mounting the ISOMAX circuit breaker range from ABB SACE.All adapters are delivered as empty units for mounting the ISOMAX circuit breaker locally by the end user.The SLK- E adapters are designed to be plugged in to the busbar systems FS, FD, FM and FST.5/114 Automation Technologies1SKC000013C0201

FastLineFuse SwitchesTechnical DataModulesDK95 DK240/50 DS400 DK300 DK240 K95 K240 SM200 M/P240 SLKD63 SLK- SLK160 SLK400 SLK630NH160Width of moduleWeightCable AI/ Cu.Rated current I 1)Thermal loadcapacity Ith 1)Rated voltage UeInsulation voltage UiFrequency zoneBreaking capacity:at 400 V, cat. AC 21 Bat 500 V, cat. AC 22 BClosing capacity with:Short- circuiting at 500 VWith largest fusesElectrical lifetime,number of operations 2)Mechanical lifetime,number of operationsType of fuse:DiazedNH- fuse- linkDegree of protectionmmkgmm 2AAVVHzAAkAeffAIP501.210-9525050010005020503.595-240400500100050201001.4400500100050201005300800500100050201003.595-24040050010005020502.210-9525050010005020502.210-95250500100050201502.0-200500100050-502.095-240400500100050X5063020080020502.095-24063400660505063DII /DII20502.110-95160160500100050X5016020014000020502.110-95160500100050X50160200140000201506.595-240400500100050X504002008001-2202007.32(120-300)630500100050X50630200800320Typetested according to IEC 60947- 3.1) When built in to a box, the power load must be reduced in accordance with the reduction factor in the table (IED 60439) on page 11.2) With fuses connected.3) Cable lugs, bars or cable clamps (please consult).Service modulesSM200 MM230 MM/400/230 S 230 SJ 230Width of moduleWeightRated current IRated voltage UeIsolation voltage UiFrequency zoneType of fuseDegree of protectionmmkgAVVHzIP1502.020023010005020502.216230100050DII20502.316400100050DII20502.416230100050DII20502.716230100050DII20Busbars type FS and FSTSpecifications FS400 FS630 FS 1200 FST1200 FST1600 FST2500Rated voltage UeInsulation voltage UiRated current IeShort- circuit rating 1 secDegree of protectionVVAkArmsIP500100040040500100063040500100012005020500100012005020500100016005020500100025005020FusesAutomation Technologies5/1151SKC000013C0201

FastLineFuse SwitchesOrdering DetailsFS Busbar assembly platesDescription Designation Ordering details WeightType No.1 pc/kgFS 400 A/ 150FS 400 A/ 250FS 400 A/ 400FS 400 A/ 600FS 630 A/ 400FS 630 A/ 600FS 630 A/ 800FS 630 A/ 1000FS 1200 A/ 600FS 1200 A/ 800FS 1200 A/ 1000Assembly plate w/ insulated busbarsAssembly plate w/ insulated busbarsAssembly plate w/ insulated busbarsAssembly plate w/ insulated busbarsAssembly plate w/ insulated busbarsAssembly plate w/ insulated busbarsAssembly plate w/ insulated busbarsAssembly plate w/ insulated busbarsAssembly plate w/ insulated busbarsAssembly plate w/ insulated busbarsAssembly plate w/ insulated busbarsNHP 406455 R0001NHP 139201 R0001NHP 139202 R0001NHP 139203 R0001NHP 139212 R0001NHP 139213 R0001NHP 139214 R0001NHP 139215 R0001NHP 139216 R0001NHP 139217 R0001NHP 139218 R00011.94.26.7107.711.415.419.415.821.226.7FS- SR/ SL Busbar assembly plates with bolted side connectionDescription Designation Ordering details WeightType No.1 pc/kgFS- SR 630A/ 250FS- SL 630A/250FS- SR 630A/400FS- SL 630A/400FS- SR 630A/600FS- SL 630A/600FS- SR 630A/800FS- SL 630A/800FS- SR 630A/1000FS- SL 630A/1000FS- SR 1200A/1600FS- SL 1200A/1600Assembly plate with bolted side conn. from the rightAssembly plate with bolted side conn. from the leftAssembly plate with bolted side conn. from the rightAssembly plate with bolted side conn. from the leftAssembly plate with bolted side conn. from the rightAssembly plate with bolted side conn. from the leftAssembly plate with bolted side conn. from the rightAssembly plate with bolted side conn. from the leftAssembly plate with bolted side conn. from the rightAssembly plate with bolted side conn. from the leftAssembly plate with bolted side conn. from the right / ArTuAssembly plate with bolted side conn. from the left / ArTu1SEP 201480 R00011SEP 201480 R00021SEP 201475 R00011SEP 201475 R00021SEP 201468 R00011SEP 201468 R00021SEP 201469 R00011SEP 201469 R00021SEP 201470 R00011SEP 201470 R00021SEP 201513 R00011SEP 201513 R00025.55.58.38.312.212.216.116.120204444FS- R Busbar assembly plates with rear connectionDescription Designation Ordering details WeightType No.1 pc/kgFS- R 630 A/400FS- R 630 A/600FS- R 630 A/800FS- R 630 A/1000Assembly plate with bolted rear connectionAssembly plate with bolted rear connectionAssembly plate with bolted rear connectionAssembly plate with bolted rear connection1SEP 201476 R00011SEP 201471 R00011SEP 201472 R00011SEP 201473 R000110.314.11822FD Busbar assembly plates with sectionalised busbarsDescription Designation Ordering details WeightType No.1 pc/kgFD 630 A/200+200FD 630 A/400+400FD 630 A/600+400Assembly plate with sectionalized busbarsAssembly plate with sectionalized busbarsAssembly plate with sectionalized busbars1SEP 304282 R00011SEP 304262 R00011SEP 304261 R00017.314.614.6FM Busbar assembly plates with space at the right hand side for extra installationsDescription Designation Ordering details WeightType No.1 pc/kgFM 630 A/200+200 Assembly plate with extra space for installations 1SEP 304282 R0001 5FM 630 A/400+200 Assembly plate with extra space for installations 1SEP 304264 R0001 8.7FM 630 A/400+400 Assembly plate with extra space for installations 1SEP 304265 R0001 10FM 630 A/600+200 Assembly plate with extra space for installations 1SEP 304263 R0001 11.8FM 630 A/600+400 Assembly plate with extra space for installations 1SEP 304306 R0001 14FB Busbar assembly plates without busbars, for extra installationsDescription Designation Ordering details WeightType No.1 pc/kgFB 350Assembly plates without busbarsNHP 350802 R0001 2FB 500Assembly plates without busbarsNHP 350802 R0002 4FB 700Assembly plates without busbarsNHP 350802 R0003 4.8FB 900Assembly plates without busbarsNHP 350802 R0004FB 1100Assembly plates without busbarsNHP 350802 R00055/116 Automation Technologies1SKC000013C0201

FastLineFuse SwitchesOrdering Details (continued)FST Busbar assembly platesDescription Designation Ordering details WeightType No.1 pc/kgFST 1200A/ 800FST 1200A/ 1200FST 1600A/ 800FST 1600A/ 1200FST 2500A/ 800FST 2500A/ 1200FST- R 2500A/ 800*FST- R 2500A/ 1200*Assembly plate w/ insulated busbarsAssembly plate w/ insulated busbarsAssembly plate w/ insulated busbarsAssembly plate w/ insulated busbarsAssembly plate w/ insulated busbarsAssembly plate w/ insulated busbarsAssembly plate w/ ins. busb. for rear conn.Assembly plate w/ ins. busb. for rear conn.NHP 139243R 0001NHP 139247R 0001NHP 139241R 0001NHP 139245R 0001NHP 139242R 0001NHP 139246R 0001NHP 139248R 0001NHP 139249R 000130463046446544.565.5* Only for connection from the rear in the middle of the busbars. FST links, screws and washersare included.FST- OETL installation kitsDescription Designation Ordering details WeightType No.1 pc/kgFST- OETL 1250AFST- OETL 1250AFST- OETL 1600AFST- OETL 1600AFST- OETL 1600AInst. kit. Cable con. below/ aboveInst. kit. Cable con. sidew.Inst. kit. Cable con. below/ aboveInst. kit. Cable con. sidew.Inst. kit. Busbar con. sidew.1SEP 407718R 00011SEP 407718R 00021SEP 407751R 00011SEP 407751R 00021SEP 407751R 0009.57.513.910.17.7FST Mounting KitDescription Designation Ordering details WeightType No.1 pc/kgFST 800FST 1200installation kit For concrete substationsinstallation kit For concrete substations1SEP 407703R00011SEP 407704R000168.4Accessories for FST- busbarDescription Designation Ordering details WeightType No.1 pc/kg1. FST 1200/ 1600- S/ B2. FST 1200/ 1600- S3. FST 1200/ 1600- E/ B4. FST 1200/ 1600- E5. FST 2500- S/ B6. FST 2500- S7. FST 2500- E/ B8. FST 2500- E9. FST 1200/ 1600- EFST- link 1200/ 1600- S/ BFST- link 1200/ 1600- SFST- link 1200/ 1600- E/ BFST- link1200/ 1600- EFST- link 2500- S/ BFST- link 2500- SFST- link12500- E/ BFST- link 2500- EFST- link for current transformerNHP 403073R 0001NHP 403073R 0002NHP 403073R 0003NHP 403073R 0004NHP 403070R 0001NHP 403070R 0002NHP 403070R 0003NHP 403070R 0004NHP 200711R 000110.15.25.64.213.48.59.98.214.4Accessories for assembly platesDescription Ordering details WeightType No.1 pc/kgCable terminal torque spannerInsulated hexagon key NV 6Blind cover (50mm)NHSN950001P0002NHSN950001P0006NHP 300185R00010.10.1FusesAutomation Technologies5/1171SKC000013C0201

FastLineFuse SwitchesOrdering Details (continued)Incomer modulesDescription Designation / Cable size mm 2 / Ordering details WeightModule width mm Type No. 1 pc/kgDK 95 / 250 ADirect conn. module 10- 95 / 50NHP 139226 R0001 1.2DK 240 / 50 / 400 A Direct conn. module 95- 24 / 50NHP 100009 R0001 1.5DK 240 / 100 / 400 A Direct conn. module 95- 240 / 100NHP 139227 R0001 3.5DK 300 / 800 ADirect conn. module 120- 300 / 100NHP 139228 R0001 5DS 400 / 400 ADirect conn. module (bolt) / 50NHP 139230 R0001 1.4K 95 / 250 ACable conn. module 10- 95 / 50NHP 139220 R0001 2.2K 240 / 400 ACable conn. module 95- 240 / 100NHP 139221 R0001 4.2M/ P 240 / 400 ACable switch module 95- 240 / 100NHP 139222 R0001 4.8Fuse switch disconnector modulesDescription Designation / Cable size mm 2 / Ordering details WeightModule width mm Type No. 1 pc/kgSLK 160 / 160 A Fuse switch module 10- 95 / 50NHP 139224 R0001 2.1SLK 400 / 400 A Fuse switch module 95- 240 / 150 NHP 139225 R0001 6.5SLK 630 / 630 A Fuse switch module 2x( 120- 300) / 200 NHP 139235 R0001 7.3Fuse disconnector modules Ð single phaseDescription Designation / Cable size mm 2 / Ordering details WeightModule width mm Type No. 1 pc/kgSLKD 63 / 63 AFuse switch module Diazed DII 10- 95 / 50 NHP 139223 R0001 2SLK- NH 160 / 160 A Fuse switch module 10- 95 / 50NHP 139238 R0001 2Service moduleDescription Designation / Cable size mm 2 / Ordering details WeightModule width mm Type No. 1 pc/kgSM 200 / 200 AService module / 150 mmNHP 139237 R0001 2MM 230 / 16 AService module / 50 mmNHTF001990 R0001 2.2MM 400 / 230/ 16 A Service module / 50 mmNHTF001990 R0002 2.3S 230 / 16 AService module / 50 mmNHTF001990 R0003 2.4SJ 230 / 16 AService module / 50 mmNHTF001990 R0004 2.7SLK- E adapters for ISOMAXDescription Designation / Cable size mm 2 / Ordering details WeightModule width mm Type No. 1 pc/kgAdapter for MCCB Isomax S1Adapter for MCCB Isomax S2Adapter for MCCB Isomax S3Adapter for MCCB Isomax S5Adapter for MCCB Isomax S6Adapter for MCCB Isomax S73 P S1 N 125 FFC / 100 mm3 P S2 N 160 FFC / 100 mm3 P S3 N 250 FF 150 mm3 P S5 N 400 LI, FF / 150 mm3 P S6 N 630 & N 800 LI, FF / 250 mm3 P S7 N 1250 & N 1600 LI, FF / 250 mmNHP 101371 R0001NHP 101432 R0001NHP 101433 R0001NHP 101437 R0001NHP 101438 R0001NHP 101439 R00012.62.83.43.76.710.15/118 Automation Technologies1SKC000013C0201

FastLineFuse SwitchesOrdering Details (continued)Accessories for modulesDescription Designation / Cable size mm 2 / Ordering details Packing WeightModule width mm Type No. unit 1 pc/kgKJK 95KJK 240KJM 240KJS 240Contact linksExtra switch elementExtra fuse carrierSNH 160 single pole fuse carrierProtection coverProtection coverProtection coverCopper linksCopper linksCable holder ¯ 20- 40Cable holder ¯ 35- 60Cable protectionCable protectionOperating handleCable terminal singleCable terminal doubleCable terminal singlePE earthing clampPE earthing clampPE earthing clampCable terminal 10- 95 mm 2 _M8Cable termnal 95- 240 mm 2 _M10PEN- clampPEN- clampBracket with 6 PEN clampsPEN- clamp with bracketPEN clamp with bracketPEN- bar 350 mmPEN- bar 500 mmPEN- bar 700 mmPEN- bar 900 mmPEN- bar 1100 mmNeutral isolatorEarthing cover for SLK 160Earthing cover for K 240Earthing device for M/ P 240Eathing cover SLK 400K 95M/ P 240SLKD 63SLK- NH 160DS 4002 x DS 4003 x DS 4002 x DS 4003 x 400 DSCable 10- 95 mm 2Cable 95- 240 mm 2Cable 10- 95 mm 2Cable 95- 240 mm 2f. Switch module M/ P240120- 300 mm 22 x (120- 300 mm 2 )Cu/ AI cable 70- 240 mm 2Up to 50 mm 2Up to 120 mm 2Up to 240 mm 210- 95 mm 295- 240 mm 2Cu/ AI cable 16- 95 mm 2Cu/ AI cable 95- mmCu/ AI cable 10- 95 mm 2Cu/ AI cable 10- 95 mm 2Cu/ AI cable 95- 240 mm 2SeparatePEN- bar for FSassembly platesFor N. barNHP 300173 R0001NHP 300174 R0001NHP 300175 R0001GSLB 230010 R0002NHP 300162 R0001NHP 300163 R0001NHP 407190 R0001NHP 407194 R0001NHP 406213 R0001NHP 406214 R0001NHP 405108 R0001NHP 407174 R0001NHP 407178 R0001NHP 405065 R0001NHP 405065 R0002NHP 405065 R0003NHP 405065 R0004NHP 405065 R0005GZN 560029P0016NHP 139231 R0001NHP 139232 R0001NHP 139233 R0001NHP 139234 R0001NHP 300221 R0001NHP 300222 R0001NHP 300223 R0001NHP 301570 R0001NHP 139236 R0001NHP 139236 R0002NHP 139236 R0003NHP 300213 R0001NHP 300214 R0001NHP 300141 R0001NHP 300143 R0001NHP 300142 R0001NHP 300144 R0001NHP 300212P000111111111111331111111111111111111111111,31,61,52,20,310,50,30,60,70,80,30,50,170,270,020,030,010,80,20,010,050,080,080,240,120,181,80,210,40,81,191,692,252,75FusesAutomation Technologies5/1191SKC000013C0201

S01121APowerLineSwitche Fuses OSDimensional Details (continued)OS MiniØ66514...8530EN 50022OA 3G01OA 1G10max 3+3OSZ 438I3585 97OS 20...32B12_OS 25...32F12_OS 30A12_O TestOA4B1Cmax 1+1OS 20...32B22_OS 25...32F22_OS 30A22_OA 3G01OA 1G10 OSZ 4max 3+37475...80IO TestOA4B1Cmax 1+175...8065S00579C36459395105135...2109334,514,3 30,8 27,610693335,614,34,530,8 27,614241 41IEC 269-2-1UL 198CCSA C22.2 No.106NFC63210,-63211OS25F1210OS32F1214OS30A12JOS30A12CCBS88-2IEC 269-2-1OS20B12A1OS32B12A1OS32B12A2BS88-6OS32B12F1OS20B22A1FOS32B22A1FOS25F2210FOS32F2214FIEC 269-2-1NFC63210,-63211OS20B22A1N1 OS25F2210OS32B22A1N1 OS32F2214OS32B22A2N1OS32B22F1N1OS25F2210N1OS32F2214N1BS88-2IEC 269-2-1OS20B22A1OS32B22A1BS88-6OS32B22F1OS 40 D12000OS 40 D22000_Ø66514...13330EN 50022OA 3G01OA 1G10 OSZ 4max 3+338I3585 97O TestOA4B1Cmax 1+1OA 3G01OA 1G10max 3+375...80OSZ 474IO TestOA4B1Cmax 1+175...80S01397A6536459594,594,5121 14,3 30,8 27,614,3 30,8133135...210331063314227,641 41DIN 000 DIN 000OS40D12000OS40D22000N1OS 30...63612814...128EN50023EN50022OA 3G01OA 1G10max 3+351,5OA 3G01OA 1G10max 1+164,7OA 3G01OA 1G10max 3+396,5OA 3G01OA 1G10max 1+164,75050Ø66100IO9279100IO92796545OS _B_, -F_, -C_, -J_OS _D_ 137141...26011943,53329601434,440,57,8333,545292945,56018840,57,864,7M446,546,560 6010,510,592NFC 14x51NFC 22x58UL J30, J60DIN 000CSA C30, C60 BS 88 A2, A3 DIN 00OS 50F12 OS 32B12 OS 32D12OS 63F12 OS 63B12 OS 63D12OS 60J12OS 32C12OS 60C12NFC 14x51NFC 22x58UL J30, J60DIN 000CSA C30, C60 BS 88 A2, A3 DIN 00OS 50F22 OS 32B22 OS 32D22 OS 32_22N1OS 63F22 OS 63B22 OS 63D22 OS 63_22N1OS 60J22OS 32_22FOS 32C22OS 63_22FOS 60C225/120 Automation Technologies1SKC000013C0201

PowerLineSwitche Fuses OSDimensional Details (continued)OS 100...160 DIN- and NFC-types, OS 100 BS-typesMechanism at the end of the switch fuse14...129,56129,567,52 2634/ 67,513OS 125D03OS 160D03EN50022EN50023OA 3G01OA 1G10max 3+35,5x7Test Indmax 1OS 100F03 OS 100B03OS 125F0319,7OS 160___W9x13OA 3G01OA 1G10max 1+119,715Ø4OA 3G01OA 1G10max 3+3OS 125D04 OS 100F04 OS 100B04OS 160D04 OS 125F0419,7OS 160___W9x13OA 3G01OA 1G10max 3+35,5x7Test Indmax 1OA 3G01OA 1G10max 1+119,715Ø4OA 3G01OA 1G10max 3+3Ø6698 144120IO110,5 144 9846 123,5 120IO46123,5110,565364553635OS _B_, -F_, -C_ 112,575,5OS _D_ 131169140...26333179,53523,56,6x10,6333675,535204214,53523,56,6x10,63737110,5OS_03120,5129,5120,5129,5M5169DIN 000NFC 22x58 BS 88 A2-A3 DIN 00OS 100F03 OS 100B03 OS 125D03OS 125F03OS 160D03DIN 000 DIN 000NFC 22x58 BS 88 A2-A3 DIN 00 DIN 00OS 100F04 OS 100B04 OS 125D04 OS 160D04FOS 125F04OS 160D04S01117A110,5M5OS_04204OS _B04F BS 88 A2-A3OS _F04F NFC 22x58OS _B04N2OS _F04N2OS _D04N2OS 125...200 BS- and OS 100 CSA-typesMechanism at the end of the switch fuse129,567,514...129,5 2 26634/67,513EN50022EN50023OS 125B03 OS 100C03OS 160B0319,7OS 160___W9x13OA 3G01OA 1G10max 3+35,5x7Test Indmax 1OA 3G01OA 1G10max 1+119,715Ø4OA 3G01OA 1G10max 3+3OA 3G01OA 1G10max 3+35,5x7OS 125B04 OS 100C04OS 160B0419,7OS 160___WTest Indmax 1OA 3G01OA 1G10max 1+119,7159x13Ø4OA 3G01OA 1G10max 3+3Ø66110,5144 120124IO144 12046 123,5 124IO46123,5110,56536455OS 100C_OS 125B_ 120,5140...263333675,535169179,53523,56,6x10,6333675,535204214,53523,56,6x10,6110,5OS_0337120,5129,537120,5129,5FusesM5169CSA C60CSA C100 BS 88 A2-A4OS 100C03 OS 125B03CSA C60CSA C60CSA C100CSA C100 BS 88 A2-A4 BS 88 A2-A4OS 100C04 OS 125B04 OS 100C04F OS 100C04N2OS 125B04F OS 125B04N2S01115A110,5M5OS_04204Automation Technologies5/1211SKC000013C0201

PowerLineSwitche Fuses OESADimensional DetailsOESA 200...400 A, DIN and BS- pattern1105212FO713661256047150EOOFFION72001755S00142C455HG230...3404512,5477 C D O11 2552 BADIN- pattern BS- pattern A (mm) B (mm) C (mm) D (mm) E (mm) F (mm) G (mm) H (mm)OESA 250D1PLOESA 250D2PLOESA 250D3PLOESA 250D4PLOESA 250DF4PLOESA 400D1PLOESA 400D2PLOESA 400D3PLOESA 400D4PLOESA 400DF4PLOESA 200B1PLOESA 200B2PLOESA 200B3PL, 250B3PLOESA 200B4PL, 250B4PL-OESA 315B1PL, OESA 400B1PLOESA 315B2PL, OESA 400B2PLOESA 315B3PL, OESA 400B3PLOESA 315B4PL, OESA 400B4PL-138200262324324146216286256256741361982602608215222229229237373737374141414141-62626262-7070707016216216216216218018018018018060606060605151515151199199199199199206206206206206185185185185185192192192192192OESA 630...800 A, DIN and BS- pattern1076512104O9176692,523219095OOFFION9290250145S00146C456220234255...325406206024,5 C D O13 4053 BADIN- pattern BS- pattern A (mm) B (mm) C (mm) D(mm)OESA 630D1PLOESA 630D2PLOESA 630D3PLOESA 630D4PLOESA 630DF4PLOESA 800D1PLOESA 800D2PLOESA 800D3PLOESA 800D4PLOESA 800DF4PLOESA 630B1PLOESA 630B2PLOESA 630B3PLOESA 630B4PL-OESA 800B1PLOESA 800B2PLOESA 800B3PLOESA 800B4PL-18326334342342319328337346346311819827835835812821830839839859595959596464646464-80a8080-909090905/122 Automation Technologies1SKC000013C0201

ONPowerLineSwitche Fuses OESA, AccessoriesDimensional DetailsPlastic handles:Ø663645Type L handle B shaftlength diameterS00473AO OFFI ONLBOH_45J5 45 5OH_65J5 65 5OH_45J6 45 6OH_65J6 65 6OH_80J6 80 6OH_125J12 125 12OH_145J12 145 12OH_175J12 175 12OH_275J12 275 12O32O75S00621A45°O OFFI ON53O 3253O 7S00375BDoor drilling forOH_ handles:Door drilling forplastic handlesOH_...EOO2S in sideoperated switches:Metallic handles:O7S00246AS00128AS00150AOFF32 18100A45o4556S00378A5,5 min 30YASDA 7, 8 (A=220) Door drilling for YASDA: OETLZX 74 (for side-operatedswitches 200...400 A)Minimum distance L between the hinge and the rotating shaftDoor drilling for OETLZX 74FusesLOESASizes [A]L[mm]SuitablehandlesS00374CShaftHinge32...6332...160200...400200...800200...8006080150175275220OH_45J_, OH_65J_OH_80J_OH_125J12, OH-145J12OH_175J12OH_275J12YASDA 7, 8Automation Technologies5/1231SKC000013C0201

PowerLineSwitche Fuses OESA, AccessoriesContact FunctionsONI ONON and OFF-functions of auxiliary and main contactsOFFO OFFo o o o0 30 60 90 αCLOSINGS00373BαMain contactsNo auxiliary contactNc auxiliary contact0➠I0 I36➠4512S00491A1. Main contacts close2. No auxiliary contacts close3. Nc auxiliary contacts openOPENINGOFFON0I= Contacts in closed position= Contacts in closed position4. Main contacts open5. No auxiliary contacts open6. Nc auxiliary contacts closePowerLine, OESA_PL, 200 A...400 AON and OFF-functions of auxiliary and main contactso o o o0 30 60 90 αAuxiliarycontactContact configurationMain contactsNo auxiliary contactNc auxiliary contactOFF0S00110AONIOZXK 1OZXK 2OZXK 3OZXK 4OZXK 5OZXK 61 no - 1 nc2 no - 2 nc4 no - 4 nc2 no4 no8 noPowerLine, OESA_PL, 630 A...800 AON and OFF-functions of auxiliary and main contactso o o o0 30 60 90 αAuxiliarycontactContact configurationMain contactsNo auxiliary contactNc auxiliary contactOFF0S00103AONIOZXK 1OZXK 2OZXK 3OZXK 4OZXK 5OZXK 61 no - 1 nc2 no - 2 nc4 no - 4 nc2 no4 no8 no5/124 Automation Technologies1SKC000013C0201

FuseLineHRC Fuse links, type gG, 500VDimensional DetailsdOFA_ 000OFA_ 00OFA_ 0OFA_ 1OFA_ 2OFA_ 3headhOFA_ 4aeaFuselink a b c d e f g hOFA_000_2-100 79 52,5 20,8 49,5 52 6 35 15OFA_00_125-160 79 59,5 29,5 50 52,8 6 35 15OFA_0_6-160 125 59,5 29,5 66 66,8 6 35 15OFA_0_200-250 125 59,5 39,5 66 66,8 6 35 20OFA_1_16-100 135 64,5 29,5 68 70,8 6 40 15OFA_1_125-315 135 66 39,5 68 70,8 6 40 20OFA_2_35-250 150 72 39,5 68 72,3 6 48 20OFA_2_300-400 150 72 51 68 72,3 6 48 26OFA_3_250-400 150 83,5 51 68 72,3 6 60 26OFA_3_425-800 150 86 70 68 72,3 6 60 33OFA_4_400...1250 200 119 89 68 85 8 85 49OFA_4A_500...1250 200 119 89 88 85 8 85 49hgOFA_ 000OFA_ 00OFA_ 0OFA_ 2OFA_ 4f cgdeabgOFA_ 3( -400A)OFA_ 1fcgOFA_ 3(425-800A)fcOFA_4_fcFusesS01566AbbbAutomation Technologies5/1251SKC000013C0201

SlimLineFuse SwitchesDimensional DetailsFront / side view5/126 Automation Technologies1SKC000013C0201

Distance between busbars (top view)SlimLineFuse SwitchesDimensional Details (continued)Position of the contact fingersFusesAutomation Technologies5/1271SKC000013C0201

SlimLineFuse SwitchesDimensional Details (continued)Cable connection5/128 Automation Technologies1SKC000013C0201

SlimLineFuse SwitchesDimensional Details (continued)Contact extensionsFusesAutomation Technologies5/1291SKC000013C0201

SlimLineFuse SwitchesDimensional Details (continued)Contact extensionsSize 00, 185 mm distance between phases52952577,5185 185495295258377,5 185 1854654252519977,5185 185200182182Size 1, 185 mm distance between phasesSize 2 and 3, 185 mm distance between phases5/130 Automation Technologies1SKC000013C0201

EasyLineFuse SwitchesDimensional DetailsXLP 000XLP 00XLP 1FusesAutomation Technologies5/1311SKC000013C0201

EasyLineFuse SwitchesDimensional Details (continued)XLP 2XLP 35/132 Automation Technologies1SKC000013C0201

EasyLineFuse SwitchesDimensional Details (continued)XLP00 - A40/ 75XLP00 - A40/ 120XLP00 - A60/ 60FusesAutomation Technologies5/1331SKC000013C0201

EasyLineFuse SwitchesDimensional Details (continued)XLP1 - A60/ 85XLP1 - A40/ 120SF - 60 System5/134 Automation Technologies1SKC000013C0201

EasyLineFuse SwitchesDimensional Details (continued)Front frame XLP 000 Front frame XLP 00Front frame XLP 1 Front frame XLP 2Front frame XLP 3FusesAutomation Technologies5/1351SKC000013C0201

EasyLineFuse SwitchesDimensional Details (continued)SLP 00 4 poleSLP K1 4 poleSLP K2/ 3 4 pole5/136 Automation Technologies1SKC000013C0201

InLineFuse SwitchesDimensional DetailsXUBM00-100XUBM00-3P-100XUBM00XUBM1/2/348,5 404397,540682929119,5113Fuses185185655,5655,5185185959519,521,5 27 30,51SEB0000202547,5442727 461SEB000021Automation Technologies5/1371SKC000013C0201

InLineFuse SwitchesDimensional Details (continued)XUBM00-1PXUBM00-3P66048,519,5 29 29 11318518595 5,5112,518 30 309 15 6633,5 96 607,7 5,31SEB00005366048,5185 95 5,5185113292919,5112,518 30 309 21 61 15733 95,3607,76,21SEB000054XUBM1/2/3-1PXUBM1/2/3-3P97,51129 56 9197,5112,5660185607,71859554,59 56 91 172,5119660185607,71859554,52547,5119442727 46 33,5 156,21SEB00005125 47,544272746 33 156,21SEB0001025/138 Automation Technologies1SKC000013C0201

InLineFuse SwitchesDimensional Details (continued)XUBM00-ZXUBM1/2/3-Z48,540 4323 14,597,540 6824 15,5655,519,5 29 29 1091851859821,5 27 30,51SEB00008665527 44 115 185 185 9825 47,5 27 461SEB000111XUBM00-3P-ZXUBM1/2/3-3P-Z48,5 23 15 112,5 9 21 61 1575,397,5 24 18 11259 56 91 172,5660185607,7Fuses1854,5660185607,798,5619,5 29 29 10918598,518 30 3033 961SEB00008725 47,5115,5442727 46 33 156,21SEB000088Automation Technologies5/1391SKC000013C0201

InLineFuse SwitchesDimensional Details (continued)XUBM1/2/3-3P-ZS97,5 5424 18 112,5114115,57111418566071607,7114185134,59959 56 91 172,5XUBM00CT rear sideinstallation37,5444,525 47,541,52727 46 33156,21SEB000103XUBM1/2/3-3P-Z2S11024 1897,5 112,559 56 91 172,54,5XUBM1/2/3CT rear sideinstallation37,5114115,57111441,5185660607,771114185134,59925 47,5442727 46 33156,21SEB0000905/140 Automation Technologies1SKC000013C0201

FastLineFuse SwitchesDimensional DetailsBusbarsFS 400 - 630 - 1200 AType A(mm) B(mm) C(mm) D(mm E(mm)FS 400A/ 150FS 400A/ 250FS 400A/ 400FS 400A/ 600FS 630A/ 400FS 630A/ 600FS 630A/ 800FS 630A/ 1000FS 1200A/ 600FS 1200A/ 800FS 1200A/ 10001502504006004006008001000600800100015025040060040060080010006008001000150250400600400600800100060080010001502504006004006008001000600800100015025040060040060080010006008001000BusbarsFST 1200 - 1600 - 2500 AFusesType A(mm) B(mm)FS 1200A/ 800FS 1200A/ 1200FS 1600A/ 800FS 1600A/ 1200FS 2500A/ 800FS 2500A/ 1200800120080012008001200600100060010006001000Automation Technologies5/1411SKC000013C0201

FastLineFuse SwitchesDimensional Details (continued)BusbarsFS-SR/ SL 630 AType A(mm) B(mm) C(mm) D(mm E(mm) F(mm)FS- SR 630A- 250FS- SL 630A- 250FS- SR 630A- 400FS- SL 630A- 400FS- SR 630A- 600FS- SL 630A- 600FS- SR 630A- 800FS- SL 630A- 800FS- SR 630A- 1000FS- SL 630A- 100025025040040060060080080010001000--236236364364600600800800------200200200200------200200200200------200200200200--------200200BusbarsFS-SR/ SL 1200 AType A(mm) B(mm) C(mm) D(mm E(mm) F(mm) G(mm) H(mm)FS- SR 1200A- 1600FS- SL 1200A- 160016001600200200200200200200200200200200200200200200BusbarsFS- R 630 AType A(mm) B(mm) C(mm) D(mm E(mm) F(mm) G(mm)FS- R 630A- 400FS- R 630A- 600FS- R 630A- 800FS- R 630A- 10004006008001000236364----200200--200200--200200--2002001353353353355/142 Automation Technologies1SKC000013C0201

FastLineFuse SwitchesDimensional Details (continued)Moudule typesAdapters for ISOMAXType A(mm) B(mm) C(mm) D(mm) E(mm) F(mm) G(mm) H(mm) I(mm) K1(mm) K2(mm) M(mm)SLK- E, S1SLK- E, S2SLK- E, S3SLK- E, S5SLK- E, S6SLK- E, S7125 A160 A250 A400A630/ 800 A1250/ 1600 A9999149149249249228228244244244277291291291291291303256256278278309358169169185185185218210210210210210254197197219219250299178178180180196212-----252119119121121137153-----193490490403403490560FusesAutomation Technologies5/1431SKC000013C0201