Thermo Scientific Automatic 210 Biopure Distilled Water Center

More documents

Recommendations

Info

Thermo Scientific Symptom (cont.) Probable Cause (cont.) Test and Remedy (cont.) Distilled Water Center will not start. Distilled Water Center starts but will not produce distillate. Section 6 Troubleshooting Storage tank full. Drain storage tank to level monitor cut-in point. Trapped distillate line. Inadequate water supply to Distilled Water Center. Malfunction in automatic drain valve. Low voltage to heater circuit. Ensure that main circuit breakers in electrical supply are on. If they are on and trouble still exists, notify plant electrician. Check voltage. If appreciably lower than rated voltage, notify plant electrician. Check level monitor adjustment and circuit connections at monitor and at electrical box. Replace monitor if condition cannot be corrected. Check the power source to level monitor 120VAC to make sure you have power to Level Monitor. Replace Level Monitor if you have 120VAC line cord and it’s set correctly. Check POWER switch and replace if faulty. Check interval timer microswitch and replace if faulty. Check connections in electrical box and tighten as necessary. Ensure that solenoid valve cords are plugged into electrical outlet. Check solenoid valves and clean or repair in accordance with instructions in this section. Ensure that water shutoff valve in water inlet line is open and cooling water control valve is adjusted properly. Check solenoid valves and clean or repair. Ensure that drain valve is closed and not leaking. Clean or repair if necessary. Check voltage. If it is less than what is stated on nameplate on side of electrical box, notify electrician. Distilled Water Center 6-3
Section 6 Troubleshooting Symptom (cont.) Probable Cause (cont.) Test and Remedy (cont.) Water Center starts but will not produce distillate. No electrical power to heater circuit. Check all wiring and connections in the electrical box. Check contactor coils and points and replace contactor if burned out. Ensure that leads are connected to low water cutoff electrode assembly terminals. 6-4 Distilled Water Center Thermo Scientific
Page 1 and 2: Thermo Scientific Automatic 210 Bio
Page 3 and 4: Preface Important Read this instruc
Page 5 and 6: Preface iv Distilled Water Center D
Page 7 and 8: Table of Contents Section 5 Section
Page 9 and 10: Section 1 Safety Information To avo
Page 11 and 12: Section 2 Installation Wall Mountin
Page 13 and 14: Section 2 Installation Plumbing Con
Page 16 and 17: Thermo Scientific Storage Tank Sect
Page 18 and 19: Thermo Scientific Automatic Water S
Page 20 and 21: Thermo Scientific Initial Operation
Page 22: Legend A - Deconcentrator Valve B -
Page 25 and 26: Section 5 Maintenance Hard Scale Re
Page 27 and 28: Section 5 Maintenance Disassembly f
Page 29 and 30: Section 5 Maintenance Heating Eleme
Page 31 and 32: Section 5 Maintenance Automatic Wat
Page 33 and 34: Section 5 Maintenance Valve Disasse
Page 35 and 36: Section 5 Maintenance Figure 5-5. P
Page 37 and 38: Section 5 Maintenance Level Monitor
Page 39 and 40: Section 5 Maintenance Interval Drai
Page 42 and 43: Thermo Scientific Section 6 Trouble
Page 46: Thermo Scientific Section 7 Technic
Page 49 and 50: Section 8 Parts List Ventgard Parts
Page 51 and 52: Section 8 Parts List Figure 8-3. So
Page 53 and 54: Section 8 Parts List Figure 8-5. Pu
Page 55 and 56: Section 8 Parts List Figure 8-8. El
Page 57 and 58: Section 8 Parts List 41 Figure 8-10
Page 59 and 60: Section 8 Parts List Figure 8-11. A
Page 61 and 62: Section 8 Parts List Figure 8-13. A
Page 64: Thermo Fisher Scientific 401 Millcr

Thermo Scientific Automatic 210 Biopure Distilled Water Center

Create successful ePaper yourself

Delete template?

Save as template?