LIBERA Series - Scame Parre S.p.A.
LIBERA Series - Scame Parre S.p.A.
LIBERA Series - Scame Parre S.p.A.
Create successful ePaper yourself
Turn your PDF publications into a flip-book with our unique Google optimized e-Paper software.
<strong>LIBERA</strong> <strong>Series</strong><br />
Connectors and consumer units<br />
for electric vehicles
<strong>LIBERA</strong> <strong>Series</strong><br />
> CONNECTORS FOR ELECTRIC VEHICLES > REFERENCE STANDARDS<br />
CEI 69-6<br />
Standardization sheet of plug and socket-outlet for the<br />
connection of eletric road vehicles to the supply network.<br />
IEC 62196-1<br />
Plugs, socket-outlets, vehicle couplers and vehicle<br />
inlets - Conductive charging of electric vehicles.<br />
Part 1: charging of electric vehicles up to 250A a.c. and 400A d.c.<br />
23H / 204 / NP IEC62196-2<br />
Plugs, socket-outlets and vehicle couplers - Conductive<br />
charging of electric vehicles.<br />
Part 2: dimensional interchangeability requirements for pin<br />
and contact-tube vehicle couplers.<br />
> VERSIONS<br />
Plugs<br />
IEC 61851-1<br />
Electric vehicle conductive charging system.<br />
Part 1: general requirements.<br />
Connectors<br />
> QUALITY MARKS<br />
Flush mounting sockets<br />
Appliance inlets<br />
Adaptors for domestic applications<br />
> TECHNICAL CHARACTERISTICS<br />
Rated current:<br />
16A - 32A<br />
Rated voltage: 230V~<br />
Frequency:<br />
50Hz<br />
Insulating voltage: 230V~<br />
Protection degree:<br />
IP40 (IP20 for adaptors)<br />
Operating temperature<br />
according to the<br />
reference standard: -25°C+40°C<br />
Max. operating temperature: 60°C<br />
Glow Wire test:<br />
650°C/850°C<br />
Material:<br />
Engineering plastic<br />
IK degree at 20°C:<br />
IK07<br />
Cable inlets:<br />
Cable sleeve IP44<br />
Cable gland IP67<br />
2
BEHAVIOUR WITH CHEMICAL AND ATMOSPHERIC AGENTS<br />
Saline<br />
solution<br />
Resistant<br />
Concentrated<br />
Limited<br />
Resistance<br />
Acids<br />
Resistant<br />
Limited<br />
Resistance<br />
Bases<br />
Diluted Concentrated Diluted Hexane Benzol Acetone Alcohol<br />
Resistant<br />
For specific substances please contact our technical service.<br />
Not<br />
Resistant<br />
Not<br />
Resistant<br />
Solvents<br />
Not<br />
Resistant<br />
Limited<br />
Resistance<br />
Mineral<br />
oil<br />
Resistant<br />
UV<br />
rays<br />
Resistant<br />
<strong>LIBERA</strong> <strong>Series</strong><br />
> WIRING AND INSTALLATION<br />
Wiring capacity of the terminals (mm 2 )<br />
Rated<br />
voltage<br />
Rated<br />
current (A)<br />
Plugs, connectors<br />
and appliance inlets<br />
Min<br />
Max<br />
Socket outlets<br />
Min<br />
Max<br />
over 50V<br />
16A 1<br />
32A<br />
2,5<br />
2,5<br />
6<br />
1,5 4<br />
2,5 10<br />
> APPLICATION EXAMPLES<br />
3
<strong>LIBERA</strong> <strong>Series</strong><br />
> THE “SAFE-IN” SAFETY DEVICE<br />
The “SAFE-IN” device works like the protection installed on<br />
household sockets, i.e., by means of an appropriate shutter, it<br />
closes the input of the socket contact tubes and prevents<br />
accidental and voluntary contact of live parts of the socket with<br />
slim objects, such as screwdrivers or wires. This protection offers<br />
an additional safety guarantee, in addition to that already<br />
provided by the spring-loaded cover assembled on the mobile<br />
sockets.<br />
> PILOT<br />
The indispensable safety during the conductive recharge of the<br />
eletric road vehicles is assured by the use of plug and socket<br />
outlet provided of back up terminal (pilot) in addition to the active<br />
and protection poles.<br />
The back up terminal allow to make a control pilot circuit with the<br />
following functions:<br />
- verification that the vehicle is properly connected;<br />
- continuous protective earth conductor integrity checking;<br />
- energization of the system;<br />
- de-energization of the system.<br />
Connector tube protective shutter for greater safety against direct<br />
contacts. (The SAFE-IN safety device).<br />
4
EXAMPLE OF ELECTRICAL ROAD VEHICLES CHARGING<br />
Charging station<br />
Vehicles<br />
<strong>LIBERA</strong> <strong>Series</strong><br />
230V<br />
Connection<br />
Charger<br />
820<br />
ohm<br />
Electronic control board<br />
Back-up terminal (pilot)<br />
The indicated solution, that is checking the presence of a 820 ohm resistence, is the adopted solution in Italy and also in the order European country.<br />
> SNAP-ON DEVICE<br />
OPENING<br />
The product is supplied in the open position;<br />
opening is obtained by a simple rotation of the<br />
handgrip or of the fruit.<br />
CLOSURE<br />
The spring located on the side of the handgrip<br />
locks the same on the contact-holding fruit.<br />
The assembly is locked through a simple<br />
rotation, engaging the spring into its seat.<br />
INSPECTION<br />
Opening is possible by means of a tool (screw<br />
driver) to be used following the ideographs<br />
marked on the handgrip.<br />
5
Connector for electric vehicles<br />
> CONNECTOR FOR ELECTRIC VEHICLES - IP44<br />
Description<br />
Adaptors for<br />
domestic use<br />
Type<br />
Italian plug (P17) 16A-230V~<br />
2P+E - IP20<br />
French-German plug 16A-230V~<br />
2P+E - IP20<br />
10/100 200.01623<br />
10/100 200.01624<br />
Plug<br />
16A-230V~ 2P+E+pilot - IP44 10/100 200.01633 200.01633A<br />
32A-230V~ 2P+E+pilot - IP44 10/100 200.03233<br />
Description<br />
Type<br />
Flange<br />
Connectors<br />
Flush mounting<br />
socket<br />
Angled socket<br />
16A-230V~ 2P+E+pilot - IP44 10/100 200.01643<br />
32A-230V~ 2P+E+pilot - IP44 10/100 200.03243<br />
16A-230V~ 2P+E+pilot - IP44 70x87 mm 10/100 200.01663<br />
32A-230V~ 2P+E+pilot - IP44 70x87 mm 10/100 200.03263<br />
16A-230V~ 2P+E+pilot - IP44 70x87 mm 10/100 200.01693<br />
32A-230V~ 2P+E+pilot - IP44 70x87 mm 10/100 200.03293<br />
> SUPPLY PANEL FOR ELECTRIC VEHICLES (STANDARD)<br />
Technical characteristics<br />
- Version with earthing conductor control card for selfpropelling<br />
electric vehicles (as adopted in Italy – 3 charge<br />
mode – and as specified in the standard CEI 69-6 regarding<br />
recharging in areas open to third parties).<br />
- N. 2 Libera series 2P+E+ pilot according to CEI 69-6.<br />
- Socket protection with D curve bipolar MT switch and<br />
“A - 30 mA” type differential on each socket.<br />
- Emergency cut-off of the recharging system (and the supply<br />
of the sockets).<br />
- Panel supply voltage: 230 Vac.<br />
- Rated current: 32A<br />
6<br />
Description<br />
With 1 Libera <strong>Series</strong> 16A flush socket and emergency push-button 1 671.2016-733<br />
With 2 Libera <strong>Series</strong> 16A flush sockets and emergency push-button 1 671.3026-480
CONNECTORS FOR ELECTRIC VEHICLES WITH RFID SYSTEM (UB1/UB2 PERSONAL)<br />
Description<br />
Type<br />
Mobile plug + TAG 16A-230V~ 2P+E+pilot - IP44 10/100 200.01633T<br />
Mobile plug + TAG + Plug Card (*) 16A-230V~ 2P+E+pilot - IP44 10/100 200.01633TC<br />
(*) Plug Card which contains the same identification code as the plug<br />
<strong>LIBERA</strong> <strong>Series</strong><br />
> SUPPLY PANEL FOR ELECTRIC VEHICLES WITH RFID SYSTEM<br />
Description<br />
Version with one socket and emergency button with RFID system<br />
for recognizing the authorized plug<br />
Version with two sockets and emergency button with RFID system<br />
for recognizing the authorized plug<br />
The panel is supplied with a Master Card board for programming<br />
1 200.UB1<br />
1 200.UB2<br />
> CONTROL SYSTEM / MENAGEMENT<br />
Description<br />
User Card: activates the functions of the personal UB1/UB2 panel<br />
allowing energy drawing with TAG-less Libera plugs also<br />
Programmer: User Card programming device (for entering enabling<br />
parameters and code)<br />
1 200.UBC<br />
1 200.UBPRO<br />
> ACCESORIES<br />
Description<br />
Tubular pole in galvanized steel 1 654.0650<br />
Fastening plate 1 654.0651<br />
7
<strong>LIBERA</strong> <strong>Series</strong><br />
> UB1 / UB2 PERSONAL WITH MASTER CARD<br />
The socket is dead until an<br />
authorized (user) plug is<br />
inserted<br />
The socket is protected<br />
against non-authorized plugs<br />
An innovative system for management and control of an<br />
electrical capable of enabling the supply service for authorized<br />
users only.<br />
The PERSONAL UB1 and UB2 modules use RFID technology for<br />
unique recognition of the user requesting connection; this control<br />
allows the socket to be kept dead until recognition of an<br />
authorized plug. Unique user identification for assignment of<br />
responsibility, a system which is certainly useful when supplying<br />
electricity in environments which are open to the public.<br />
Self-learning of the plugs to<br />
be authorized with<br />
Master Card<br />
Automatic identification and<br />
control of the user during<br />
connection<br />
> APPLICATION EXAMPLES<br />
8
DIMENSIONS<br />
ENCLOSURES<br />
<strong>LIBERA</strong> <strong>Series</strong><br />
ENCLOSURES<br />
(Dimensions in mm)<br />
9
<strong>LIBERA</strong> <strong>Series</strong><br />
> DIMENSIONS<br />
ADAPTOR FOR DOMESTIC APPLICATIONS - 16A<br />
ADAPTOR FOR DOMESTIC APPLICATIONS - 16A<br />
90° PLUG<br />
PLUG - 32A<br />
PLUG - 16A<br />
Ø 44<br />
Ø 7<br />
31<br />
30<br />
143<br />
114<br />
Ø 44<br />
Ø 53<br />
Ø 53<br />
31<br />
30<br />
10<br />
(Dimensions in mm)
CONNECTOR - 16A<br />
Ø 7<br />
46<br />
31<br />
CONNECTOR - 32A<br />
46<br />
Ø 44<br />
31<br />
119<br />
148<br />
Ø 53<br />
Ø 44<br />
Ø 53<br />
<strong>LIBERA</strong> <strong>Series</strong><br />
FLUSH MOUNTING SOCKET - 16A-32A<br />
56<br />
87<br />
18˚<br />
70<br />
73<br />
34<br />
43<br />
70<br />
65<br />
APPLIANCE INLET - 16A-32A<br />
(Dimensions in mm)<br />
11
ZP00509-GB-5<br />
<strong>Scame</strong>’s technological partners<br />
in this project:<br />
www.in-presa.com<br />
info@tagitalia.com<br />
<strong>Scame</strong>OnLine<br />
www.scame.com<br />
export@scame.com<br />
GENERALE SISTEMI SRL<br />
VIA FRA I CAMPI, 13/C<br />
59012 GALCIANA - PRATO - ITALY<br />
TEL. +39 0574 816434<br />
FAX +39 0574 815476<br />
SCAME PARRE S.p.A.<br />
VIA COSTA ERTA, 15<br />
24020 PARRE (BG) ITALY<br />
TEL. +39 035 705000<br />
FAX +39 035 703122