TENNANT 7100 SCRUBBER DRYER OPERATOR MANUAL - Clemas

More documents

Recommendations

Info

OPERATION FILLING THE TANKS 1. Turn the machine power on. See the STARTING THE MACHINE section of the manual. FOR SAFETY: When starting machine, keep foot on brake and directional pedal in neutral. 2. Drive the machine to the tank filling site. 3. Turn the machine power off. See the STOP THE MACHINE section of the manual. 4. Set the machine parking brake. FOR SAFETY: Before leaving or servicing machine, stop on level surface, set parking brake, turn off machine, and remove key. <strong>7100</strong> 330699 (12 -00) 25
OPERATION 5. CONVENTIONAL SCRUBBING: Open the solution tank cover. Measure and pour in the correct amount of detergent. Fill the rest of the solution tank with water up to the FULL line near the top of the tank. NOTE: Floor conditions, water condition, amount of soilage, type of soilage, and brush pressure all play an important role in determining the type and concentration of detergent used. For specific recommendations, contact your Tennant representative. WARNING: Flammable materials can cause an explosion or fire. Do not use flammable materials in tank(s). FOR SAFETY: When using machine, follow mixing and handling instructions on chemical containers. 6. ESt (option): Fill the recovery tank with water and detergent up to the lower sensor float to extend scrub time. Make sure the ESt system is on. WARNING: Flammable materials can cause an explosion or fire. Do not use flammable materials in tank(s). FOR SAFETY: When using machine, follow mixing and handling instructions on chemical containers. NOTE: If you DO NOT want to use the ESt mode (option), DO NOT put water in the recovery tank and make sure the ESt system is off. 7. FaSTt SCRUBBING (option): Open the solution tank cover and fill the solution tank to the FULL line near the top of the tank with cool clear water only. Do not add cleaning detergents. NOTE: When cleaning using FaSTt option, USE CLEAR COOL WATER ONLY. DO NOT add cleaning detergents in solution tank. Conventional cleaning detergents/restorers may cause failure to the FaSTt solution system. 8. Lower the tank cover. 26 <strong>7100</strong> 330699 (3 -04)
Page 1 and 2: TENNANT 7100 SCRUBBER DRYER OPERATO
Page 3 and 4: SAFETY PRECAUTIONS The safety label
Page 5 and 6: OPERATION MACHINE COMPONENTS M L A
Page 7 and 8: OPERATION CONTROLS AND INSTRUMENTS
Page 9 and 10: OPERATION Forward: Press the top of
Page 11 and 12: OPERATION OPERATING LIGHTS SWITCH T
Page 13 and 14: OPERATION REAR SQUEEGEE SWITCH The
Page 15 and 16: OPERATION BATTERY DISCHARGE INDICAT
Page 17 and 18: OPERATION SOLUTION FLOW LEVER The s
Page 19 and 20: OPERATION HOW THE MACHINE WORKS The
Page 21 and 22: OPERATION PRE-OPERATION CHECKLIST C
Page 23: OPERATION 4. Make sure to connect t
Page 27 and 28: OPERATION Heavy duty stripping pad
Page 29 and 30: OPERATION SCRUBBING 1. Start the ma
Page 31 and 32: OPERATION STOP SCRUBBING 1. Press t
Page 33 and 34: OPERATION 5. Access the recovery ta
Page 35 and 36: OPERATION 12.ESt mode (option): Whe
Page 37 and 38: OPERATION STOP THE MACHINE 1. Stop
Page 39 and 40: OPERATION OPTIONS POWER WAND The po
Page 41 and 42: OPERATION 9. Press the squeegee swi
Page 43 and 44: OPERATION 16. Disconnect the soluti
Page 45 and 46: OPERATION 6. Lock the battery cart
Page 47 and 48: OPERATION 14.Release the battery ca
Page 49 and 50: OPERATION 5. Pull the release lever
Page 51 and 52: OPERATION Problem Cause Remedy FaST
Page 53 and 54: MAINTENANCE MAINTENANCE CHART NOTE:
Page 55 and 56: MAINTENANCE SCRUB HEAD LIFT BEARING
Page 57 and 58: MAINTENANCE CHARGING THE BATTERIES
Page 59 and 60: MAINTENANCE 3. The machine systems
Page 61 and 62: MAINTENANCE REPLACING THE DISK BRUS
Page 63 and 64: MAINTENANCE 11. Place the new scrub
Page 65 and 66: MAINTENANCE 5. Observe the shape of
Page 67 and 68: MAINTENANCE REPLACING THE CYLINDRIC
Page 69 and 70: MAINTENANCE The vacuum fan inlet fi
Page 71 and 72: MAINTENANCE REAR SQUEEGEE ASSEMBLY
Page 73 and 74: MAINTENANCE ADJUSTING REAR SQUEEGEE
Page 75 and 76:
MAINTENANCE 4. Pull off the retaini
Page 77 and 78:
MAINTENANCE SIDE SQUEEGEE BLADES Th
Page 79 and 80:
MAINTENANCE SKIRTS AND SEALS SCRUB
Page 81 and 82:
MAINTENANCE BRAKES AND TIRES BRAKES
Page 83 and 84:
MAINTENANCE PUSHING, TOWING, AND TR
Page 85 and 86:
MAINTENANCE MACHINE JACKING You can
Page 87 and 88:
SPECIFICATIONS SPECIFICATIONS GENER
Page 89:
SPECIFICATIONS (700 mm scrub) 850 m
show all

TENNANT 7100 SCRUBBER DRYER OPERATOR MANUAL - Clemas

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?