JM Aerofoil - Angus Air

• Eleven sizes are offered from 315mm to1000mm diameter• Volume flows of up to 20m 3 /s• Static pressures up to 800 Pa• High energy efficiency• Low installed noise levels• Motor protection IP55• All casings are hot dipped galvanised• Overheat protection is fitted as standard• Inverter controllableJM AerofoilCased FansSizes31JM - (315mm) to 100JM - (1000mm).Larger sizes up to 2500mm diameter are also a vailable. Please enquire.Electrical Supply220 - 240V / 50Hz / 1 φ380 - 420V / 50Hz / 3 φFan PerformanceAll fans are tested to the latest inter nationally recognised standard IS05801 Part 1 (1997),installation category D (AMCA approved) for aerodynamic performance and BS848 Part 2(1985) for acoustic performance. Coupled with a wide range of fan diameters, the adjustablepitch Aerofoil impeller gives the exact performance required, with a non overloading fancharacteristic.ImpellersA unique high efficiency aerofoil section blade with a purposely smoothed hub and clampplate for adjustable pitch angle availability.The Fläkt Woods impellers are all high pressure die cast to off er thin aerofoil sections for lowgeneration of noise. Every cast aluminium component is X-r ay examined using Real TimeRadiography inspection prior to assembly. The maximum pitch angles shown allow for speedcontrol by frequency inverter (3ph only).MotorsAll motors are totally enclosed air stream r ated class F insulation. Constructed from aluminiumor cast iron as standard with special ‘T’ slot or pad mounted fixings. Single speed motors aresuitable for speed control by voltage regulation where indicated. Three phase motors aresuitable for use with frequency inverters. Two speed motors where available are pole changetype. Suitable for horizontal through to vertical shaft operation. Supplied IP55, with removabledrain plugs.Sealed for life bearings lubricated with wide temperature range grease. The BT, CT and F22are all fitted with overheat protection thermostat as standard. D motors are fitted withThermistor OHP. These motors are suitable for inverter speed control down to 20% of fullspeed.Temperature Range-40°C to 50°C as standard. (All motors are not suitable forstarting at temperatures lower than -20°C.) Fans that includeBT or CT motors can be contin uously operated at temperaturesup to 70°C. When these fans are operating in excess of 50°C theyshould be run at full speed only. Other fans can be operated up to70°C with appropriate deration of motors.Most standard 3φ fans can be offered for a one off emergency oper ation at200˚C for 2 hours.CasingsJM Aerofoil fans are available in either a long cased f orm, complete with an externallymounted pre-wired electrical terminal box, or short cased for duct or plate installation. Casingsare spun from sheet steel with integ ral pre-drilled and radiused inlet flanges. The galvanisedfinish gives a high resistance to corrosion and is ideal f or external as well as internal use.AccessoriesSilencers, Mounting feet, Vibration isolators, Matching flanges, Flexible connectors, Airoperated non return dampers, Guards, Bell mouth inlets. Electronic and transformer typespeed controllers and frequency inverters. For a full range please see pages 58-61.Application GuideTelephone:01206 222 555CASEDFax:01206 222 905Email:fans.uk@flaktwoods.comExpress Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselector9

CASED 10Performance DataTelephone:01206 222 555Fax:01206 222 9051 Phase 3 Phase1 - 31JM/16/4/5/40 3 - 31JM/16/2/5/282 - 35JM/16/4/5/40 4 - 35JM/16/2/5/34Email:fans.uk@flaktwoods.com5 - 31JM/16/4/5/40 7 - 31JM/16/2/5/34 9 - 35JM/16/2/5/406 - 35JM/16/4/5/40 8 - 35JM/16/2/5/32Express Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselectorJM Aerofoil fan31JM - 35JM48 937Sound pressure levels quoted are average dBA at 3m distance over a sphere, under freefield conditions and are presented for comparative purposes only .1256Fans that include BT or CT motors can be continuously operated at temperatures upto 70°C. When these fans are operating in excess of 50°C they should be run at fullspeed only.For Short cased fans please omit the prefix from the product number and state S-type onenquiries/orders. Product numbers shown are for Long cased fans.Bold text denotes Super Expr ess Product, next day deliver y available if or deredby 4pm.Electrical DataRefProductCodeSpeedrev/minMotorProductNumberPitchAngle(°)MotorRating(kW)Full LoadCurrent(at 230V)(A)220-240V/50Hz/1φStartingCurrent(at 230V)(A)WiringDiagramRefSpeed ControllerElectronicTransformer1 31JM/16/4/5/... 1420 BT4 DX321460 40 0.095 0.5 1.5 CD1705 ME1.1 N/A 44 0.62 0.51SoundLeveldBAm 3 /s at Pa (Static)0 50 100 150 200 250 300 4003 31JM/16/2/5/... 2840 BT9 DX321202 24-28 0.48 3.1 6.7 CD1705 N/A N/A 61 1.02 0.97 0.92 0.86 0.82 0.72 0.70 0.512 35JM/16/4/5/... 1420 BT4 DX361460 40 0.13 1.0 1.8 CD1705 ME1.1 MT1.5 49 1.01 0.86 0.644 35JM/16/2/5/... 2840 CT9 JL361205 32-34 1 6.8 21 CD1705 N/A N/A 64 1.80 1.75 1.68 1.61 1.55 1.46 1.38 1.16RefProductCodeSpeedrev/minMotorProductNumberPitchAngle(°)MotorRating(kW)Full LoadCurrent(at 400V)(A)380-420V/50Hz/3φStartingCurrent(at 400V)(A)WiringDiagramRefSpeed ControllerTransformer5 31JM/16/4/5/... 1420 BT4 DX341460 40 0.13 0.50 1.1 CD1344 MT3.1 FWX1 44 0.68 0.55InverterSoundLeveldBAm 3 /s at Pa (Static)0 50 100 150 200 250 300 4007 31JM/16/2/5/... 2840 BT9 DX341202 34 0.58 1.5 5.7 CD1344 N/A FWX1 61 1.20 1.14 1.09 1.03 0.97 0.90 0.826 35JM/16/4/5/... 1420 BT5 DX381460 40 0.18 0.6 1.9 CD1344 MT3.1 FWX1 49 1.02 0.87 0.648 35JM/16/2/5/... 2840 CT5 DX381210 8-32 0.95 2.5 8 CD1344 N/A FWX1 64 1.72 1.67 1.61 1.54 1.47 1.40 1.32 1.119 35JM/16/2/5/... 2840 CT9 JL381204 8-40 1.6 3.8 17.5 CD1344 N/A FWX2 66 2.03 1.96 1.89 1.82 1.74 1.64 1.54 1.28Wiring diagrams can be found on pages 22-23The fan noise levels shown are for the specified operating point. When an electronic controller is incorporated, a magnetic not e (enhanced motor noise) can occur - par ticularly if the fan is operating at speeds well below maximum.For noise sensitive applications FWL recommend using an auto transformer speed controller . Fans are supplied at catalogue stat ed angle. Should you wish for the pitch angle to be adjusted, we would be happy to of fer a quotation

Dimensions - 31 JM Aer ofoilJM – Cylindrical SilencersBore Dia.mm (D)LengthAcoustic Performance (dB) – Octave Band Mid Fr equency – Hz63 125 250 500 1K 2K 4K 8K315 - B 1D 1 2 4 9 11 10 9 7355 - B 1D 1 2 4 10 12 10 9 7315 - C 1D 2 5 5 9 18 20 18 15355 - C 1D 2 5 6 9 18 22 19 16Size Frame C K315Weight kgFanBT4/5 330 245 21BT9 375 289 22CT5 330 245 23CT9 375 289 27Suitablefor fanOAInverter*ProductNumbersB C JWeight (kg)B TypeC Type315 SB211401 415 315 M8 10 13355 SB221401 455 355 M8 12 15* For C type silencer change prefix from SB to SCDimensions - 35 JM Aer ofoilTypeProductNumberA B CWeight(kg)FWX1 430412 420 242 195 14.2FWX2 430413 420 242 195 14.2Electronic ControllerTypeProductNumberA B C DME1.1 DA410290 104 83 55 40Transformer ControllerSize Frame C K355Weight kgFanBT4/5 330 245 22BT9 375 289 23CT5 330 245 24CT9 375 289 28TypeNumberProductA B C D EMax.Weight(kg)MT1.5 423099 255 170 140 155 194 5.5MT3.1 402011 255 170 140 155 194 7.7All dimensions shown in mm.Telephone:01206 222 555CASEDFax:01206 222 905Email:fans.uk@flaktwoods.comExpress Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselector11

CASED 12Performance DataTelephone:01206 222 555Fax:01206 222 9051 Phase 3 Phase1 - 40JM/16/4/5/40 3 - 45JM/16/4/5/40 5 - 45JM/16/2/5/142 - 45JM/16/4/5/30 4 - 40JM/16/2/5/22Email:fans.uk@flaktwoods.com6 - 40JM/16/4/5/40 8 - 45JM/16/4/5/40 10 - 45JM/16/2/5/207 - 45JM/16/4/5/34 9 - 40JM/16/2/5/32 11 - 45JM/20/2/6/34Express Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselectorJM Aerofoil fan40JM - 45JM5111049Sound pressure levels quoted are average dBA at 3m distance over a sphere, under freefield conditions and are presented for comparative purposes only .12 3678Fans that include BT or CT motors can be continuously operated at temperatures upto 70°C. When these fans are operating in excess of 50°C they should be run at fullspeed only.For Short cased fans please omit the prefix from the product number and state S-type onenquiries/orders. Product numbers shown are for Long cased fans.Bold text denotes Super Expr ess Product, next day deliver y available if or deredby 4pm.Electrical DataRefProductCodeSpeedrev/minMotorProductNumberPitchAngle(°)MotorRating(kW)220-240V/50Hz/1φFull LoadCurrent(at 230V)(A)StartingCurrent(at 230V)(A)WiringDiagramRefSpeed ControllerElectronicTransformer1 40JM/16/4/5/… 1420 BT9 DX411452 40 0.32 2.2 5 CD1705 ME1.3 MT1.5 52 1.50 1.31 1.07SoundLeveldBAm 3 /s at Pa (Static)0 50 100 150 200 250 300 400 500 6004 40JM/16/2/5/… 2840 CT9 JL411203 18-22 1 6.8 21 CD1705 N/A N/A 66 1.92 1.87 1.81 1.75 1.69 1.61 1.54 1.35 1.102 45JM/16/4/5/… 1420 BT9 JL461452 24-30 0.32 2.2 5 CD1705 ME1.3 MT1.5 52 1.82 1.62 1.41 1.133 45JM/16/4/5/… 1420 CT5 DX461466 40 0.39 2.9 5.6 CD1705 ME1.3 MT1.5 56 2.19 1.96 1.675 45JM/16/2/5/… 2840 CT9 JL461201 10-14 1 6.8 21 CD1705 N/A N/A 66 2.13 2.05 1.99 1.91 1.84 1.77 1.68 1.50 1.29 1.01RefProductCodeSpeedrev/minMotorProductNumberPitchAngle(°)MotorRating(kW)380-420V/50Hz/3φFull LoadCurrent(at 400V)(A)StartingCurrent(at 400V)(A)WiringDiagramRefSpeed ControllerTransformer6 40JM/16/4/5/… 1420 BT9 DX431452 40 0.29 1 3 CD1559 MT3.1 FWX1 52 1.50 1.32 1.07InverterSoundLeveldBAm 3 /s at Pa (Static)0 50 100 150 200 250 300 400 500 6009 40JM/16/2/5/… 2840 CT9 DX431203 8-32 1.6 3.8 17.5 CD1344 N/A FWX2 66 2.59 2.51 2.43 2.35 2.26 2.17 2.08 1.86 1.617 45JM/16/4/5/… 1420 BT9 JL481452 8-34 0.39 1.3 3.9 CD1559 N/A FWX1 52 1.99 1.77 1.51 1.228 45JM/16/4/5/… 1420 CT5 DX481460 40 0.53 1.8 4.9 CD1559 MT3.2 FWX1 56 2.20 1.96 1.6810 45JM/16/2/5/… 2840 CT9 JL481202 8-20 1.6 3.8 17.5 CD1344 N/A FWX2 66 2.71 2.64 2.56 2.48 2.40 2.32 2.23 2.04 1.8111 45JM/20/2/6/… 2840 F22 EX481205 8-34 3.8 7.2 64 CD1343 N/A FWX4 72 3.88 3.80 3.72 3.63 3.55 3.46 3.37 3.18 2.96 2.71Wiring diagrams can be found on pages 22-23The fan noise levels shown are for the specified operating point. When an electronic controller is incorporated, a magnetic not e (enhanced motor noise) can occur - par ticularly if the fan is operating at speeds well below maximum.For noise sensitive applications FWL recommend using an auto transformer speed controller . Fans are supplied at catalogue stat ed angle. Should you wish for the pitch angle to be adjusted, we would be happy to of fer a quotation

Dimensions - 40 JM Aer ofoilJM – Cylindrical SilencersBore Dia.mm (D)LengthAcoustic Performance (dB) – Octave Band Mid Fr equency – Hz63 125 250 500 1K 2K 4K 8K400 - B 1D 2 3 5 10 13 11 9 8450 - B 1D 2 3 6 12 13 11 10 6400 - C 1D 2 6 6 10 19 24 20 17450 - C 1D 2 4 7 13 20 23 22 17Size Frame C K400Weight kgFanBT4/5 330 245 24BT9 375 289 25CT5 330 245 26CT9 375 289 30Suitablefor fanOAInverter*ProductNumbersB C JWeight (kg)BTypeCType400 SB241401 500 400 M10 15 18450 SB251401 600 450 M10 20 24* For C type silencer changeprefix from SB to SCDimensions - 45 JM Aer ofoilTypeProductNumberA B CWeight(kg)FWX1 430412 420 242 195 14.2FWX2 430413 420 242 195 14.2FWX4 430415 420 242 195 14.2Speed ControllerTypeProductNumberA B C DME1.3 DA410290 148 87 62 47Size Frame C K450Weight kgFanBT4/5 330 245 25BT9 375 289 28CT5 330 245 28Size Frame C K450Weight kgFanCT9 375 289 32F22/CM29 520 434 50112 520 434 57Transformer ControllerTypeNumberProductA B C D EMax.Weight(kg)MT1.5 423099 255 170 140 155 194 5.5MT3.1 402011 255 170 140 155 194 7.7MT3.2 402012 325 300 175 255 255 12.8All dimensions shown in mm.Telephone:01206 222 555CASEDFax:01206 222 905Email:fans.uk@flaktwoods.comExpress Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselector13

Performance DataCASED 14Telephone:01206 222 555Fax:01206 222 9051 Phase 3 Phase1 - 50JM/20/4/6/20 3 - 50JM/20/4/6/322 - 50JM/16/4/5/28 4 - 50JM/16/4/5/38Email:fans.uk@flaktwoods.com5 - 50JM/20/4/6/20 7 - 50JM/20/4/6/28 9 - 50JM/16/4/5/40 11 - 50JM/20/2/6/346 - 50JM/16/4/5/30 8 - 50JM/20/4/6/38 10 - 50JM/20/2/6/24Express Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselectorJM Aerofoil fan50JMSound pressure levels quoted are average dBA at 3m distance over a sphere, under freefield conditions and are presented for comparative purposes only .Fans that include BT or CT motors can be continuously operated at temperatures upto 70°C. When these fans are operating in excess of 50°C they should be run at fullspeed only.For Short cased fans please omit the prefix from the product number and state S-type onenquiries/orders. Product numbers shown are for Long cased fans.Electrical DataBold text denotes Super Expr ess Product, next day deliver y available if or deredby 4pm.RefProductCodeSpeedrev/minMotorProductNumberPitchAngle(°)MotorRating(kW)220-240V/50Hz/1φFull LoadCurrent(at 230V)(A)StartingCurrent(at 230V)(A)WiringDiagramRefSpeed ControllerElectronicTransformerSoundLeveldBAm 3 /s at Pa (Static)0 50 100 150 2002 50JM/16/4/5/… 1420 CT5 DX511464 24-28 0.52 3.9 7.8 CD1705 ME1.6 MT1.5 57 2.42 2.19 1.95 1.664 50JM/16/4/5/… 1420 CT9 JL511460 32-38 0.68 4.8 11 CD1705 ME1.6 MT1.5 59 2.93 2.66 2.36 1.991 50JM/20/4/6/… 1420 BT9 DX511455 16-20 0.32 2.2 5 CD1705 ME1.3 MT1.5 53 1.84 1.68 1.52 1.303 50JM/20/4/6/… 1420 CT5 DX511466 32 0.52 3.9 7.8 CD1705 ME1.6 MT1.5 56 2.61 2.42 2.20 1.94 1.62RefProductCodeSpeedrev/minMotorProductNumberPitchAngle(°)MotorRating(kW)380-420V/50Hz/3φFull LoadCurrent(at 400V)(A)StartingCurrent(at 400V)(A)WiringDiagramRefSpeed ControllerTransformer6 50JM/16/4/5/… 1420 CT5 DX531460 30 0.54 1.8 4.9 CD1559 MT3.2 FWX1 57 2.54 2.30 2.04 1.759 50JM/16/4/5/… 1420 CT9 JL531454 34-40 0.83 2.3 8.6 CD1559 MT3.7 FWX1 59 3.02 2.75 2.435 50JM/20/4/6/… 1420 BT9 JL531456 8-20 0.39 1.3 3.9 CD1559 N/A FWX1 53 1.84 1.68 1.52 1.307 50JM/20/4/6/… 1420 CT5 DX531462 28 0.54 1.8 4.8 CD1559 MT3.2 FWX1 56 2.37 2.19 1.98 1.75 1.428 50JM/20/4/6/… 1420 CT9 JL531458 32-38 0.83 2.3 8.6 CD1559 MT3.7 FWX1 58 2.88 2.69 2.45 2.16InverterSoundLeveldBAm 3 /s at Pa (Static)0 50 100 150 200 250 300 400 500 60010 50JM/20/2/6/… 2840 F22 EX531203 8-24 3.8 7.2 64 CD1343 N/A FWX4 70 4.32 4.23 4.16 4.08 4.00 3.91 3.83 3.65 3.43 3.2011 50JM/20/2/6/… 2840 112 DX531204 8-34 6.2 11.4 77.5 CD1343 N/A FWX6 74 5.56 5.46 5.37 5.27 5.16 5.05 4.96 4.73 4.49 4.23Wiring diagrams can be found on pages 22-23The fan noise levels shown are for the specified operating point. When an electronic controller is incorporated, a magnetic not e (enhanced motor noise) can occur - par ticularly if the fan is operating at speeds well below maximum.For noise sensitive applications FWL recommend using an auto transformer speed controller . Fans are supplied at catalogue stat ed angle. Should you wish for the pitch angle to be adjusted, we would be happy to of fer a quotation

Dimensions - 50 JM Aer ofoilSize Frame C KWeight kgFanBT5 330 235 27BT9 375 289 28500CT5 330 235 30CT5/9 375 289 34F22/CM29 520 434 60112 520 434 67JM – Cylindrical SilencersTransformer ControllerInverterSpeed ControllerBoreDia.mm (D)LengthAcoustic Performance (dB) – Octave Band Mid Fr equency – Hz63 125 250 500 1K 2K 4K 8KTypeNumberProductA B C D EMax.Weight(kg)TypeProductNumberA B CWeight(kg)FWX1 430412 420 242 195 14.2TypeProductNumberA B C DME1.3 DA410290 148 87 62 47500 - B 1D 2 3 6 13 14 10 10 5500 - C 1D 2 3 8 16 21 22 21 17MT1.5 423099 255 170 140 155 194 5.5MT3.2 402012 325 300 175 255 255 12.8FWX4 430415 420 242 195 14.2FWX6 430417 420 242 195 14.2ME1.6 DA410291 148 87 62 47MT3.7 402013 425 300 235 255 355 26Suitablefor fanOAProductNumbersB C JWeight (kg)BTypeCType500 SB271401 650 500 M10 25 29* For C type silencer change prefix from SB to SCAll dimensions shown in mm.Telephone:01206 222 555CASEDFax:01206 222 905Email:fans.uk@flaktwoods.comExpress Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselector15

Performance DataCASED 16Telephone:01206 222 555Fax:01206 222 9051 Phase 3 Phase1 - 63JM/20/6/6/22 3 - 56JM/16/4/5/20 5 - 56JM/20/4/6/282 - 63JM/20/6/6/30 4 - 63JM/20/4/6/16 6 - 56JM/16/4/5/32Email:fans.uk@flaktwoods.com7 - 63JM/20/6/6/30 9 - 56JM/16/4/5/28 11 - 63JM/20/4/6/20 13 - 56JM/20/2/6/248 - 56JM/16/4/5/24 10 - 56JM/20/4/6/32 12 - 63JM/20/4/6/32Express Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselectorJM Aerofoil fan56-63JMElectrical DataSound pressure levels quoted are average dBA at 3m distance over a sphere, under freefield conditions and are presented for comparative purposes only .Fans that include BT or CT motors can be continuously operated at temperatures upto 70°C. When these fans are operating in excess of 50°C they should be run at fullspeed only.For Short cased fans please omit the prefix from the product number and state S-type onenquiries/orders. Product numbers shown are for Long cased fans.Bold text denotes Super Expr ess Product, next day deliver y available if or deredby 4pm.RefProductCodeSpeedrev/minMotorProductNumberPitchAngle(°)MotorRating(kW)220-240V/50Hz/1φFull LoadCurrent(at 230V)(A)StartingCurrent(at 230V)(A)WiringDiagramRefElectronicSpeed ControllerTransformerSoundLeveldBAm 3 /s at Pa (Static)0 50 100 150 200 250 3003 56JM/16/4/5/… 1420 CT5 JL571453 18-20 0.52 3.9 7.8 CD1705 ME1.6 MT1.5 57 2.74 2.50 2.24 1.93 1.466 56JM/16/4/5/… 1420 CT9 DX571456 32 0.97 6.7 13.5 CD1705 ME1.6 MT1.8 58 3.76 3.46 3.15 2.81 2.385 56JM/20/4/6/... 1420 CT9 DX571459 28 0.97 6.7 13.5 CD1705 ME1.6 MT1.8 58 3.47 3.25 3.01 2.74 2.431 63JM/20/6/6/... 900 CT5 JL641651 16-22 0.29 2.3 4.1 CD1705 ME1.3 MT1.5 49 2.57 2.23 1.782 63JM/20/6/6/... 900 CT9 JL641652 26-30 0.53 0.38 6.8 CD1705 ME1.6 MT1.8 52 3.25 2.85 2.324 63JM/20/4/6/… 1420 CT9 DX641453 16 0.97 6.7 13.5 CD1705 ME1.6 MT1.8 61 3.12 2.98 2.80 2.58 2.30 1.95 1.38Wiring diagrams can be found onpages 22-23RefProductCodeSpeedrev/minMotorProductNumberPitchAngle(°)MotorRating(kW)380-420V/50Hz/3φFull LoadCurrent(at 400V)(A)StartingCurrent(at 400V)(A)WiringDiagramRefSpeed ControllerTransformer8 56JM/16/4/5/… 1420 CT5 JL591452 16-24 0.54 1.8 4.9 CD1343 MT3.2 FWX1 57 3.09 2.83 2.56 2.27 1.859 56JM/16/4/5/… 1420 CT9 DX591453 28 0.83 2.3 8.6 CD1343 MT3.7 FWX1 58 3.44 3.16 2.88 2.55 2.1210 56JM/20/4/6/… 1420 CT9 DX591458 32 1.15 3.2 11 CD1343 MT3.7 FWX2 61 3.80 3.57 3.31 3.03 2.70InverterSoundLeveldBAm 3 /s at Pa (Static)0 50 100 150 200 250 300 400 500 60013 56JM/20/2/6/… 2910 112 EX591201 8-24 6.2 11.4 77.5 CD1343 N/A FWX6 73 6.33 6.25 6.16 6.05 5.98 5.85 5.77 5.53 5.30 5.037 63JM/20/6/6/… 900 CT9 JL661652 26-30 0.5 1.5 4.5 CD1559 MT3.2 FWX1 50 3.24 2.86 2.3311 63JM/20/4/6/… 1420 CT9 DX661453 20 1.15 3.2 11 CD1559 MT3.7 FWX2 61 3.77 3.57 3.37 3.14 2.89 2.5512 63JM/20/4/6/… 1420 F22 DX661454 32 2.1 5 27 CD1343 MT3.7 FWX2 61 5.40 5.12 4.87 4.56 4.23 3.83The fan noise levels shown are for the specified operating point. When an electronic controller is incorporated, a magnetic not e (enhanced motor noise) can occur - par ticularly if the fan is operating at speeds well below maximum.For noise sensitive applications FWL recommend using an auto transformer speed controller . Fans are supplied at catalogue stat ed angle. Should you wish for the pitch angle to be adjusted, we would be happy to of fer a quotation.

Dimensions - 56 JM Aer ofoilJM – Cylindrical SilencersBore Dia.mm (D)LengthAcoustic Performance (dB) – Octave Band Mid Fr equency – Hz63 125 250 500 1K 2K 4K 8K560 - B 1D 2 4 7 14 14 19 10 7560 - B 1D 2 5 7 15 13 8 9 8630 - C 1D 3 5 8 16 20 18 19 15630 - C 1D 3 5 8 15 19 16 14 12Size Frame C K560Weight kgFanBT5/9 375 280 34CT5/9 375 280 38F22/CM29 520 424 62112 520 424 69Suitablefor fanOAInverter*ProductNumbersB C JWeight (kg)BTypeCType560 SB281401 710 560 M10 30 35630 SB301401 780 630 M10 35 42* For C type silencer changeprefix from SB to SCDimensions - 63 JM Aer ofoilTypeProductNumberA B CWeight(kg)FWX1 430412 420 242 195 14.2FWX2 430413 420 242 195 14.2FWX3 430414 420 242 195 14.2FWX6 430346 420 242 195 14.2Speed ControllerTypeProductNumberA B C DME1.3 DA410290 148 87 62 47ME1.6 DA410291 148 87 62 47Size Frame C D K630Weight kgFanBT5/9 375 403 289 48CT5/9 375 403 289 52F22/CM29 520 403 434 76112 520 403 434 83Size Frame C D K630Weight kgFan132 520 440 432 156160 625 440 537 206160 - Teco 711 440 619 232180 711 440 619 293Transformer ControllerTypeNumberProductA B C D EMax.Weight(kg)MT1.5 423099 255 170 140 155 194 5.5MT1.8 402011 325 300 185 255 255 8MT3.2 402012 325 300 175 255 255 12.8MT3.7 402013 425 300 235 255 355 26All dimensions shown in mm.Telephone:01206 222 555CASEDFax:01206 222 905Email:fans.uk@flaktwoods.comExpress Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselector17

CASED 18Performance Data71JMTelephone:01206 222 5551 - 71JM/20/6/6/18 3 - 71JM/20/4/6/22 5 - 71JM/20/4/6/362 - 71JM/20/6/6/36 4 - 71JM/20/4/6/24Fax:01206 222 90580JM6 - 80JM/20/6/6/26 8 - 80JM/25/4/9/227 - 80JM/20/6/6/36 9 - 80JM/25/4/9/28Email:fans.uk@flaktwoods.comExpress Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselectorJM Aerofoil fan71-80JMElectrical DataSound pressure levels quoted are average dBA at 3m distance over a sphere, under freefield conditions and are presented for comparative purposes only .Fans that include BT or CT motors can be continuously operated at temperatures upto 70°C. When these fans are operating in excess of 50°C they should be run at fullspeed only.For Short cased fans please omit the prefix from the product number and state S-type onenquiries/orders. Product numbers shown are for Long cased fans.Bold text denotes Super Expr ess Product, next day deliver y available if or deredby 4pm.380-420V/50Hz/3φm 3 /s at Pa (Static)RefProductCodeSpeedrev/minMotorProductNumberPitchAngle(°)MotorRating(kW)Full LoadCurrent(at 400V)(A)StartingCurrent(at 400V)(A)WiringDiagramRefSpeed ControllerTransformerInverterSoundLeveldBA0 50 100 150 200 250 300 4001 71JM/20/6/6/… 900 CT9 JL741652 16-18 0.5 1.5 4.5 CD1559 MT3.2 FWX1 53 3.29 2.97 2.542 71JM/20/6/6/… 900 F22 EX741653 24-36 1.35 3.4 15 CD1559 MT3.7 FWX2 55 5.47 4.89 4.233 71JM/20/4/6/... 1440 F22 JL741451 14-22 2.1 5.0 27 CD1559 MT3.7 FWX3 65 6.10 5.85 5.64 5.39 5.16 4.86 4.564 71JM/20/4/6/… 1440 F22 EX741401 8-24 2.7 5.8 30 CD1343 N/A FWX3 65 6.49 6.24 6.00 5.76 5.51 5.25 4.925 71JM/20/4/6/… 1440 112 DX741404 36 4.4 8.4 57.2 CD1343 N/A FWX5 68 8.75 8.41 8.03 7.66 7.24 6.81 6.346 80JM/20/6/6/… 935 F22 EX831651 24-26 1.35 3.4 15 CD1559 MT3.7 FWX2 58 6.48 5.83 5.20 4.487 80JM/20/6/6/… 935 F22 JL831652 8-36 2.5 6.4 26 CD1559 N/A FWX3 69 9.43 9.05 8.68 8.27 7.86 7.46 7.018 80JM/25/4/9/… 1440 112 EX831405 8-22 4.4 8.4 57.2 CD1343 N/A FWX5 71 8.42 8.16 7.91 7.62 7.38 7.05 6.75 5.989 80JM/25/4/9/… 1440 132S EX831408 28 6.6 12.6 84.4 CD1343 N/A FWX6 71 10.07 9.84 9.54 9.24 8.93 8.61 8.21 7.35Wiring diagrams can be found on pages 22-23The fan noise levels shown are for the specified operating point. When an electronic controller is incorporated, a magnetic not e (enhanced motor noise) can occur - par ticularly if the fan is operating at speeds well below maximum.For noise sensitive applications FWL recommend using an auto transformer speed controller . Fans are supplied at catalogue stat ed angle. Should you wish for the pitch angle to be adjusted, we would be happy to of fer a quotation

Dimensions - 71 JM Aer ofoilJM – Cylindrical SilencersBore Dia.mm (D)LengthAcoustic Performance (dB) – Octave Band Mid Fr equency – Hz63 125 250 500 1K 2K 4K 8K710 - B 1D 3 5 7 15 13 9 9 8710 - C 1D 3 5 8 15 19 15 14 12800 - B 1D 3 5 8 16 12 9 9 8800 - C 1D 4 5 8 16 19 15 14 13Size Frame C K710Weight kgFanCT5/9 375 259 54F22/CM29 520 404 80112 520 404 87132 520 434 147Size Frame C K710Weight kgFan132 520 434 147160M 625 539 223160L 711 625 245Suitablefor fanOA*ProductNumbersB C JWeight (kg)B Type C Type710 SB311401 860 710 M10 44 53800 SB331401 1000 800 M10 55 66* For C type silencer changeprefix from SB to SCDimensions - 80 JM Aer ofoilInverterTypeProductNumberA B CWeight(kg)FWX1 430412 420 242 195 14.2FWX2 430413 420 242 195 14.2FWX3 430414 420 242 195 14.2FWX5 430416 420 242 195 14.2FWX6 430417 420 242 195 14.2Size Frame C D J K800Weight kgFanCT5/9 375 488 10 259 63F22/CM29 520 488 10 404 90112 520 488 10 404 96132 520 480 12 434 166Size Frame C D J K800Weight kgFan160M 625 480 12 505 230160L 711 480 12 589 261180L 711 480 12 589 320Transformer ControllerTypeNumberProductA B C D EMax.Weight(kg)MT3.2 402012 325 300 175 255 255 12.8MT3.7 402013 425 300 235 255 355 26All dimensions shown in mm.Telephone:01206 222 555CASEDFax:01206 222 905Email:fans.uk@flaktwoods.comExpress Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselector19

CASED 20Performance Data90JMTelephone:01206 222 5551 - 90JM/25/8/9/32 3 - 90JM/25/6/9/24 5 - 90JM/25/4/9/322 - 90JM/25/6/6/32 4 - 90JM/25/4/9/24Fax:01206 222 905100JMEmail:fans.uk@flaktwoods.com6 - 100JM/25/8/9/22 8 - 100JM/25/4/6/22 10 - 100JM/25/4/9/287 - 100JM/25/6/6/18 9 - 100JM/25/4/9/22Express Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselectorJM Aerofoil fan90-100JMElectrical DataSound pressure levels quoted are average dBA at 3m distance over a sphere, under freefield conditions and are presented for comparative purposes only .Fans that include BT or CT motors can be continuously operated at temperatures upto 70°C. When these fans are operating in excess of 50°C they should be run at fullspeed only.For Short cased fans please omit the prefix from the product number and state S-type onenquiries/orders. Product numbers shown are for Long cased fans.Bold text denotes Super Expr ess Product, next day deliver y available if or deredby 4pm.RefProductCodeSpeedrev/minMotorProductNumberPitchAngle(°)PitchAngle200°C(°)MotorRating(kW)380-420V/50Hz/3φFull LoadCurrent(at 400V)(A)StartingCurrent(at 400V)(A)WiringDiagramRefSpeed ControllerTransformerInverterSoundLeveldBAm 3 /s at Pa (Static)0 50 100 150 200 250 300 400 5001 90JM/25/8/9/… 695 F22 JL931802 8-32 30 1.4 4.9 18 CD1343 N/A FWX2 58 7.50 6.74 5.912 90JM/25/6/6/… 935 F22 JL933602 8-32 28 2.5 6.4 26 CD1343 N/A FWX3 65 9.83 9.06 8.20 7.203 90JM/25/6/9/… 935 F22 JL931602 8-24 24 2.5 6.4 26 CD1343 N/A FWX3 63 8.58 8.12 7.63 7.14 6.55 5.784 90JM/25/4/9/… 1440 132M EX931403 8-24 20 9 17.0 114 CD1343 N/A FWD7 74 12.40 12.11 11.84 11.53 11.24 10.95 10.64 9.93 9.155 90JM/25/4/9/… 1440 160M EX931406 32 28 13.2 25.4 127 CD1343 N/A FWD8 75 15.53 15.22 14.86 14.46 14.09 13.71 13.33 12.46 11.516 100JM/25/8/9/… 695 F22 JL131802 8-22 22 1.4 4.9 18 CD1343 N/A FWX2 61 8.36 7.39 6.357 100JM/25/6/6/… 950 F22 EX133652 16-18 18 2.1 5.7 24 CD1343 MT3.7 FWX3 68 9.52 8.79 7.93 6.95 5.808 100JM/25/4/6/… 1450 132M EX133402 8-22 18 9 17 114 CD1343 N/A FWD7 79 16.48 15.87 15.35 14.80 14.20 13.59 13.02 11.66 9.989 100JM/25/4/9/… 1470 160M JL131419 8-22 18 13.2 25.4 127 CD1343 N/A FWD8 79 17.70 17.22 16.79 16.31 15.88 15.40 14.94 13.88 12.7210 100JM/25/4/9/… 1470 160L EX131405 28 26 18 34.8 171 CD1343 N/A FWD9 79 20.98 20.53 20.07 19.59 19.10 18.61 18.10 17.00 15.76Wiring diagrams can be found on pages 22-23The fan noise levels shown are for the specified operating point. When an electronic controller is incorporated, a magnetic not e (enhanced motor noise) can occur - par ticularly if the fan is operating at speeds well below maximum.For noise sensitive applications FWL recommend using an auto transformer speed controller . Fans are supplied at catalogue stat ed angle. Should you wish for the pitch angle to be adjusted, we would be happy to of fer a quotation

Dimensions - 90 JM Aer ofoilJM – Cylindrical SilencersBore Dia.mm (D)LengthAcoustic Performance (dB) – Octave Band Mid Fr equency – Hz63 125 250 500 1K 2K 4K 8K900 - B 1D 3 5 10 17 13 11 10 81000 - B 1D 4 5 11 16 11 10 8 9900 - C 1D 4 5 9 17 19 15 14 131000 - C 1D 5 5 11 18 19 15 14 13Size Frame C D J K900Weight kgFanF22/CM29 520 538 10 444 94112 520 538 10 444 101132S/M 520 575 12 440 179Size Frame C D J K900Weight kgFan160M 625 575 12 545 248160L 711 575 12 629 260180L 711 575 12 629 312Suitablefor fanOA*ProductNumbersB C JWeight (kg)B Type C Type900 SB341401 1100 900 M12 70 841000 SB351401 1200 1000 M12 82 100* For C type silencer changeprefix from SB to SCDimensions - 100 JM Aer ofoilInverterTypeProductNumberA B CWeight(kg)FWX2 430413 420 242 195 14.2FWX3 430414 420 242 195 14.2FWD7 416522 480 242 260 23FWD8 416523 480 242 260 23FWD9 416524 480 242 260 23Transformer ControllerSize Frame C D J K1000Weight kgFanF22/CM29 520 588 10 444 102112 520 588 10 444 109132/M 520 625 12 440 200Size Frame C D J K1000Weight kgFan160M 625 625 12 545 260160L 711 625 12 629 295180L 711 625 12 629 348TypeNumberProductA B C D EMax.Weight(kg)MT3.7 402013 425 300 235 255 355 26All dimensions shown in mm.Telephone:01206 222 555CASEDFax:01206 222 905Email:fans.uk@flaktwoods.comExpress Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselector21

CASED 22Telephone:01206 222 555Fax:01206 222 905Email:fans.uk@flaktwoods.comExpress Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselectorWiring DiagramsCD1343JM Aerofoil fanCased FansFanFan + Transformer Speed ControllerCD1344FanFan + Transformer Speed Controller

Wiring DiagramsCD1559FanFan + Transformer Speed ControllerJM Aerofoil fanCased FansCD1705Fan Fan + Electronic Speed Controller Fan + Transformer Speed ControllerTelephone:01206 222 555CASEDFax:01206 222 905Email:fans.uk@flaktwoods.comExpress Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselector23

JM – Cylindrical SilencersCASED 58Telephone:01206 222 555Acoustic Performance B Type (without Pod)Fax:01206 222 905Email:fans.uk@flaktwoods.comExpress Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselectorJM AccessoriesCased FansBore Dia.mm (D)LengthAcoustic Performance (dB) – Octave Band Mid Fr equency – Hz63 125 250 500 1K 2K 4K 8K315 1D 1 2 4 9 11 10 9 7355 1D 1 2 4 10 12 10 9 7400 1D 2 3 5 10 13 11 9 8450 1D 2 3 6 12 13 11 10 6500 1D 2 3 6 13 14 10 10 5560 1D 2 4 7 14 14 19 10 7630 1D 2 5 7 15 13 8 9 8710 1D 3 5 7 15 13 9 9 8800 1D 3 5 8 16 12 9 9 8900 1D 3 5 10 17 13 11 10 81000 1D 4 5 11 16 11 10 8 9The above silencers give the following approximate dBA reductions:B Type 1 diameter length – 7 to 10 dBA C T ype 1 diameter length – 12 to 15 dBA.For full acoustic details and resistance to air flow for type C see publication SPO1.Acoustic Performance C Type (with Pod)Acoustic Performance (dB) – Octave Band Mid Fr equency – HzBore Dia.Lengthmm (D)63 125 250 500 1K 2K 4K 8K315 1D 2 5 5 9 18 20 18 15355 1D 2 5 6 9 18 22 19 16400 1D 2 6 6 10 19 24 20 17450 1D 2 4 7 13 20 23 22 17500 1D 2 3 8 16 21 22 21 17560 1D 3 5 8 16 20 18 19 15630 1D 3 5 8 15 19 16 14 12710 1D 3 5 8 15 19 15 14 12800 1D 4 5 8 16 19 15 14 13900 1D 4 5 9 17 19 15 14 131000 1D 5 5 11 18 19 15 14 13Suitablefor fanOAProductNumbersB TypeB C JB TypeWeight (kg)C Type315 SB211401 415 315 M8 10 13355 SB221401 455 355 M8 12 15400 SB241401 500 400 M10 15 18450 SB251401 600 450 M10 20 24500 SB271401 650 500 M10 25 29560 SB281401 710 560 M10 30 35630 SB301401 780 630 M10 35 42710 SB311401 860 710 M10 44 53800 SB331401 1000 800 M10 55 66900 SB341401 1100 900 M12 70 841000 SB351401 1200 1000 M12 82 100Bold text denotes Super Expr ess Product, next day deliver y available if or dered by 4pm.

Guard – JM AerofoilSuitablefor fanφAType C WeightJM Bell Mouth Inlet– Fan with flanged inlet onlyJM AccessoriesCased Fans315 I 137 1.2315 IV 30 0.5355 I 137 1.4355 IV 30 0.5400 I 137 1.6400 IV 30 0.6450 I 137 1.8450 II 137 1.6450 IV 30 0.6500 I 137 2500 II 137 1.8500 IV 30 0.7560 I 137 2.2560 II 137 2560 IV 50 1630 I 137 2.8630 II 137 2.6630 III 350 3630 IV 50 1.2710 I 137 3.2710 II 137 3710 III 350 3.4710 IV 50 1.4800 I 137 3.5800 II 137 3.3800 III 350 3.9800 IV 50 1.5900 I 137 4.2900 II 137 4.2900 III 310 4.8900 IV 50 1.71000 I 137 51000 II 137 4.81000 III 310 5.61000 IV 50 2Type I & TypeIIImpeller SideL & S TypeMotor SideS Type(BT, CT &F22)Type IIIMotor SideS Type(132 & 160)Type IVBellmouth &L TypeMotor SideType II guards have a Ø220 hole cut out of centre.SuitableforfanφAProductNumbersCDWeight(kg)315 408593 65 379 1355 248950 85 423 1.2400 74880 80 480 1.5450 248952 95 536 2500 74881 87 600 3.2560 248953 100 668 4630 74882 108 757 4.8710 74883 126 857 5.4800 74884 134 957 6.8900 404842 150 1077 81000 74885 167 1199 17.8JM – Matching Flanges and Flexible ConnectorSuitableProduct NumbersWeight (kg)for Matching Flexible C Matching Flexiblefan OAFlange ConnectorFlange Connection315 DA408238 AS040315 110 1.1 3.3355 DA501351 AS040355 110 1.3 3.9400 DA074913 AS040400 110 1.5 4.5450 DA501353 AS040450 110 1.7 5500 DA074914 AS040500 110 2 5.5560 DA501355 AS040560 110 2.3 6.8630 DA074915 AS040630 160 3 7.5710 DA074916 AS040710 160 3.2 8.1800 74917 AS040800 160 3.6 9.1900 404841 AS040900 160 4.1 10.41000 74918 AS041000 160 4.6 11.6Note: Flexible Connection weight includes two Matching Flanges.Suitable for up to 600°C emergency operation for 2 hours and200°C continuous.Bold text denotes Super Expr ess Product, next day deliver y available if or dered by 4pm.Telephone:01206 222 555CASEDFax:01206 222 905Email:fans.uk@flaktwoods.comExpress Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselector59

CASED 60Telephone:01206 222 555Rubber in Shear V ibration IsolatorsTypeLoadrange permounting(kg)Fax:01206 222 905ProductNumberEmail:fans.uk@flaktwoods.comA B C E F H J K LExpress Website:www.flaktwoods.com/expressFan Selector:www.flaktwoods.com/fanselectorJM AccessoriesCased Fans63.105.40 0-4 267321 64 43 2 20 50 M6 - 7 763.105.60 0-9 267322 64 43 2 20 50 M6 - 7 719.100.yellow 5-28 DA267336 80 45 5 32 57 M8 41 12 919.100.Blue 950 DA267337 80 45 5 32 57 M8 41 12 919.100.Red 16-85 267342 80 45 5 32 57 M8 41 12 919.101.Blue 23-180 DA267345 95 60 5 45 71 M10 56 14 919.101.Red 35-280 DA267346 95 60 5 45 71 M10 56 14 919.102.Red 48-400 267352 150 86 6 70 115 M12 82 22 11JM Mounting FeetEnclosed Spring Vibration IsolatorsProductCodeProductNumberFrame Size G L M N P T V W315 DA408199 BT/CT.F22 175 265 315 10 200 10 20 60355 DA408200 BT/CT.F22 200 305 355 10 225 10 20 60400 DA408201 BT/CT.F22 225 350 400 10 250 12 20 60450 DA408202 BT/CT,F22 255 400 450 10 280 12 20 60500 DA408203 BT/CT,F22 290 450 500 10 315 12 25 65560 DA408204 BT/CT,F22 330 510 560 10 355 12 25 65630 DA243495 BT/CT,F22 375 580 630 10 400 14 25 65710 DA245874 BT/CT,F22 415 660 710 10 440 14 25 80800 245024 BT/CT,F22 485 750 800 12 510 14 25 80800 249468 132 485 750 800 1 510 14 25 80900 249467 F22 491 850 900 12 518 14 25 60900 249258 132 491 850 900 12 518 14 25 601000 249464 F22 547 950 1000 10 574 15 25 601000 249255 132 547 50 1000 12 574 15 25 60TypeLoadrange permounting(kg)ProductNumberA B C D E F G H J KES20/10/ZSB Purple 10 503008 76 38 60 54 48 66 3 M8 40 6.5ES20/15/ZSB Yellow 15 503009 76 38 60 54 48 66 3 M8 40 6.5ES20/20/ZSB Grey 20 503010 76 38 60 54 48 66 3 M8 40 6.5ES25/60/7SB Green 60 503015 110 70 90 85 78 94 6 M10 60 9ES25/100/ZSB Blue 100 503016 110 70 90 85 78 94 6 M10 60 9Bold text denotes Super Expr ess Product, next day deliver y available if or dered by 4pm.