Lambda sensors

More documents

Recommendations

Info

D 10 | Oxygen Sensor Type Code LSU 4.2LSU 4.2 Technical Data & SpecificationsGeneralSensor Part Number ( as example )with 650mm cable length 0 258 006 065with 460mm cable length 0 258 006 066Electrical connection6 pole connector module(with integrated trim resistor)Connector part number D 261 205 138Mounting thread sizeM18 x 1.5mmSensor hexagon size SW 22Application ConditionsTemperature range, passive (storage temperature)Permissible maximum exhaust gas temperature at sensor element with heatingswitched on. Note: If the exhaust gas temperature of 850 º C is exceeded,the heater power must be switched off. In this case the accuracy ofthe sensor signal is limited.Operating temperatureof the sensor housing hexagonat the cable glandat the connection cableat the connectorMaximum current load of lambda = 1 Nernst cellMaximum pumping current into pump cellfor rich gas signalfor lean gas signalHeater ElementNominal supply voltage, test voltageMaximum permissible effective heater voltage at sensor element temperature of< 900 º Cshort time < 200 hourscontinuousMinimum frequency of heater voltage controlat supply voltage (peak) < 16 Vat supply voltage (peak) < 28 VNominal heating power for exhaust gas = 350 º C & exhaust gas flowspeed of ~ 0.7 m/sec at 9 V heater voltageInsulation resistance between heater and sensor connection-40…+ 100 º C< + 980 º C(max 250 h in 10 min intervals)< + 570 º C< + 200 º C< + 150 º C< + 120 º C< 10 uA> - 9 mA< 18 mA9 V< 13 V< 12 V> 2 Hz> 10 Hz~10 W> 30m ohmsInitial heater voltage is dependent on start temperature of sensor; nominal values at- 40 º C 7.4 V- 10 º C 7.8 V+ 20 º C 8.2 V+ 50 º C 8.6 VMaximum heater voltage increase during warm-up phaseNominal heater cold resistance at ambient temperature for new sensor,including cable and connectorat 20 º Cat - 40 º C< 0.4 V/sec3.2 ohms2.1 ohmsBosch Automotive Aftermarket 2009 | 2010
Oxygen Sensor Type Code LSU 4.2 | D 11Data for Measurement Applications<strong>Lambda</strong> control rangeSensor internal resistance at 750 º CGuideline value for sensor “light-off time” to be reached after switching on sensorheater; exhaust gas temperature ~ 20 º C0.70…infinity~ 80 ohms< 20 secSensor ageing (lambda value drift) in calibration gas; measured at exhaust gastemperature of 20 º Cat lambda = 1.70; lambda delta change +/- 0.20at lambda = 0.80; lambda delta change +/- 0.04Sensor useful life at exhaust temperature of < 300 º C> 160,000 km dependent oninstallation compliance2009 | 2010 Bosch Automotive Aftermarket
Page 1 and 2:
Direct Fit and Universal Applicatio
Page 3 and 4:
A 1Oxygen SensorsProduct Informatio
Page 5 and 6:
The Bosch Automotive Story | A 3In
Page 7 and 8:
The Modern Oxygen Sensor | A 5Vehic
Page 9 and 10:
Bosch Oxygen Sensor Design Types |
Page 11 and 12:
Oxygen Sensor Evolution | A 990,000
Page 13 and 14:
Oxygen Sensor Evolution | A 11Unive
Page 15 and 16:
Oxygen Sensor Construction and Oper
Page 17 and 18:
Oxygen Sensors - System Application
Page 19 and 20:
Testing of Oxygen Sensors | A 17Sim
Page 21 and 22:
Causes and Effects of Oxygen Sensor
Page 23 and 24:
The Bosch Yellow Jackets Edition 20
Page 25 and 26:
Diagnose Your Sensors | A 23KTS oxy
Page 27 and 28:
| B1Vehicle Application ListingB2 |
Page 29 and 30:
ASTON MARTIN | B3Brera939 01.06 939
Page 31 and 32:
AUDI | B58P1 07.03 - 08.04 BDB 6 3.
Page 33:
AUDI | B78E2, B6 03.01 - 12.04 BBJ
Page 37 and 38:
AUDI | B118E2, B6 03.03 - 12.04 BBK
Page 39 and 40:
BENTLEY | B138C2, B4 09.91 - 12.94
Page 41 and 42:
BMW | B15X5E 53 03.99 - 09.03 44 8S
Page 43 and 44:
BMW | B17316ti CompactE 36 10.94 -
Page 45 and 46:
BMW | B19323i TouringE 91 09.05 N52
Page 47 and 48:
BMW | B21E 60 03.07 N53 B25A 6 2.5
Page 49 and 50:
BMW | B23645CiE 63 01.04 - 09.05 N6
Page 51 and 52:
CITROEN | B25CHRYSLERCrossfireZH 03
Page 53 and 54:
DAIHATSU | B27DAEWOOCielo08.94 - 08
Page 55 and 56:
FORD | B29456456GT51255057506.00 F1
Page 57 and 58:
FORD | B31EB II 10.92 - 04.93 J 8 5
Page 59 and 60:
FORD | B33FestivaWB 04.94 - 12.96 U
Page 61 and 62:
FORD | B35DC II 03.92 - 02.95 Z 8 5
Page 63 and 64:
HOLDEN | B37VS II 09.96 - 04.98 VU
Page 65 and 66:
HONDA | B39LG 09.94 - 09.96 7AFE 4
Page 67 and 68:
HONDA | B41GH 12.98 - 12.01 D16W2 4
Page 69 and 70:
HYUNDAI | B43VY II 09.03 - 09.04 VF
Page 71 and 72:
JAGUAR | B45TucsonJM 08.04 G4GC 4 2
Page 73 and 74:
LAND ROVER GROUP | B47WranglerTJ 01
Page 75 and 76:
MAZDA | B49MASERATIQuattroporte03.0
Page 77 and 78:
MERCEDES-BENZ | B51BJ 07.99 - 09.03
Page 79 and 80:
MERCEDES-BENZ | B53CLK55 AMGW208 05
Page 81 and 82:
MERCEDES-BENZ | B55W219 04.06 M 273
Page 83 and 84:
MERCEDES-BENZ | B57W203 06.05 - 07.
Page 85 and 86:
MERCEDES-BENZ | B59E280W124 07.93 -
Page 87 and 88:
MERCEDES-BENZ | B61SLK 350W171 12.0
Page 89:
MERCEDES-BENZ | B63S430W220 10.98 -
Page 92 and 93:
B66 | MITSUBISHIMITSUBISHIMChalleng
Page 94 and 95:
B68 | NISSANNNISSANLaurel06.97 - 08
Page 96 and 97:
B70 | PEUGEOTPPEUGEOTN5 05.97 - 10.
Page 98 and 99:
B72 | PORSCHEPPORSCHECarrera GT10.0
Page 100 and 101:
B74 | RENAULTRRENAULTBB./CB./SB. 03
Page 102 and 103:
B76 | ROVERROVER7582701.99 - 05.05
Page 104 and 105:
B78 | SAABSAAB09.93 - 12.98 B 234 I
Page 106 and 107:
B80 | SUBARUSUBARUGD,GG 07.01 - 05.
Page 108 and 109:
B82 | TOYOTATTOYOTAMCV36R 09.02 - 0
Page 110 and 111:
B84 | TOYOTATOYOTAACA 20/21 05.00 -
Page 112 and 113:
B86 | VOLVOVOLVOVV4001.96 - 07.99 B
Page 114 and 115:
B88 | VOLVO940960VOLVO09.95 - 07.97
Page 116 and 117:
B90 | VWVVWGolf V1K1 08.04 - 11.05
Page 118 and 119:
B92 | VWVVW3C2 11.05 BWA 4 2.0 Cont
Page 120 and 121:
2B 94 | NotesBosch Automotive After
Page 122 and 123:
C 2 | Universal Oxygen Sensor Progr
Page 124 and 125:
C 4 | Universal Oxygen Sensor Insta
Page 126 and 127:
C 6 | Cross Reference Direct Fit to
Page 128 and 129: C 8 | Cross Reference Direct Fit to
Page 130 and 131: C 10 | Cross Reference Direct Fit t
Page 132 and 133: C 12 | Cross Reference Direct Fit t
Page 134 and 135: 14C 14 | Product Images0 258 001 05
Page 166 and 167: 46C 46 | Product ImagesF 00H L00 05
Page 168 and 169: 48C 48 |NotesBosch Automotive After
Page 170 and 171: D 2 | Supporting Stone Brothers Rac
Page 172 and 173: D 4 | Oxygen Sensor Type Code LSM 1
Page 174 and 175: D 6 | Oxygen Sensor Type Code LSM 1
Page 176 and 177: D 8 | Oxygen Sensor Type Code LSU 4
Page 180 and 181: D 12 |NotesBosch Automotive Afterma
Page 182 and 183: D 14 |NotesBosch Automotive Afterma
Page 184: Assuring your workshop’s future s
show all

Lambda sensors

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?