Proposed Permit to Operate - Air Pollution Control District

COUNTY OF SAN DIEGO, AIR POLLUTION CONTROL DISTRICT10124 OLD GROVE RD, SAN DIEGO, CA 92131(858) 586-2600 FAX (858) 586-2601 PERMIT NO.921303EXPIRESJune 15, 2016PERMIT TO OPERATETHE FOLLOWING IS HEREBY GRANTED A PERMIT TO OPERATE THE ARTICLE, MACHINE, EQUIPMENT OR CONTRIVANCE DESCRIBED BELOW. THISPERMIT IS NOT TRANSFERABLE TO A NEW OWNER NOR IS IT VALID FOR OPERATION OF THE EQUIPMENT AT ANOTHER LOCATION, EXCEPT FORPORTABLE EQUIPMENT. RULE 10C REQUIRES THIS PERMIT TO OPERATE OR COPY BE POSTED ON OR WITHIN 25 FEET OF THE EQUIPMENT, ORMAINTAINED READILY AVAILABLE AT ALL TIMES ON THE OPERATING PREMISES.PERMITTEEEQUIPMENT ADDRESSNATIONAL STEEL & SHIPBUILDINGPO BOX 85278 MS 20 J28TH ST & HARBOR DRSAN DIEGO, CA 92186-5278 SAN DIEGO, CA 92113EQUIPMENT DESCRIPTIONCRANE #14: CUMMINS, MODEL QST30-G1 NR1, 1030 BHP, DIESEL FIRED,TURBO CHARGED, AFTERCOOLED,S/N 37198949, ENGINE FAMILY NO. 1CEXL030.ABA, VENTED TO A DIESEL PARTICULATE FILTER AND ANENGLEHARD SELECTIVE CATALYTIC REDUCTION SYSTEM..EVERY PERSON WHO OWNS OR OPERATES THIS EQUIPMENT IS REQUIRED TO COMPLY WITH THE CONDITIONSLISTED BELOW AND ALL APPLICABLE REQUIREMENTS AND DISTRICT RULES, INCLUDING BUT NOT LIMITED TORULE(S) 50, 53, 62, AND 69.4.1.FAILURE TO OPERATE IN COMPLIANCE IS A MISDEMEANOR AND IS SUBJECT TO CIVIL AND CRIMINAL PENALTIES.A. FEDERALLY-ENFORCEABLE AND DISTRICT-ENFORCEABLE CONDITIONS1. THE PERMITTEE SHALL COMPLY WITH THE FOLLOWING APPLICABLE REQUIREMENTS: RULE 53 ANDRULE 62.[RULE 1421]2. THIS EQUIPMENT SHALL BE PROPERLY MAINTAINED AND KEPT IN GOOD OPERATING CONDITION AT ALLTIMES IN ACCORDANCE WITH MANUFACTURER'S INSTRUCTIONS. THESE INSTRUCTIONS SHALL BE KEPTONSITE.[RULE 69.4.1]3. AN ENGINE IDENTICAL TO THE ONE DESCRIBED ABOVE WITH SERIAL NO. 37223631 MAY BE USEDDURING TIMES WHEN THE ENGINE DESCRIBED ABOVE IS UNDERGOING MAINTENANCE. AT NO TIMESHALL THE ENGINE WITH SERIAL NO. 37223631 BE OPERATED WHEN ALL FOUR ENGINES DESCRIBEDIN PERMIT TO OPERATE NOS. 950706, 921303, 975360 AND 975361 ARE IN OPERATION. [NSR]4. THIS EQUIPMENT SHALL BE FIRED ON CALIFORNIA DIESEL FUEL ONLY.[RULE 69.4.1]5. THE PERMITTEE SHALL MAINTAIN CALIFORNIA DIESEL FUEL CERTIFICATION TO SUBSTANTIATE THEUSE OF THIS FUEL. THESE RECORDS SHALL BE MAINTAINED ONSITE FOR FIVE YEARS AND MADEAVAILABLE TO THE DISTRICT UPON REQUEST.[RULE 69.4.1]6. PERMITTEE SHALL KEEP A MANUAL OF RECOMMENDED MAINTENANCE PROVIDED BY THEMANUFACTURER, OR OTHER MAINTENANCE PROCEDURES AS APPROVED IN WRITING BY THEDISTRICT. (RULE 69.4.1)7. THE SELECTIVE CATALYTIC REDUCTION SYSTEM (SCR) AND DIESEL PARTICULATE FILTER SHALL BEMAINTAINED IN GOOD CONDITION AND IN FULL OPERATION AT ALL TIMES WHEN THE ENGINE IS INOPERATION.[RULE 69.4.1 AND NSR]8. THE NON-RESETTABLE FUEL METER SHALL BE MAINTAINED IN GOOD WORKING ORDER AND USED FORRECORDING TOTAL FUEL USAGE OF THIS ENGINE. THE DISTRICT'S COMPLIANCE DIVISION SHALL BENOTIFIED PRIOR TO REPLACEMENT OF THE FUEL METER.[RULE 69.4.1]9. THE FUEL CONSUMPTION FOR THIS ENGINE, AND ANY SPARE ENGINE USED IN THE SAMECRANE,SHALL NOT EXCEED 262,400 GALLONS PER CALENDAR YEAR. A DAILY LOG OFFUEL CONSUMPTION OFANY ENGINE USED IN THIS CRANE SHALL BE MAINTAINED ON THE PREMISES. (NSR)[NSR]10. OXIDES OF NITROGEN (NOX) EMISSIONS FROM THIS ENGINE SHALL NOT EXCEED 53 PPM BY VOLUME,MEASURED IN THE FLUE GAS CALCULATED AT 15 PERCENT OXYGEN ON A DRY BASIS.[CA EXECUTIVE ORDER D-24-01]11. CARBON MONOXIDE (CO) EMISSIONS FROM THE ENGINE SHALL NOT EXCEED 4500 PPM BY VOLUME(PPMV), MEASURED IN THE FLUE GAS AND CALCULATED AT 15 PERCENT OXYGEN ON A DRY BASIS.[RULE 69.4.1]Permit Conditions Continued...Page 1