MATERIAL SAFETY DATA SHEET - USG Corporation
MATERIAL SAFETY DATA SHEET - USG Corporation
MATERIAL SAFETY DATA SHEET - USG Corporation
You also want an ePaper? Increase the reach of your titles
YUMPU automatically turns print PDFs into web optimized ePapers that Google loves.
61320001<br />
<strong>MATERIAL</strong> <strong>SAFETY</strong> <strong>DATA</strong> <strong>SHEET</strong><br />
<strong>SHEET</strong>ROCK® All Purpose Joint Compound<br />
United States Gypsum Company<br />
550 West Adams Street<br />
Chicago, Illinois 60661-3637<br />
A Subsidiary of <strong>USG</strong> <strong>Corporation</strong><br />
SECTION 1<br />
CHEMICAL PRODUCT AND IDENTIFICATION<br />
PRODUCT(S) <strong>SHEET</strong>ROCK® All Purpose Joint Compound<br />
CHEMICAL FAMILY /<br />
GENERAL CATEGORY<br />
Joint Treatment<br />
SYNONYMS Joint Compound, Taping Compound, Mud<br />
SECTION 2<br />
HAZARD IDENTIFICATION<br />
Product Safety: 1 (800) 507-8899<br />
www.usg.com<br />
Version Date: January 1, 2011<br />
Version: 7<br />
MSDS #61-320-001<br />
Page 1 of 8<br />
EMERGENCY OVERVIEW:<br />
ΔWARNING!<br />
This product is not expected to produce any unusual hazards during normal use. Exposure to high dust levels may<br />
irritate the skin, eyes, nose, throat, or upper respiratory tract. Prolonged and repeated breathing of respirable mica<br />
dust may cause lung disease (pneumoconiosis).<br />
POTENTIAL HEALTH EFFECTS (See Section 11 for more information)<br />
ACUTE :<br />
Inhalation<br />
Eyes<br />
Skin None known.<br />
Ingestion None known.<br />
CHRONIC:<br />
Inhalation<br />
Eyes None known.<br />
Skin None known.<br />
Ingestion None known.<br />
Exposure to dust generated during the handling or sanding of the product may cause temporary<br />
irritation to eyes, skin, nose, throat, and upper respiratory tract. Persons subjected to large amounts<br />
of this dust will be forced to leave area because of nuisance conditions such as coughing, sneezing<br />
and nasal irritation. Labored breathing may occur after excessive inhalation. If respiratory symptoms<br />
persist, consult physician.<br />
Dust can cause temporary mechanical irritation of eyes. If burning, redness, itching, pain or other<br />
symptoms persist or develop, consult physician.<br />
Prolonged and repeated breathing of respirable mica dust may cause lung disease (pneumoconiosis).<br />
The extent and severity of lung injury correlates with the length of exposure and dust concentration.<br />
Exposures to respirable crystalline silica are not expected during the normal use of this product;<br />
however, actual levels must be determined by workplace hygiene testing. Prolonged and repeated<br />
exposure to airborne free respirable crystalline silica can result in lung disease (i.e., silicosis) and/or<br />
lung cancer. The development of silicosis may increase the risks of additional health effects. The risk<br />
of developing silicosis is dependent upon the exposure intensity and duration.
<strong>MATERIAL</strong> <strong>SAFETY</strong> <strong>DATA</strong> <strong>SHEET</strong><br />
<strong>SHEET</strong>ROCK® All Purpose Joint Compound<br />
TARGET ORGANS: Eyes, skin and respiratory system.<br />
PRIMARY ROUTES OF ENTRY: Inhalation, eyes and skin contact.<br />
MSDS #61-320-001<br />
Page 2 of 8<br />
CARCINOGENICITY CLASSIFICATION OF INGREDIENT(S) All substances listed are associated with the nature of<br />
the raw materials used in the manufacture of this product and are not independent components of the product<br />
formulation. All substances, if present, are at levels well below regulatory limits. See Section 11: Toxicology<br />
Information for detailed information.<br />
<strong>MATERIAL</strong> IARC NTP ACGIH CAL- 65<br />
Crystalline silica 1 1 A2 Listed<br />
IARC - International Agency for Research on Cancer: 1- Carcinogenic to humans; 2A – Probably carcinogenic to<br />
humans; 2B – Possibly carcinogenic to humans; 3 - Not classifiable as a carcinogen; 4 – Probably not a carcinogen<br />
NTP – National Toxicology Program (Health and Human Services Dept., Public Health Service, NIH/NIEHS): 1-<br />
Known to be carcinogen; 2- Anticipated to be carcinogens<br />
ACGIH – American Conference of Governmental Industrial Hygienists: A1 – Confirmed human carcinogen; A2 –<br />
Suspected human carcinogen; A3 – Animal carcinogen; A4 - Not classifiable as a carcinogen; A5 – Not suspected as<br />
a human carcinogen<br />
CAL-65 – California Proposition 65 “Chemicals known to the State of California to Cause Cancer”<br />
Respirable crystalline silica: IARC: Group 1 carcinogen, NTP: Known human carcinogen. The weight percent of<br />
crystalline silica given represents total quartz and not the respirable fraction. The weight percent of respirable silica<br />
has not been measured in this product.<br />
Food and Drug Administration [CFR Title 21, v.3, sec 184.1409] – Ground limestone is Generally Recognized as Safe<br />
(GRAS).<br />
POTENTIAL ENVIRONMENTAL EFFECTS: This product has no known adverse effect on ecology. (See Section 12<br />
for more information.)<br />
SECTION 3<br />
COMPOSITION, INFORMATION ON INGREDIENTS<br />
<strong>MATERIAL</strong> WT% CAS #<br />
Limestone >65<br />
Or Dolomite<br />
Mica
Eyes<br />
<strong>MATERIAL</strong> <strong>SAFETY</strong> <strong>DATA</strong> <strong>SHEET</strong><br />
<strong>SHEET</strong>ROCK® All Purpose Joint Compound<br />
MSDS #61-320-001<br />
Page 3 of 8<br />
In case of contact, do not rub or scratch your eyes. To prevent mechanical irritation, flush thoroughly<br />
with water for 15 minutes. If irritation persists, consult physician.<br />
Skin Wash with mild soap and water. If irritation persists, consult physician.<br />
Ingestion This product is not intended to be ingested or eaten. If gastric disturbance occurs, call physician.<br />
MEDICAL CONDITIONS WHICH MAY BE AGGRAVATED: Pre-existing upper respiratory and lung diseases such<br />
as, but not limited to, bronchitis, emphysema and asthma. Pre-existing skin diseases such as, but not limited to,<br />
rashes and dermatitis.<br />
NOTES TO PHYSICIAN: Treatment should be directed at the control of symptoms and the clinical condition.<br />
General Fire Hazards None known<br />
SECTION 5<br />
FIRE FIGHTING MEASURES<br />
Extinguishing Media Water or use extinguishing media appropriate for surrounding fire.<br />
Special Fire Fighting Procedures Wear appropriate personal protective equipment. See section 8.<br />
Unusual Fire/ Explosion Hazards None known<br />
Hazardous Combustion Products<br />
Above 800º C – limestone may decompose to calcium oxide (CaO) and<br />
carbon dioxide (CO2).<br />
Flash Point Not Determined Auto Ignition Not Applicable<br />
Method Used Not Applicable Flammability<br />
Upper Flammable Limit (UFL) Not Determined Classification<br />
Not Applicable<br />
Lower Flammable Limit (LFL) Not Determined Rate of Burning Not Applicable<br />
SECTION 6<br />
ACCIDENTAL RELEASE MEASURES<br />
CONTAINMENT: No special precautions. Wear appropriate personal protective equipment. See section 8.<br />
CLEAN-UP: Use normal clean up procedures. No special precautions.<br />
DISPOSAL: Follow all local, state, provincial and federal regulations. Never discharge large releases directly into<br />
sewers or surface waters.<br />
SECTION 7<br />
HANDLING AND STORAGE<br />
HANDLING: Avoid dust contact with eyes and skin. Wear the appropriate eye and skin protection against dust (See<br />
Section 8). Minimize dust generation and accumulation. Avoid breathing dust. Wear the appropriate respiratory<br />
protection against dust in poorly ventilated areas and if TLV is exceeded (see Sections 2 and 8). Use good safety and<br />
industrial hygiene practices.
<strong>MATERIAL</strong> <strong>SAFETY</strong> <strong>DATA</strong> <strong>SHEET</strong><br />
<strong>SHEET</strong>ROCK® All Purpose Joint Compound<br />
MSDS #61-320-001<br />
Page 4 of 8<br />
STORAGE: Store in a cool, dry, ventilated area away from sources of heat, moisture and incompatibilities (see<br />
Section 10).<br />
SECTION 8<br />
EXPOSURE CONTROLS/PERSONAL PROTECTION<br />
<strong>MATERIAL</strong> WT% TLV (mg/m 3 ) PEL( mg/m 3 )<br />
Limestone >65<br />
Or Dolomite<br />
Mica
<strong>MATERIAL</strong> <strong>SAFETY</strong> <strong>DATA</strong> <strong>SHEET</strong><br />
<strong>SHEET</strong>ROCK® All Purpose Joint Compound<br />
Freezing Point Not Applicable Viscosity Not Applicable<br />
Boiling Point Not Applicable Particle Size Varies<br />
Flash Point Not Determined Bulk Density ~ 40-80 lb/ft3<br />
Evaporation Rate (BuAc = 1)<br />
Not Applicable Molecular Weight Mixture<br />
Upper Flammable Limit (UFL) Not Determined VOC Content Zero g/L<br />
Lower Flammable Limit (LFL) Not Determined Percent Volatile Zero<br />
Vapor Pressure (mm Hg) Not Applicable<br />
STABILITY Stable.<br />
SECTION 10<br />
CHEMICAL STABILITY AND REACTIVITY<br />
CONDITIONS TO AVOID Contact with incompatibles (see below).<br />
INCOMPATIBILITY None known.<br />
HAZARDOUS POLYMERIZATION None known.<br />
HAZARDOUS DECOMPOSITION<br />
ACUTE EFFECTS: None known.<br />
MSDS #61-320-001<br />
Page 5 of 8<br />
Above 800º C – limestone may decompose to calcium oxide (CaO)<br />
and carbon dioxide (CO2).<br />
SECTION 11<br />
TOXICOLOGICAL INFORMATION<br />
CHRONIC EFFECTS / CARCINOGENICITY:<br />
Mica: Prolonged and repeated breathing of respirable mica dust may cause lung disease (pneumoconiosis). The<br />
extent and severity of lung injury correlates with the length of exposure and dust concentration.<br />
Crystalline Silica: Exposures to respirable crystalline silica are not expected during the normal use of this product;<br />
however, actual levels must be determined by workplace hygiene testing. The weight percent of respirable crystalline<br />
silica may not have been measured in this product. Prolonged and repeated exposure to airborne free respirable<br />
crystalline silica can result in lung disease (i.e., silicosis) and/or lung cancer. The development of silicosis may<br />
increase the risks of additional health effects. Smoking in combination with silica exposures increases the risk of<br />
cancer. The risk of developing silicosis is dependent upon the exposure intensity and duration.<br />
In June, 1997, IARC classified crystalline silica (quartz and cristobalite) as a human carcinogen. In making the overall<br />
evaluation, the IARC Working Group noted that carcinogenicity in humans was not detected in all industrial<br />
circumstances studied. Carcinogenicity may be dependent on inherent characteristics of the crystalline silica or on<br />
external factors affecting its biological activity or distribution of its polymorphs.<br />
IARC states that crystalline silica inhaled in the form of quartz or cristobalite from occupational sources is carcinogenic<br />
to humans (Group 1).<br />
SECTION 12<br />
ECOLOGICAL INFORMATION
<strong>MATERIAL</strong> <strong>SAFETY</strong> <strong>DATA</strong> <strong>SHEET</strong><br />
<strong>SHEET</strong>ROCK® All Purpose Joint Compound<br />
ENVIRONMENTAL TOXICITY: This product has no known adverse effect on ecology.<br />
Ecotoxicity value Not determined.<br />
SECTION 13<br />
DISPOSAL CONSIDERATIONS<br />
MSDS #61-320-001<br />
Page 6 of 8<br />
WASTE DISPOSAL METHOD: Dispose of material in accordance with federal, state, and local regulations. Never<br />
discharge directly into sewers or surface waters. Consult with environmental regulatory agencies for guidance on<br />
acceptable disposal practices.<br />
SECTION 14<br />
TRANSPORT INFORMATION<br />
U.S. DOT INFORMATION: Not a hazardous material per DOT shipping requirements. Not classified or regulated.<br />
Shipping Name Same as product name.<br />
Hazard Class Not classified.<br />
UN/NA # None. Not classified.<br />
Packing Group None.<br />
Label (s) Required Not applicable.<br />
GGVSec/MDG-Code Not classified.<br />
ICAO/IATA-DGR Not applicable.<br />
RID/ADR None.<br />
ADNR None.<br />
UNITED STATES REGULATIONS<br />
SECTION 15<br />
REGULATORY INFORMATION<br />
All ingredients of this product are included in the U.S. Environmental Protection Agency’s Toxic Substances Control<br />
Act Chemical Substance Inventory.<br />
<strong>MATERIAL</strong> WT%<br />
Limestone >65<br />
Or Dolomite<br />
Mica
<strong>MATERIAL</strong> <strong>SAFETY</strong> <strong>DATA</strong> <strong>SHEET</strong><br />
<strong>SHEET</strong>ROCK® All Purpose Joint Compound<br />
Hydroxypropyl Amylopectin Phosphate
<strong>MATERIAL</strong> <strong>SAFETY</strong> <strong>DATA</strong> <strong>SHEET</strong><br />
<strong>SHEET</strong>ROCK® All Purpose Joint Compound<br />
INFORMATION FOR HANDLING AND IDENTIFICATION OF CHEMICAL HAZARDS<br />
MSDS #61-320-001<br />
Page 8 of 8<br />
HEALTH<br />
0<br />
*<br />
FLAMMABILITY<br />
1 0<br />
PHYSICAL HAZARD<br />
1<br />
0 = Minimal Hazard<br />
NFPA Ratings: HMIS Ratings: 1 = Slight Hazard<br />
0<br />
Health: 1 Health: 1 2 = Moderate Hazard<br />
0<br />
Fire: 0 Fire: 0 3 = Serious Hazard<br />
PERSONAL PROTECTION<br />
Reactivity: 0 Reactivity: 0 4 = Severe Hazard<br />
E – Safety glasses, gloves and dust respirator; * - Contains silica<br />
Key/Legend<br />
ANSI American National Standards Institute<br />
ACGIH American Conference of Governmental Industrial Hygienists<br />
CAA Clean Air Act<br />
CAS Chemical Abstracts Service (Registry Number)<br />
CERCLA Comprehensive Environmental Response, Compensation and Liability Act of 1980<br />
CFR Code of Federal Regulations<br />
DOT United States Department of Transportation<br />
DSL Canadian Domestic Substances List<br />
EPA United States Environmental Protection Agency<br />
EPCRA Emergency Planning & Community Right-to-know Act<br />
HMIS Hazardous Materials Identification System<br />
IARC International Agency for Research on Cancer<br />
MSHA Mine Safety and Health Administration<br />
NDSL Canadian Non-Domestic Substances List<br />
NFPA National Fire Protection Association<br />
NIOSH National Institute for Occupational Safety and Health<br />
OSHA Occupational Health and Safety Administration<br />
PEL Permissible Exposure Limit<br />
PPE Personal Protection Equipment<br />
RCRA Resource Conservation and Recovery Act<br />
SARA Superfund Amendments and Reauthorization Act of 1986<br />
TLV Threshold Limit Value<br />
TSCA Toxic Substances Control Act<br />
UN/NA# United Nations/North America number<br />
WHMIS Workplace Hazardous Material Information System<br />
Prepared by:<br />
Product Safety<br />
<strong>USG</strong> <strong>Corporation</strong><br />
550 West Adams Street<br />
Chicago, IL 60661-3637<br />
The information contained in this document applies to this specific material as supplied. It may not be valid for this<br />
material if it is used in combination with any other materials. It is the user’s responsibility to satisfy oneself as to the<br />
suitability and completeness of this information for his/her own particular use.<br />
END<br />
E