CD40022 Dispenser - Technical Manual - Ice-O-Matic
CD40022 Dispenser - Technical Manual - Ice-O-Matic
CD40022 Dispenser - Technical Manual - Ice-O-Matic
You also want an ePaper? Increase the reach of your titles
YUMPU automatically turns print PDFs into web optimized ePapers that Google loves.
Service Diagnosis CD40030/<strong>CD40022</strong><br />
Symptom Probable Cause Possible Fix<br />
No ice is dispensed No power to dispenser. Check for proper power.<br />
Basic Model Is dispenser plugged in?<br />
No ice. Check ice machine.<br />
Vend switch does not close. Check vend switch.<br />
Check chute for proper motion.<br />
Interlock switch open. Check interlock switch, be sure<br />
top panel is in place.<br />
Drive motor windings open. Check drive motor.<br />
Drive gears failed. Check gear reducer.<br />
No ice is dispensed Same as above plus coin Check coin switch.<br />
Coin Op Model switch does not close<br />
Vend timer does not work. Connect power to post 6 of<br />
coin mech timer, timer should<br />
activate, ready light should be<br />
ON and pushing the chute<br />
should start the gear motor,<br />
If not replace the vend timer.<br />
Only dispenser small Sweep arm damaged. Check/replace sweep arm.<br />
amounts of ice.<br />
No water dispensed, Water shut off. Check water supply to unit,<br />
Water <strong>Dispenser</strong> model check shutoff valve inside<br />
cabinet.<br />
Water leak Drain is plugged Check drain for restriction<br />
<strong>Ice</strong> catch pan has overfilled Remove excess ice.<br />
<strong>Ice</strong> catch pan screened plugged Clean screen<br />
Seal between ice machine Remove ice machine and<br />
And dispenser leaking replace gasket tape.<br />
Water drip from spout Some dripping is normal, Check spout drain for<br />
but if severe: restriction.<br />
Page 16