PUMP INSTALLATION - Calgary Pump Symposium

More documents

Recommendations

Info

SAFETY “A good pump installation improves safety, reliability, and asset life cycle cost.” Equipment location (grade / mezzanine) (indoor / outdoor) Proximity to personnel / work areas Prevailing wind Structural-borne vibration Guarding CSA / OSHA compliance Ambient temperature Brad Cassolato, P.Eng. WCI Ltd. 403-475-2534 cassolato@shaw.ca PUMP INSTALLATION NOTES 2
SAFETY ( cont’d ) Drainage (leakage) off to a safe place (sewers / dikes / trenches) Personnel unobstructed access / egress needed around machinery, piping, structures, start/stop, instruments, seal pots, and valves Ergonomics of PM and PdM activities Adequate lighting Housekeeping simplified Detectors (eg. LEL / H2S / fire) Brad Cassolato, P.Eng. WCI Ltd. 403-475-2534 cassolato@shaw.ca PUMP INSTALLATION NOTES 3
Page 1: PUMP INSTALLATION NOTES, COMMENTARY
Page 5 and 6: SAFETY ( cont’d ) Floor drain lo
Page 7 and 8: REFERENCES API-610 API RP 686 Pu
Page 9 and 10: BASEPLATES ( cont’d ) Literature
Page 11 and 12: BASEPLATES ( cont’d ) Approach to
Page 13 and 14: Open top - drain rim - angle sides
Page 15 and 16: Full I-beam construction - full sea
Page 17 and 18: Non-slip grating example Brad Casso
Page 19 and 20: RECEIVING EQUIPMENT Check against
Page 21 and 22: FOUNDATIONS ( cont’d ) Foundatio
Page 23 and 24: INSTALLATION Contractor qualificat
Page 25 and 26: Levelling pucks Photo courtesy of S
Page 27 and 28: Level baseplate side to side Photo
Page 29 and 30: ELECTRICAL Ground the equipment: -
Page 31 and 32: GROUTING “For a given baseplate
Page 33 and 34: GROUTING ( cont’d ) Cem
Page 35 and 36: GROUTING ( cont’d ) MANUAL POUR B
Page 37 and 38: GROUTING ( cont’d ) Brad Cassolat
Page 39 and 40: EPOXY GROUT Epoxy grout preferred
Page 41 and 42: EPOXY GROUT ( cont’d ) “Concret
Page 43 and 44: PIPING Good piping design and inst
Page 45 and 46: PIPING ( cont’d ) API RP686 SUCTI
Page 47 and 48: PIPING ( cont’d ) “4.6.2 Pipe f
Page 49 and 50: PIPING ( cont’d ) Brad Cassolato
Page 51 and 52: PIPING ( cont’d ) Don’t forget
Page 53 and 54:
GALLERY Brad Cassolato, P.Eng. WCI
Page 55 and 56:
Brad Cassolato 403-475-2534 cassola
Page 57 and 58:
Brad Cassolato, P.Eng. WCI Ltd. 403
Page 59 and 60:
OBSTRUCTED FOR LIFTING Brad Cassola
Page 61 and 62:
OBSTRUCTED FOR INGRESS Brad Cassola
show all

PUMP INSTALLATION - Calgary Pump Symposium

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?