2001-2002 DS - Mobilicab

INDEX
compression gauge 16-3
compressor, piston ring 16-5
compressor, valve spring 16-7
computer, onboard 12-19, 12-39, 12-47
connecting rod 7-13
connector, 4-pin 12-43
connector, cord 7-11
connector, iq controller 12-47
continuity tester 16-5
control cable 13-3, 13-5, 13-7
controller, 48-volt (220-amp) 12-39
controller, 48-volt (225-amp) 12-19
controller, 48-volt (250-amp) 12-47
cord connector 7-11
cordset, ac 13-3, 13-5, 13-7, 13-9, 13-11,
13-13, 13-15
cordset, dc 13-3, 13-5, 13-7, 13-9, 13-11,
13-13, 13-15
counterbalance guide shaft 7-13
counterbalance weight 7-13
cover
brush inspection port 6-11
controller 12-47
crankcase 7-11
dust 4-3, 5-9
electrical component box 6-7
gear case 11-7
oil pump 7-7
seat back 1-13, 1-15
seat bottom 1-11
steering column 5-3
wiper switch 12-21
wiper switch case 12-9
crank, bell 12-9, 12-21
crankcase 7-13
crankcase cover 7-11
crankshaft 7-13
crankshaft seal 7-11
crankshaft shim 7-13
cup, accelerator pedal return spring 4-7
current limiter 13-15
cutter, valve seat 16-7
cylinder head 7-9
D
damper, rpm limiter 7-5
dash panel, center 1-3
dash, driver side 1-3
dash, passenger side 1-3
decal
driver/passenger warning 3-3, 3-5
electrical component cover 3-5, 12-47
frame ground and governor warning 3-3
gasoline warning 3-3
ingersoll-rand 3-3, 3-5
key switch 3-3, 3-5
motor braking 3-5
operating instructions 3-3, 3-5
potentiometer 3-5
resistor warning 3-5
rotating parts and hot manifold warning
3-3
tow/run switch 3-5
wiper switch warning 12-9, 12-21
delta a-plate 5-7
delta shock and gear support 5-7
delta sleeve 5-7
differential bearing 15-3
differential gear 11-7, 15-3, 15-5
differential gear case 11-7, 15-5
differential housing 15-3
differential idler gear 11-7, 15-3, 15-5
differential pin 11-7, 15-3
diode 12-13, 12-19, 12-37
dipstick 7-3
door, access 1-7, 1-9
double lip seal 5-9
drag link, rack and pinion 5-5
drain plug (crankcase) 7-7
drink holder 1-3
drive bar 12-23
drive belt 10-3, 10-5
drive clutch 10-3
drive clutch holder tool 16-3
drive clutch hub puller 16-3
drive clutch puller 16-3
drive hub 10-3
driven clutch 10-5
driven clutch cam puller 16-3
driven clutch puller plug 16-3
drum, brake 4-3
dry moly lubricant 16-5
dust boot 5-5, 5-7
dust cap 12-43
dust cover 4-3, 5-9
E
8-volt battery 12-17, 12-35, 12-45
80-amp fuse 12-13
eccentric 5-9
e-clip (air box top) 8-11
electrical box cam 6-7
electrical component box 6-7
end bell, commutator 6-11
end bell, output shaft 6-11
end shield 14-3, 14-5, 14-7, 14-9
energy displacement coil 12-37
engine shroud 7-3
engine valve spring 7-9
engine, fe290 ohv gasoline 7-3
equalizer rod 4-5
equalizer, brake cable 4-5
e-ring (governor cable) 8-9
exhaust gasket 9-3
exhaust system 9-3
exhaust valve 7-9
F
4-pin plug and wedge lock 12-43
4-pin receptacle and wedge lock 12-43
48-volt motor, 3.10-hp 14-5
48-volt motor, 3.20-hp 14-7, 14-9
48-volt solenoid 12-19, 12-37, 12-47
fan housing 7-3
fan shroud 7-3
fan, flywheel 7-5
fastener, barrel 1-13, 1-15
fe290 ohv gasoline engine 7-3
fender, inner 1-7, 1-9
field coil (starter/generator) 6-11
fill plug 15-3
fill plug with gasket 15-5
filter, air 8-11
filter, fuel 8-3
filter, oil 7-7
fitting, grease 5-9
fitting, thread-forming grease 5-5, 5-7
fixed face (drive clutch) 10-3
fixed face (driven clutch) 10-5
float (carburetor) 8-5
float chamber 8-5
floor mat 1-3, 1-5, 1-7, 1-9
flywheel 7-5
flywheel fan 7-5
flywheel puller 16-5
fork, shift 11-5
forward/reverse bell crank 6-5
forward/reverse handle 6-5
forward/reverse shifter 6-5
forward/reverse shifter base 6-5
forward/reverse switch 12-7, 12-15, 12-33,
12-43
forward/reverse switch case 12-33, 12-43
forward/reverse switch handle 12-7, 12-15
front body 1-5
front spring retainer plate 5-9
f-terminal insulator 6-11
fuel filter 8-3
fuel impulse pump 8-3
fuel line 8-3
fuel pickup tube (valve) 8-3
fuel strap, rear 8-3
fuel tank 8-3
fuse 13-3, 13-5, 13-7, 13-9, 13-11, 13-13,
13-15
fuse block 6-7
fuse holder 12-13
fuse lens 12-13
fuse, 10-amp 6-7
fuse, 3/8-amp 12-17, 12-35, 12-45
fuse, 80-amp 12-13
Page i-10
2001/2002 DS Golf Cars Illustrated Parts List