2001-2002 DS - Mobilicab

More documents

Recommendations

Info

3 G E WARNING ROLLOVER OR FALLING OFF MAY CAUSE DEATH. • Before using vehicle, read operating instructions. • Remain seated and hold on to seat handle while moving. • Do not start vehicle until all occupants are seated. • Two (2) persons per seat maximum. • Operate from driver side only and not on public roads. • Keep entire body inside vehicle while moving. • Drive slowly in turns and straight up and down slopes. • Do not leave children unattended on vehicle. • Never operate under the influence of alcohol or drugs. • Use brakes to reduce speed when coasting downhill. • Never stand in front of or behind vehicle. CCI 101960601 DRIVER / PASSENGER WARNING DECAL 1 OFF ON KEY SWITCH DECAL 2 3 OPERATING INSTRUCTIONS • Read Owner's Manual and safety warnings located on dash panel prior to driving. • Study and understand controls. • Make sure wheels are turned in desired direction. • Turn key to “ON” position and be sure nothing is in your path. • While vehicle is stopped, select direction by placing shift lever or switch in desired position: F – Forward N – Neutral R – Reverse (Buzzer will sound) • Vehicle will start moving when accelerator pedal is depressed. • Slowly depress accelerator pedal to increase speed. Park brake will release when accelerator pedal is depressed. • To stop, release accelerator pedal and depress brake pedal. • After stopping, firmly depress park brake until it locks. • Place forward and reverse switch in neutral position. Turn key “OFF” and remove key when not in use. CCI 1016216-01 OPERATING INSTRUCTIONS DECAL IMPORTANT NOTICE VEHICLE EQUIPPED TO LIMIT DOWNHILL SPEED IMPORTANT NOTICE MOTOR BRAKING DECAL (POWERDRIVE PLUS VEHICLES ONLY) • Maximum vehicle speed is limited during downhill operation with accelerator pedal depressed. • Vehicle will brake gently when accelerator pedal is released. • System is activated only when tow switch is in the "RUN" position. • When towing vehicle, tow switch must be in the "TOW" position. CCI 1019599-01 (IQ SYSTEM VEHICLES ONLY) • Maximum vehicle speed is limited by motor braking during downhill operation with accelerator pedal depressed. • If motor brake enabled, vehicle motor will brake when accelerator pedal is released. • Beeping alarm indicates reduction in motor braking. Apply brakes to reduce speed. • System is activated only when tow switch is in the "RUN" position. • When towing vehicle, tow switch must be in the "TOW" position. 101959902 4 NOTICE ELECTRICAL COMPONENT DECAL (ON SPEED CONTROLLER COVER IQ SYSTEM VEHICLE ONLY) NOTICE Do not operate vehicle without this cover properly installed. Do not direct water stream in this area; will cause damage to components. See vehicle maintenance and service manual before servicing. CCI 101931501 • DO NOT OPERATE VEHICLE WITHOUT COVER IN PLACE. • DO NOT DIRECT WATER STREAM AT THIS SWITCH. POTENTIOMETER CAUTION DECAL (ON WIPER SWITCH COVER INSIDE BATTERY COMPARTMENT) 6 CCI 1016109-01 9 WARNING HOT RESISTORS (COILED WIRE) CAN CAUSE SEVERE BURNS. RESISTOR WARNING DECAL (ON FRAME UNDER SEAT ON V-GLIDE 36 VOLT VEHICLE) (ON MOUNTING PLATE UNDER ACCESS PANEL ON POWERDRIVE PLUS VEHICLE EQUIPPED WITH A DB SOLENOID AND COIL) 5 Club Car F N TOW/RUN SWITCH WARNING DECAL (ON TOW/RUN SWITCH BRACKET UNDER SEAT) 7 TOW Place Tow/Run switch in TOW position before: • Disconnecting or connecting batteries • Towing • Extended storage • Servicing RUN FAILURE TO HEED THIS WARNING COULD RESULT IN A BATTERY EXPLOSION OR SEVERE PERSONAL INJURY. CCI 101908601 (POWERDRIVE PLUS AND IQ SYSTEM VEHICLES) 8 INGERSOLL-RAND DECAL (ON BODY PANEL) (FOR 2001 VEHICLES ONLY) Page 3-4 2001/2002 DS Golf Cars Illustrated Parts List
ITEM PART NO. DESCRIPTION 1 2 3 4 DECALS – ELECTRIC VEHICLE 1 101960601 Decal, Driver/Passenger Warning ......................................................................... 1 2 101825101 Decal, Key Switch ................................................................................................. 1 3 101621601 Decal, Operating Instructions ................................................................................ 1 4 101959901 Decal, Motor Braking (PowerDrive Plus vehicle) ................................................... 1 4 101959902 Decal, Motor Braking (IQ System vehicle) ............................................................ 1 5 1013496 Decal, Resistor Warning (V-Glide 36-Volt and PowerDrive Plus vehicles) ..................................................................................... 1 6 101610901 Decal, Potentiometer Caution ............................................................................... 1 7 101952401 Decal, Ingersoll-Rand – Gold (for 2001 vehicles only)........................................... 2 8 101908601 Decal, Tow/Run Switch (PowerDrive Plus and IQ System vehicles) ..................... 1 9 101931501 Decal, Electrical Component Cover (IQ System vehicle) ...................................... 1 QTY 3 G E 2001/2002 DS Golf Cars Illustrated Parts List Page 3-5
Page 1: 2001-2002 ILLUSTRATED PARTS LIST DS
Page 4 and 5: NOTE: This illustrated parts list r
Page 6 and 7: CONTENTS SECTION 7 - FE290 ENGINE F
Page 9 and 10: BODY AND TRIM 1 G E
Page 11 and 12: ITEM PART NO. DESCRIPTION 1 2 3 4 B
Page 13 and 14: ITEM PART NO. DESCRIPTION 1 2 3 4 F
Page 15 and 16: REAR BODY AND FENDER - GASOLINE VEH
Page 17 and 18: REAR BODY AND FENDER - ELECTRIC VEH
Page 19 and 20: ITEM PART NO. DESCRIPTION 1 2 3 4 S
Page 21 and 22: SEAT BACK AND BAG HOOP - EARLIER ST
Page 23 and 24: ITEM PART NO. DESCRIPTION SEAT BACK
Page 25 and 26: ITEM PART NO. DESCRIPTION 1 2 3 4 C
Page 27 and 28: WHEELS AND TIRES 2 G E
Page 29 and 30: ITEM PART NO. DESCRIPTION 1 2 3 4 W
Page 31 and 32: DECALS 3 G E
Page 33: ITEM PART NO. DESCRIPTION 1 2 3 4 D
Page 37 and 38: BRAKES, PEDAL, AND CABLE ASSEMBLIES
Page 43 and 44: ITEM PART NO. DESCRIPTION 1 2 3 4 A
Page 45 and 46: STEERING, FRONT AND REAR SUSPENSION
Page 55 and 56: ITEM PART NO. DESCRIPTION 1 2 3 4 R
Page 57 and 58: ELECTRICAL SYSTEM - GASOLINE VEHICL
Page 59 and 60: ITEM PART NO. DESCRIPTION 1 2 3 4 W
Page 61 and 62: ITEM PART NO. DESCRIPTION FORWARD/R
Page 63 and 64: ELECTRICAL COMPONENT BOX - GASOLINE
Page 65 and 66: ITEM PART NO. DESCRIPTION ELECTRICA
Page 73 and 74: FE290 ENGINE 7 G E
Page 75 and 76: ITEM PART NO. DESCRIPTION FE290 ENG
Page 83 and 84: ITEM PART NO. DESCRIPTION FE290 ENG
Page 85 and 86:
FE290 ENGINE - CRANKCASE AND CRANKS
Page 87 and 88:
ITEM PART NO. DESCRIPTION 1 2 3 4 E
Page 89 and 90:
FUEL, INTAKE, AND GOVERNOR SYSTEMS
Page 91 and 92:
ITEM PART NO. DESCRIPTION 1 2 3 4 F
Page 93 and 94:
ITEM PART NO. DESCRIPTION 1 2 3 4 C
Page 95 and 96:
Page 97 and 98:
ITEM PART NO. DESCRIPTION GOVERNOR
Page 99 and 100:
INTAKE DUCT, CHOKE, AND AIR BOX ASS
Page 101 and 102:
EXHAUST SYSTEM 9 G E
Page 103 and 104:
ITEM PART NO. DESCRIPTION 1 2 3 4 E
Page 105 and 106:
TORQUE CONVERTER 10 G E
Page 107 and 108:
ITEM PART NO. DESCRIPTION 1 2 3 4 D
Page 109 and 110:
ITEM PART NO. DESCRIPTION 1 2 3 4 D
Page 111 and 112:
UNITIZED TRANSAXLE 11 G E
Page 113 and 114:
UNITIZED TRANSAXLE - GEAR CASES AND
Page 115 and 116:
ITEM PART NO. DESCRIPTION UNITIZED
Page 117 and 118:
UNITIZED TRANSAXLE - DIFFERENTIAL A
Page 119 and 120:
ELECTRICAL SYSTEM - ELECTRIC VEHICL
Page 121 and 122:
ITEM PART NO. DESCRIPTION ELECTRICA
Page 123 and 124:
ITEM PART NO. DESCRIPTION 1 2 3 4 W
Page 125 and 126:
Page 127 and 128:
ITEM PART NO. DESCRIPTION WIPER SWI
Page 129 and 130:
ITEM PART NO. DESCRIPTION 1 2 3 4 R
Page 131 and 132:
BATTERIES, CHARGER RECEPTACLE, SOLE
Page 133 and 134:
Page 135 and 136:
ITEM PART NO. DESCRIPTION 1 2 3 4 B
Page 137 and 138:
ITEM PART NO. DESCRIPTION COMPUTER,
Page 139 and 140:
MULTI-STEP POTENTIOMETER - POWERDRI
Page 141 and 142:
MOTOR CONTROLLER OUTPUT REGULATOR (
Page 143 and 144:
ITEM PART NO. DESCRIPTION WIRING -
Page 145 and 146:
WIRING - POWERDRIVE SYSTEM 48 VEHIC
Page 147 and 148:
ITEM PART NO. DESCRIPTION 1 2 3 4 W
Page 149 and 150:
WIRING - POWERDRIVE PLUS VEHICLE WI
Page 151 and 152:
FORWARD/REVERSE SWITCH, TOW/RUN SWI
Page 153 and 154:
Page 155 and 156:
SOLENOIDS, ENERGY DISPLACEMENT MODU
Page 157 and 158:
Page 159 and 160:
WIRING - IQ SYSTEM VEHICLE WITH MOT
Page 161 and 162:
FORWARD/REVERSE SWITCH, TOW/RUN SWI
Page 163 and 164:
Page 165 and 166:
ITEM PART NO. DESCRIPTION COMPUTER,
Page 167 and 168:
BATTERY CHARGER 13 G E
Page 169 and 170:
ITEM PART NO. DESCRIPTION 1 2 3 4 A
Page 171 and 172:
ACCU-POWER CHARGER, EXPORT, 230-VOL
Page 173 and 174:
ACCU-POWER CHARGER, EXPORT, 100-VOL
Page 175 and 176:
ITEM PART NO. DESCRIPTION 1 2 3 4 P
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
Page 183 and 184:
ELECTRIC MOTOR 14 G E
Page 185 and 186:
ITEM PART NO. DESCRIPTION 1 2 3 4 M
Page 187 and 188:
ITEM PART NO. DESCRIPTION MOTOR - P
Page 189 and 190:
Page 191 and 192:
Page 193 and 194:
TRANSAXLE - ELECTRIC VEHICLE 15 G E
Page 195 and 196:
ITEM PART NO. DESCRIPTION TRANSAXLE
Page 197 and 198:
ITEM PART NO. DESCRIPTION TRANSAXLE
Page 199 and 200:
MAINTENANCE AND SERVICE TOOLS 16 G
Page 201 and 202:
Page 203 and 204:
MAINTENANCE AND SERVICE TOOLS, CONT
Page 205 and 206:
MAINTENANCE AND SERVICE TOOLS, CONT
Page 207 and 208:
INDEX Part Number and Page 183 8-11
Page 209 and 210:
INDEX 1014453 10-3 1014454 10-5 101
Page 211 and 212:
INDEX 101696206 1-9 101696208 1-7 1
Page 213 and 214:
INDEX 101928001 11-5 101928101 11-5
Page 215 and 216:
INDEX belt, drive 10-3, 10-5 belt,
Page 217 and 218:
INDEX G gasket carburetor insulator
Page 219 and 220:
INDEX magnetic 15-3 spark 7-5 plug
Page 221 and 222:
INDEX U u-bolt 5-11 unitized transa
Page 228:
Golf Cars Club Car Inc. P.O. Box 20
show all

2001-2002 DS - Mobilicab

Create successful ePaper yourself

Delete template?

Save as template?