GhubrahIncidentInves.. - authority for electricity regulation, oman

More documents

Recommendations

Info

Report Number: R 8991 Issue: 1.1 Executive Summary A serious incident occurred at Al Ghubrah Power and Desalination Plant, Muscat, on 9 th May 2006, which resulted in fatal injuries to two Sogex employees whilst performing maintenance activities on the Phase 3 ‘D’ Hypochlorite storage cylinder. Following the incident the AER requested Advantica to visit the site of the incident to carry out a site inspection and to conduct an evaluation of the probable cause of the incident. The Advantica visit took place on 10 th May 2006. A verbal debriefing was conducted at the AER offices with the Executive Director, and a document was prepared for issue to all sites following the initial site survey and inspections, which stated that no further work should be carried out on the Hypochlorite cylinders. The timetable for the issue of this report was also discussed during the debriefing. The principle cause of the incident at Al Ghubrah was a systemic failure of the Permit to Work (PTW) system. ‘Hot’ work involving the use of electrical tools to repair a section of the cylinder structure was allowed to take place under a work order which referenced a ‘cold’ PTW. The ‘cold’ permit had been raised previously to cover painting activities, and stated that no isolations, draining or venting were required. The subsequent cylinder repair work should have been the subject of a proper Risk Assessment which would have identified the need for the work to be carried out under a ‘hot’ PTW with suitable gas detection and other safety precautions, including necessary isolations and proper venting. The source of ignition was in all probability the use of an electric drill (not fit for purpose - drill brushes causing sparks in hazardous area, electrical connections badly made etc.) in proximity to ‘D’ cylinder vent (not isolated and in service at the time). There were no job-specific fire precautions (i.e. Portable fire extinguishers) in place. A new rigorous PTW system is required urgently for the Al Ghubrah site. Risk Assessments should be carried out prior to all activities. The safety department should be involved at all stages of an activity. Scaffolding construction and inspection standards should be reviewed as soon as possible. Although not a direct contributory factor to the incident, the poor standards observed could be a danger to health and safety in their own right. Page i
Report Number: R 8991 Issue: 1.1 Project Code: AER May 2006 Distribution Name Company John Cunneen Authority for Electricity Regulation (AER), Oman Document Authorisation Name Signature Date Author (s) Reviewers QA John Martin Sikobe Litaba Rebecca Gavin Ian Mather Authorisation Sikobe Litaba Page ii
Page 1: R 8991 15 May 2006 REPORT ON INVEST
Page 5 and 6: Report Number: R 8991 Issue: 1.1 1
Page 11 and 12: Report Number: R 8991 Issue: 1.1 AP

GhubrahIncidentInves.. - authority for electricity regulation, oman

Create successful ePaper yourself

Delete template?

Save as template?