GENERATOR SELECTION CONTENTS - Diesel Generator

More documents

Recommendations

Info

1. Basic Data A C <strong>GENERATOR</strong> <strong>SELECTION</strong> - CHECK LIST SECTION 4303 January, 1990 Page 1 ¨ Voltage Designation HC, UC, MHC, etc ¨ Phase Bearings One/Two ¨ Frequency Control System 3/4/5/6 ¨ Speed Poles 2/4/6 ¨ Site kVA ¨ Site kW ¨ Power Factor 2. Build Type and Accessories ¨ Parallel Droop Kit ¨ Three Phase Sensing ¨ RFI Filter Kit ¨ Anti-condensation Heaters and Voltage ¨ IP23 Enclosure ¨ Air Inlet Filters ¨ Shaft Standard/Special/2nd Extension ¨ Coupling or Adaptor Type ¨ Winding Ends Out ¨ C.S.A. Approval ¨ Other Approval (specify) Refer to Factory ¨ Official/Special Inspection ¨ Special Testing Refer to Factory ¨ Belt drive Check side load ¨ Vertical Mounting - special bearings Refer to Factory ¨ AVR Type ¨ Special Nameplate Refer to Factory ¨ Special Foot Mounting Refer to Factory ¨ Manual Voltage Regulator ¨ Over Voltage Protection ¨ Frequency Detection Module ¨ VAR/PF Controller ¨ Alternator Protection Module ¨ Excitation Loss Module ¨ Diode Failure Detector
3. Rating Adjustments ¨ Derate for High Ambient Temperature Section 4401 ¨ Derate for High Altitude Section 4411 ¨ Derate for Temperature Rise Restriction ¨ Derate for Lagging Power Factor Below 0.8 ¨ Derate for Leading Power Factor Refer to Factory ¨ Derate for Maximum Overload Condition ¨ Derate for Maximum Voltage Dip Restriction ¨ Derate for High Sustained Short Circuit Current Requirement ¨ Derate and/or Special Build for Thyristor Type Load ¨ Allowance for Future Growth ¨ Derate for Voltages Higher than Normal Top Limit of Winding Refer to Factory ¨ Derate for Voltages Lower than Normal Bottom Limit of Winding Refer to Factory ¨ Allowance for Standby Duty only ¨ Derate for Unbalanced Load Regulation ¨ Final Steady State Machine Rating kW ¨ Final Resultant Power Factor ¨ Final Required kVA for Transient Performance ¨ Final Required kVA for Short Circuit Performance ¨ Frame Size Selection based on limited Rating 4. Typical Test Data The following typical test figures are normally available on request:- ¨ Open Circuit and Short Circuit magnetisation Curve ¨ Regulation, Phase Sequence, Insulation Resistance and Megger ¨ Heat Run ¨ Efficiency Curves ¨ Efficiency - by Summation of Losses ¨ Waveform Analysis (Distortion, Deviation, T.I.F., T.H.F., Photograph) SECTION 4303 January 1990 Page 2
Page 1 and 2: GENERATOR SELECTION SECTION 4 Janua
Page 3 and 4: SECTION DRAWING SINGLE BEARING WITH
Page 5 and 6: SECTION 4111 January, 1990 Page 2 C
Page 7 and 8: SECTION 4111 January 1990 Page 4 Op
Page 9 and 10: SECTION 4111 January, 1990 Page 6 P
Page 11 and 12: SECTION 4111 January, 1990 Page 8 T
Page 13 and 14: Figure 2 Curve (1) machine characte
Page 15 and 16: Introduction OPERATING PRINCIPLES S
Page 17 and 18: SECTION 4131 January, 1990 Page 3 S
Page 19 and 20: A.C. GENERATOR STANDARDS SECTION 43
Page 24 and 25: POWER RATING SECTION 4311 January,
Page 26 and 27: TEMPERATURE AND TRANSIENT PERFORMAN
Page 28 and 29: CONTROL SYSTEM Stamford a.c. genera
Page 30 and 31: ALTITUDE SECTION 4411 January, 1990
Page 32 and 33: CLIMATE AND ENVIRONMENT SECTION 443
Page 34 and 35: SECTION 4501 January, 1990 Page 2 I
Page 36 and 37: SECTION 4511 January, 1990 Page 2 T
Page 38 and 39: CONSTANT OR STEAD STATE LOADS - SIN
Page 40 and 41: SECTION 4521 January 1990 Page 2 Be
Page 42 and 43: SECTION 4522 January 1990 Page 4 Wh
Page 44 and 45: Since I = kW genr. and I M = kW M _
Page 46 and 47: EXAMPLES OF SELECTION FOR VARIOUS L
Page 48 and 49: LOAD (e) - 3 x 3 h.p. 3 phase motor
Page 50 and 51: SECTION 4595 January 1990 Page 5 In
Page 52 and 53: POWER FACTOR CORRECTION SECTION 459
Page 54 and 55: Example Two - from an actual enquir
Page 56 and 57: Example Three To illustrate motor s
Page 58 and 59: FOREWORD ROTATING DIODE PROTECTION
Page 60 and 61: SECTION 4901 January 1990 Page 3
Page 62 and 63: 1. INTRODUCTION AND THEORY PARALLEL
Page 64 and 65: SECTION 4902 January 1990 Page 3 On
Page 66 and 67: SETTING THE DROOP CIRCUIT SECTION 4
Page 68 and 69: 4. WORKING PROCEDURE SECTION 4902 J
Page 70 and 71: 1. INTRODUCTION THREE PHASE SHORT C
Page 72 and 73:
4. SHORT CIRCUIT CURRENT DECREMENT
Page 74 and 75:
CONTROL FOR GENERATORS IN PARALLEL
Page 76 and 77:
SECTION 4951 January 1990 Page 3 Ma
Page 78 and 79:
SECTION 4952 January 1990 Page 2 Se
Page 80 and 81:
SECTION 4953 January 1990 Page 1 VO
Page 82 and 83:
SECTION 4953 January 1990 Page 3 4)
Page 84:
SECTION 4953 January 1990 Page 5 3)
show all

GENERATOR SELECTION CONTENTS - Diesel Generator

Create successful ePaper yourself

Delete template?

Save as template?