Genset operation and service manual - Under-Slung ... - Florens

More documents

Recommendations

Info

OPERATION AND SERVICE MANUAL DIESEL DRIVEN GENERATOR SET MODEL 69UG15 Carrier Transicold A member of the United Technologies Corporation family. Stock symbol UTX. Carrier Transicold, Carrier Corporation, P.O. Box 4805, Syracuse, N.Y. 13221 U. S. A. © 2002Carrier Corporation D Printed in U. S. A. 0602
SAFETY SUMMARY GENERAL SAFETY NOTICES The following general safety notices supplement the specific warnings and cautions appearing elsewhere in this manual. They are recommended precautions that must be understood and applied during operation and maintenance of the equipment covered herein. The general safety notices are presented in the following three sections labeled: First Aid, Operating Precautions and Maintenance Precautions. A listing of the specific warnings and cautions appearing elsewhere in the manual follows the general safety notices. FIRST AID An injury, no matter how slight, should never go unattended. Always obtain first aid or medical attention immediately. OPERATING PRECAUTIONS Always wear safety glasses and hearing protection. Keep hands, clothing and tools clear of the radiator fan and rotating belts. No work should be performed on the unit until all circuit breakers and start-stop switches are turned off and the negative battery terminal has been disconnected.. Always work in pairs. Never work on the equipment alone. In case of severe vibration or unusual noise, stop the unit and investigate. MAINTENANCE PRECAUTIONS Be sure power is turned off and the negative battery cable is disconnected before working on generator set. Do not bypass any electrical safety devices, e.g. bridging an overload, or using any sort of jumper wires. Problems with the system should be diagnosed, and any necessary repairs performed, by qualified service personnel. In case of electrical fire, open circuit switch and extinguish with CO 2 (never use water). Fuel Tanks present explosion, fire and rupture hazards even if liquid fuel has been drained. Do not attempt any repairs, especially repairs using flame, welder or torch, unless you haveen properly trained and the tank has been emptied of liquid fuel and fuel vapors and the tank is properly ventilated. UNIT LABEL IDENTIFICATION To help identify the hazard labels on the Unit and explain the level of awareness each one carries, explanations with appropriate consequences are provided below: DANGER -- indicates an immediate hazard which WILL result in severe personal injury or death. WARNING -- indicates hazards or unsafe conditions which COULD result in severe personal injury or death. CAUTION --indicates potential hazards or unsafe practices which COULD result in minor personal injury, product or property damage. SPECIFIC WARNING AND CAUTION STATEMENTS The statements that follow are applicable to the generator set and appear elsewhere in this manual. These recommended precautions must be understood and applied during operation and maintenance of the equipment covered herein. WARNING Do not use gasoline to clean air cleaner parts. WARNING Beware of moving V-belt, belt driven components and hot exhaust components. WARNING Under no circumstances should ether or any other unauthorized starting aids be used in conjunction with the glow plugs. Safety--i T-266
Page 1: Carrier Transicold Diesel Driven Ge
Page 5 and 6: TABLE OF CONTENTS PARAGRAPH NUMBER
Page 7 and 8: LIST OF ILLUSTRATIONS FIGURE NUMBER
Page 9 and 10: Table 1-1. Model Chart - Continued
Page 11 and 12: 3 2 4 5 1 14 13 12 11 10 9 8 7 6 14
Page 13 and 14: 1.3 ENGINE The engine is a vertical
Page 15 and 16: The alternator converts mechanical
Page 17 and 18: The engine, engine control devices
Page 19 and 20: SECTION 2 OPERATION 2.1 GENERATOR S
Page 21 and 22: 2.3 STARTING AND STOPPING INSTRUCTI
Page 23 and 24: 3.1 DIESEL ENGINE CONDITION 3.1.1 E
Page 25 and 26: CONDITION 3.2 BATTERY CHARGING ALTE
Page 27 and 28: SECTION 4 SERVICE AND PREVENTIVE MA
Page 29 and 30: Table 4-1 Preventative Maintenance
Page 31 and 32: manner. Remove the inner cup from t
Page 33 and 34: . Winding Insulation Testing Contin
Page 35 and 36: 6. Remove chains from the lift eyes
Page 37 and 38: + BATTERY B VOLTS AC TAP (TACH.) GR
Page 39 and 40: 4.7.7 Alternator Installation a. Ma
Page 41 and 42: SECTION 5 SCHEMATICS 5.1 INTRODUCTI
Page 43 and 44: BATTERY CHARGER OPTION CB5 or F ALT
Page 45 and 46: Figure 5-4 Schematic Diagram 230 Vo
Page 47 and 48: ALTERNATOR OPTION RED OR WHITE OR B
Page 49 and 50: GENERATOR CB4 CIRCUIT BREAKER R1 RE
Page 51: INDEX - Continued S T SAFETY DEVICE

Genset operation and service manual - Under-Slung ... - Florens

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?