HE, HEII and VHE Section and Base Assembly - Weil-McLain

GASHE, HEII and VHE Section and Base Assembly68 Discontinued Service Parts

HE, HEII and VHE Section and Base AssemblyGASParts not listed below are obsolete and no longer available. Parts listed below may become obsolete.Call Customer Service for part availability.Fig. No. Part No. Description Series No.D 592-800-011 2" Square Cut Seal (2 per joint) 1-3E560-234-500 7/16" Tie Rod without Nut: (9") (3 per boiler) 1-3560-234-501 7/16" Tie Rod without Nut: (12") (3 per boiler) 1-3560-234-502 7/16" Tie Rod without Nut: (15") (3 per boiler) 1-3560-234-503 7/16" Tie Rod without Nut: (18“) (3 per boiler) 1-3G 562-248-684 7/16" Washer (1 per Tie Rod) 1-3J3591-638-850Silicone Sealant for Cleanout Plate-RTV 700 or equivalent: (10.3 oz.)Base Side Panel (2 per Boiler)450-030-644 Base Access Panel: (HSI Only)- HE/VHE/HEII-3 3450-030-645 Base Access Panel: (HSI Only)- HE/VHE/HEII-4 3450-030-646 Base Access Panel: (HSI Only)- HE/VHE/HEII-5 3450-030-647 Base Access Panel: (HSI Only)- HE/VHE/HEII-6 3J4 450-030-475 Base Pan Angle-left hand 1-3J5 450-030-474 Base Pan Angle-right hand 1-3M 590-424-252 Leg Assembly (Includes: Leg, Nuts and Washer) 1-3O560-528-992 Main Burner Orifice: (Natural Gas): 2.0mm-7/16" Hex-1/8" NPT 1-3560-529-052 Main Burner Orifice: (Propane Gas): 1.25mm-7/16" Hex-1/8" NPT 1-3512-200-035 Burner, Aluminized: (1.00" OD x15.00" Long) 1-3512-200-045Burner, Aluminum with Pilot Bracket - (HE/VHE Cycle Pilot SystemOnly)591-632-612 Waterglass (4 oz Bottle) 1-3591-602-914 Boiler Cement (1 Can)=(1/2 Gallon) 1-3591-638-851 Silicone Sealant (RTV 700 or Equivalent) (3 oz) 1-3Note: Number of burners for HE/VHE/HEII Boilers:HE/VHE/HEII-3-(4 main burners),HE/VHE/HEII-4-(6 main burners),HE/VHE/HEII-5-(8 main burners),HE/VHE/HEII-6-(10 main burners).For Cycle Pilot HE/VHE Boilers subtract one main burner, and add one pilot burner to each above.Boiler Cement Quantities Required:HEII-3-(1 Can),HEII-4-(2 Cans),HEII-5-(3 Cans),HEII-6-(4 Cans),1 Can Equals ½ Gallon (Used For Base Front and Back Cross Ties on HEII)1-31-3Discontinued Service Parts 69

GASHE, HEII and VHE Hot Surface Ignition6White-Rodgers 36C74-215White-Rodgers 36C74-22770 Discontinued Service Parts

HE, HEII and VHE Hot Surface IgnitionGASFig.No.PartNo.1 510-811-6551 510-811-6562 510-811-5022 382-200-4483 382-930-216DescriptionMfr.Combination Gas Valve Control For Natural GasCombination Gas Control Valve Kit (step opening, 0.9"W.C. low fire to 3.5" W.C. high fire, 1/2" x 1/2" N.P.T. 24Volt, Natural Gas)Combination Gas Valve Control For Propane GasCombination Gas Control Valve Kit (step opening, 3.0"W.C. low fire to 10.0" W.C. high fire, 1/2" x 1/2" N.P.T.24 Volt, Propane Gas)Mfr.’s PartNo.ModelWhite Rodgers 36C74-913 ALLWhite Rodgers 36C74-227 ALLGas Control Components For Natural Gas And Propane GasCombination Ignition-Sensing Control Module, 24 Volt,(lock-out after 3 ignition trials)Intergrated Boiler Control Module, 24 Volt, (lock-outafter 3 ignition trials)Norton 201 to 201N Conversion Kit - Used only withHoneywell & Fenwall Controls - (Igniter, Bracket, SenseRod)White Rodgers 50E47-871UnitedTechnologiesCaddoConnections Inc.511-330-182 Sapco Fame Sensor - Comes with Kit # 382-930-216 Sapco511-330-1844 511-330-1485 511-330-192Norton 201N (Igniter only) - with Lead Wires andConnector used with White RodgersIgniter Replacement Kit - (Includes Igniter and Shieldused with United Technologies) - HE II OnlyMain Fame Sensor, used with White Rodgers Control #50E47-871CaddoConnections Inc.HE/VHE1013-200 HE IIHE/VHEHE/VHEHE/VHENorton MB478687 HE IIWhite Rodgers450-030-655 Igniter Bracket, Boilers with - 201N Igniter (HSI ) only Weil-McLain760-802-HSI450-030-653 Igniter Bracket, Boilers with - 271N Igniter Weil-McLain HE II450-030-642 Igniter Shield, Boilers with HSI Only Weil-McLain ALL6 591-391-8197 591-391-7868 591-391-808Wiring Harness - Module to Igniter - Gold ControlModule OnlyWiring Harness - Module to Controls Gold ControlModule OnlyWiring Harness - Module to Igniter - White RodgersModule Only9 591-391-788 Wiring Harness - Gold Control Module to Junction Box591-391-784Wiring Harness - Gold Control Module to Inducer(4-Pin Molex Plug)Weil-McLainCaddoConnections Inc.CaddoConnections Inc.CaddoConnections Inc.CaddoConnections Inc.HE/VHEHE/VHEHE IIHE IIHE/VHEHE IIDiscontinued Service Parts 71

GASHE, HEII and VHE Hot Surface Ignition1213Fig.No.PartNo.510-811-480510-811-48512 382-200-45113 382-200-449382-200-450382-200-448DescriptionMfr.Conversion Kits: Natural to Propane, Propane to NaturalConversion Kit – Natural Gas to Propane Gas(HSI only) - (Includes: Gas Valve, Orifices andinstructions)Conversion Kit – Propane Gas to Natural Gas(HSI only) - (Includes: Gas Valve, Orifices andinstructions)Conversion Kits: Control SystemsConversion Kit – From Honeywell, Fenwall, WhiteRodgers HSI to Gold Control SI - (Includes: Module,Wiring, Transformer, Igniter, hardware and instructions)Complete Conversion Kit From Cycle Pilot System toGold Control HSI (Natural Gas) - (Includes: Module,Gas Valve, Wiring, hardware and instructions)Complete Conversion Kit From Cycle Pilot System toGold Control HSI (Propane Gas) - (Includes: Module,Gas Valve, Wiring, hardware and instructions)Conversion Kit From Honeywell S9301A or GoldControl 1013 -100 to Gold Control 1013-200 -(Includes: Module, Wiring and instructions)Weil-McLainWeil-McLainWeil-McLainWeil-McLainWeil-McLainWeil-McLainMfr.’s PartNo.ModelALLALLHE/VHEHE/VHEHE/VHEHE II72 Discontinued Service Parts

HE, HEII and VHE Blower AssemblyGAS101131228Fig.No.PartNo.2 510-312-3123 510-312-322510-312-317510-312-279699-999-022699-999-036699-999-024699-999-03410 510-312-166Description Mfr. Mfr.’s Part No.Blower Assembly (Includes: Mounting Plate,Hardware, Motor and Wheel) - All BoilersBlower Wheel (galvanized Steel, 5.75" diameter,5/16" shaft)Blower Assembly (Includes: Mounting Plate,Hardware, Motor and Wheel) - All BoilersBlower Wheel (stainless steel, 5.72" diameter,5/16 shaft)Starter/Termination Kit (Includes: Starter Tee,Termination Coupling, Sealant and instructions)(Saf-T- Vent Only).Starter/Termination Kit (Includes: Starter Tee,Termination Coupling, Sealant and instructions)(Z- Vent Only).Starter/Termination Kit (Includes: Starter Tee,Termination Coupling, Sealant and instructions)(Saf-T- Vent Only).Starter/Termination Kit (Includes: Starter Tee,Termination Coupling, Sealant and instructions)(Z- Vent Only).Electrical ComponentsCombination Transformer-Relay Receptacle,120/24 Volt, 40 VABoilerModelWeil-McLain (See Note) HE/HE-IIRevcor Inc. B575-212S HE/HE IIWeil-McLain (See Note) VHESheridanManufacturing ofOhioWeil-McLainWeil-McLainWeil-McLainWeil-McLainS57-20CCWVHEHE/VHEHE/VHEHE IIHE IIWhite Rodgers S84A-85 HE/VHEHoneywell R8285K-1004 HE/VHEProductsUnlimited57-01E07C5F23 HE/VHE11 510-350-223 Plug In Relay, DPST, 24 Volt Holding Coil Honeywell R822U1006 HE/VHE510-312-167 Complete Transformer and Relay Honeywell R8285D1000 HE/VHE10 511-842-370 24 Volt Step Down Transformer, 40 VA Honeywell AT140B1297 HE II512-050-230 Fuse Thermal Roll-Out, 228°C Elmwood Sensor RD226-001 ALLNote: Original draft inducer motor was Fasco # 7121-5750,Currently using Fsco # 7162-1335.Discontinued Service Parts 73

Section Newscontinued from page 8Heather HilliardRebecca GorringIn other business at the awards luncheon, attendees heardupdates on Lunch and Learns and the Mentor program, and ideasfor future events. It was a valuable exercise for the new leads inattendance to gain insight and become familiar with the functioningof the MTS YP Committee before the Quarterly LeadsMeeting that was held later in August and hosted by Universal-Pegasus International.The group’s third quarter Lunch and Learn was hosted byChristian Fenger and Hempel. The agenda went over coatings ingeneral, generic types and why corrosion protection is importantin the offshore oil and gas business. The next Lunch and Learnwill be October 7 at Oil States Industries, an MTS member.YP group members showed their support for the Houston SectionGolf Tournament by donating MTS YP logo pens and MTS YP shirtsto the auction.Puget SoundThe annual BBQ and Summer Social was held in June on theRV Golden Dolphin. Hosted by Ross Laboratories, the event wassponsored by the Puget Sound Section, the Hydro Society ofAmerica and the Oceanic Engineering Society of IEEE. Chair:Fritz Stahr, stahr@uw.eduSan DiegoThe section welcomes new leadership. Thenew chair is Scott Mau, a research fisheriesbiologist with the Southwest FisheriesScience Center of the NOAA National MarineFisheries Center. He replaces BarbaraFletcher. Mau uses ROVs for his fisheriesresearch on rockfish and abalone. He hasbeen active in section leadership for manyScott Mauyears, helping to run the section-sponsoredMATE regional ROV competition, as a supporter of the section’sstudent intern program and as section vice-chair. “As chairI am looking forward to being a part of the great things oursection will be doing this year.” The new vice-chair is DavidVelasco, the general manager for Brazil at MTS member SonTek/YSI. Velasco moves to the vice-chair position from that of secretary.Stan Logan, customer service manager at MTS memberTeledyne Impulse, took on the job of secretary and previouslywas a section councilor for three years. Beth Berkley with MTSmember SeaBotix will continue as treasurer.In June, 70 people gathered for the annual Corporate AppreciationDinner to thank the section’s corporate members. Theevent also recognizes those who have served on committees, aswell as any departing and newly elected section officers. Raffleprizes were donated by Sidus Solutions, SeaBotix, SonTek/YSI,and Teledyne RDI, who were all present at the dinner. Winners ofthe local science fair, which the section supports, were also onhand. The top science fair winner in the senior division, PrithviUndavalli, won $1,000 for “Encrypted Parallel FM Transmissionwith Arduino Chipsets.” The section awarded lesser amounts tosecond and third place winners, and the top three projects in ajunior category. Some other winning topics were “DNA Barcodingof Invasive Species in the San Diego Bay” and “OTC Medicationsare Affecting Aquatic Life.” “Recognizing the science fair winnersand having them each give a brief presentation of their project isone of the highlights of the evening,” noted Logan. Chair: ScottMau, scott.mau@noaa.gov nWelcome New MembersCaliforniaKelsey R. AndersonAmanda CarrollMatthew D. McCauleyJustin R. PeglowTania M. SoaresChris WelshColoradoBenjamin S. LaroPerry WischowFloridaAllie R. CribbsEllen PragerPatrick RiceMatt YoungHawaiiLeighton ChongDaniel MerrittIllinoisNikala GigliottiIndianaRichard BoyDaniel P. GallagherBrian KavalarPatrick McCammonRichard J. PentimontiAndrew ShulmanMichael TownsendLouisianaRonnie GrizzaffiAngie HombMassachusettsSusan AveryJeff DusekMarylandAmber D. ButlerMaineGary MorettiMichiganKarl GustAlexis J. OesterleNorth CarolinaRyan L. GlennReny B. TysonNew HampshireCB LawlerNew YorkKaelyn LynchOregonKristin BeemTexasWade AbadieGeorge AristizabalBrian T. AshWilliam BarnettCraig BatemanBonnie BattonJohn BenckensteinMark CanadaSimon CooperChristel FrantzMatthew GonzalesPhilip GrossweilerDavid HaThomas “Trey” HallAudun HaugeBryan HuttonBrett JohnsonKevin M. KulishGuy MirroWesley LangstonJames M. PappasIsrael PerezTony RandellLisa RobinsonDavid RokohlRick SeabrookAndy SchusterMike ShawEric SonneTony YacobVirginiaJose L. BlancoDennis EganKatelyn JenkinsScott MoweryJoseph PerryMarc SteinerWashingtonM. Elizabeth ClarkeAmanda GrayPeter W. HavensJohn KnappDavid L. MartinBritish Columbia, CanadaPavel HaintzNewfoundland andLabrador, CanadaNeil GallDennis HoganDarrell O’NeillShelley PettenSharon TillerBrian WadeOntario, CanadaJim LotimerJapanNatheer AlabsiNorwayOlav EgelandØyvind N. SmogeliCurrents S E P T E M B E R / O C T O B E R 2 0 1 0

HE, HEII and VHE Water TrimGASFig.No.PartNo.7 381-354-5257 381-354-526Description1" Universal Circulator Hardware Kit (Includes: Screws, Nuts, (1)Flange and (1) Gasket)1 1/4" Universal Circulator Hardware Kit (Includes: Screws, Nuts,(1) Flange and (1) Gasket)ADDITIONAL WATER TRIM COMPONENTSMfr.Weil-McLainWeil-McLainMfr.’s PartNo.8 510-148-567 Automatic Air Vent, float type, 1/8" N.P.T. Taco 400-3561-013-849 Reducing Coupling, ½" X 1/8" N.P.T. for Taco Air Vent Weil-McLain9 510-632-088 Fill-Trol Diaphragm Expansion Tank with O-Ring – (tank only) Am-Trol 1099 510-632-089 Fill-Trol Diaphragm Expansion Tank with O-Ring – (tank only) Am-Trol 11010 511-210-434Fill Valve Angle Style-90 with Built-in Strainer, Pressure Reducer,Check Valve requires user provided shut-off valveConbraco 65-006-95Discontinued Service Parts 75

GASHE, HEII and VHE Pressure Switches567Fig. No.56PartNo.511-624-541511-624-545511-624-544511-624-510511-624-511511-624-512511-624-511511-624-512511-624-513511-624-549511-624-548511-624-541511-624-545511-624-514511-624-548511-624-541590-317-6307 590-317-631Description Mfr. Mfr.’s Part No. ModelPressure Differential Switch, SPDT, 1.05"setting, 0 – 4000' ft elevationPressure Differential Switch, SPDT, 0.95"setting, 4000 – 8000' ft elevationPressure Differential Switch, SPDT, 0.85"setting, 8000 – 12000' ft elevationPressure Differential Switch, SPDT, 1.00"setting, 0 – 4000' ft elevationPressure Differential Switch, SPDT, 0.90"setting, 4000 – 8000' ft elevationPressure Differential Switch, SPDT, 0.80"setting, 8000 – 12000' ft elevationPressure Differential Switch, SPDT, 0.90"setting, 0 - 4000' ft elevationPressure Differential Switch, SPDT, 0.80"setting, 4000 - 8000' ft elevationPressure Differential Switch, SPDT, 0.70"setting, 8000 – 12000' ft elevationPressure Differential Switch, SPDT, 1.47"setting, 0 - 4000' ft elevationPressure Differential Switch, SPDT, 1.15"setting, 0 - 4000' ft elevationPressure Differential Switch, SPDT, 1.05"setting, 4000 - 8000' ft elevationPressure Differential Switch, SPDT, 0.95"setting, 8000 - 12000' ft elevationPressure Differential Switch, SPDT, 1.26"setting, 0 - 4000' ft elevationPressure Differential Switch, SPDT, 1.15"setting, 4000 - 8000' ft elevationPressure Differential Switch, SPDT, 1.05"setting, 8000 - 12000' ft elevationPressure Differential Switch Tubing,1/8"I.D. X 12" long, whitePressure Differential Switch Tubing,1/8"I.D. X 12" long, redHoneywellHoneywellHoneywellHoneywellHoneywellHoneywellHoneywellHoneywellHoneywellIS20298-5449IS20298-5512IS20298-5511IS20298-5452IS20298-5453IS20298-5513IS20298-5453IS20298-5513IS20298-5514HE-Series1&2-(ALL)HE-Series2-(ALL)HE-Series2-(ALL)HE-Series 3,HE-II –Sizes (3,4,5)HE-Series 3,HE-II –Sizes (3,4,5)HE-Series 3,HE-II –Sizes (3,4,5)HE-Series 3,HE-II –Size (6)HE-Series 3,HE-II –Size (6)HE-Series 3,HE-II –Size (6)Honeywell IS20298-5515 VHE–Series 1(ALL)Honeywell IS20298-5450 VHE–Series 2(ALL)Honeywell IS20298-5449 VHE–Series 2(ALL)Honeywell IS20298-5512 VHE–Series 2(ALL)Honeywell IS20298-5451 VHE–Series 3(ALL)Honeywell IS20298-5450 VHE–Series 3(ALL)Honeywell IS20298-5449 VHE–Series 3(ALL)ManufacturersRubber SupplyManufacturersRubber SupplyHE/VHE/HE-IIHE/VHE/HE-II76 Discontinued Service Parts