MAXI SKY 1000 ® CEILING LIFT SYSTEM

Handling and StorageAvoid violent shock during transportation.The lift should not remain stored fmore than twomonths without recharging the batteries.If you store or ship the MAXI SKY 1000 lift, turnthe power off (green light off).Battery ReplacementARJO uses sealed lead-acid batteries. Contraryto nickel-cadmium, ARJO batteries do not haveany memory effect. Therefore, batteries shouldnot be completely discharged before recharge.Replace the battery when there is a noticeablereduction in the number of transfers that can beperformed between charges. If you notice theMAXI SKY 1000 lift beeping and a red lightflashing, see the instructions inTroubleshooting to ensure it is a problem withthe battery.To replace a battery, contact your local dealer orrepresentative.DO NOT ATTEMPT TO USE ABATTERY NOT AUTHORIZED BYARJO.ARJO batteries are specially designed forARJO charging systems. Attempting touse an unauthorized battery mayseriously damage the lift and/or thecharger.MAINTENANCEsufficient degree may lead to deterioration orextreme softening of the webbing, which couldlead to the fibres being rubbed off (almost aspowder in extreme cases). It is best to avoidfumes, spray or mists of acid and alkalis ororganic solvents. If contamination is suspected,wash out well in warm water. Avoid contact withexcessive heat, which is likely to affect theproduct.CleaningCertain chemical substances mentioned abovemay be removed with heavy duty cleaner dilutedin warm water. Ensure that any cleaning agentsare removed by rinsing thoroughly in warmwater, maximum 60°C (140°F).For normal washing and cleaning, follow the careinstructions on the label of the product.StorageSlings should be stored away from directsunlight, stress, pressure, excessive heat orhumidity. The sling should be kept away fromcontact with sharp objects, corrosives or otherpossible damaging material.1. Check for any sign of wear on sling straps asdescribed above and at the strap-slingjunction. Buckles on certain slings should bechecked to ensure that the locking/unlockingmechanism opens and closes easily and issecure when locked.Verification of Charger Power SourceIf the light does not illuminate when there arebatteries in, do the following steps:1. Make sure that the power cord is correctlyplugged into the charger in the wall and clipon charging station indicator green light ison.2. Make sure that there is contact between thecontact plates of the lift and the circuit boardof the charging station.3. Check the power of the outlet.4. If the yellow or green light of the chargingstation do not light up, contact your localdealer or representative for assistance.Sling Inspection and CareFor maximum patient safety and hygiene, readthe following instructions:Chemical AttackOil, grease, creosote or paint stains areharmless but other forms of chemical attack of aLoose threads in stitched area.Noticeable discoloration by havingalighter color strap than the doublethickness stitched area.Side wear.Middle wear.2. Check for any sign of deterioration of thesling material. Check for general externalwear, local abrasion, cuts, holes or burns inthe webbing and for chemical attack.3. Look at "stitched areas" for broken, worn,pulled or unraveled stitches.4. Sling should be cleaned as indicated on thetag.If there is any sign of wear or deterioration asindicated above or other visual defect, slingshould be changed immediately. By continuingto use the lift without changing the sling, caregiver and patient safety is greatly compromisedMAXI SKY 1000 Operating Manual 16