TREMFAST LV ADHESIVE - Tremco Roofing

Material Safety Data SheetTREMFAST LV ADHESIVEVersion 2.0 Print Date 01/22/2013REVISION DATE: 01/21/2013bonding/grounding connection when pouring liquid. Extinguish all ignition sources including pilot lights, nonexplosionproof motors and electrical equipment until vapors dissipate. Personal protective equipment must beworn during maintenance or repair of contaminated mixer, reactor, or other equipment. Keep container closedwhen not in use. Vapor may migrate to sources of ignition. Do not smoke, weld, generate sparks, or use flamenear container. Store in sealed containers in a cool, dry, ventilated warehouse location.SECTION 8 - EXPOSURE CONTROLS / PERSONAL PROTECTIONPersonal protection equipmentRespiratory protection : Wear appropriate, properly fitted NIOSH/MSHA approved organic vapor orsupplied air respirator when airborne contaminant level(s) are expected toexceed exposure limits indicated on the MSDS. Follow manufacturer'sdirections for respirator use.Hand protection : Use suitable impervious nitrile or neoprene gloves and protective apparel toreduce exposure.Eye protection : Wear appropriate eye protection.Wear chemical safety goggles and/or faceshield to prevent eye contact. Do not wear contact lenses. Do not touch eyeswith contaminated body parts or materials. Have eye washing facilities readilyavailable.Protective measures : Use professional judgment in the selection, care, and use.Inspect and replaceequipment at regular intervals.Engineering measures : Use only in well ventilated areas. Provide maximum ventilation in enclosedareas.Use local exhaust when the general ventilation is inadequate.Exposure LimitsChemical Name CAS Number Regulation Limit FormDichloromethane75-09-2 ACGIH TWA: 50 ppm(Methylene Chloride)Calcium Carbonate 1317-65-3 OSHA PEL: 5 mg/m3 Respirable fraction.(Limestone)OSHA PEL: 15 mg/m3 Total dust.ACGIH TWA: 3 mg/m3 Respirable particles.ACGIH TWA: 10 mg/m3 Inhalable particles.OSHA TWA: 15 mg/m3 Total dust.OSHA TWA: 5 mg/m3 Respirable fraction.Zinc oxide 1314-13-2 ACGIH TWA: 2 mg/m3 Respirable fraction.ACGIH STEL: 10 mg/m3 Respirable fraction.OSHA PEL: 5 mg/m3 Fume.OSHA PEL: 5 mg/m3 Respirable fraction.OSHA PEL: 15 mg/m3 Total dust.OSHA TWA: 15 mg/m3 Total dust.OSHA TWA: 5 mg/m3 Respirable fraction.SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIESFormColorOdor: Liquid solution: Lt. Beige: Chlorinated solvent3/6 48808 805

Material Safety Data SheetTREMFAST LV ADHESIVEVersion 2.0 Print Date 01/22/2013REVISION DATE: 01/21/2013pHVapour pressure: Not available.: 340 hPaVapor density: Heavier than airMelting point/range: Not available.Freezing point: Not available.Boiling point/range : 113 - 180 °F, 45 - 82 °CWater solubility: NegligibleSpecific Gravity : 1.1885% Volatile Weight : 58 %SECTION 10 - REACTIVITY / STABILITYSubstances to avoidStabilityHazardous polymerization: Oxidizing agents.Strong acids.Strong bases.: Stable under normal conditions. Avoid welding arcs, flames or other hightemperature sources.: Will not occur.SECTION 11 - TOXICOLOGICAL INFORMATIONDichloromethane (Methylene Chloride), CAS-No.: 75-09-2Acute oral toxicity (LD-50 oral) 1,600 mg/kg ( Rat ) 3,000 mg/kg ( Rat )Acute inhalation toxicity (LC-50) 2,000 mg/l for 15 min ( Rat ) 11,600 mg/l for 6 h ( Guinea pig) 14,400 mg/l for 7 h ( Mouse ) 79 mg/l for 2 h ( Rat ) 52 mg/lfor 6 h ( Rat ) 56.23 mg/l for 7 h ( Mouse ) 49.1 mg/l for 6 h( Mouse ) 51.5 mg/l for 2 h ( Mouse ) 40.2 mg/l for 6 h (Guinea pig ) 16,000 mg/l for 7 h ( Mouse )Zinc oxide, CAS-No.: 1314-13-2Acute oral toxicity (LD-50 oral) 7,950 mg/kg ( Mouse ) 7,950 mg/kg ( Mouse )SECTION 12 - ECOLOGICAL INFORMATIONNo Data AvailableSECTION 13 - DISPOSAL CONSIDERATIONSRCRA Class : D001: Reportable Quantity = 100 lbs. (Characteristic of ignitability)This classification applies only to the material as it was originally produced.Disposal Method : Subject to hazardous waste treatment, storage, and disposal requirements underRCRA. Recycle or incinerate waste at EPA approved facility or dispose of incompliance with federal, state and local regulations.4/6 48808 805

Material Safety Data SheetTREMFAST LV ADHESIVEVersion 2.0 Print Date 01/22/2013REVISION DATE: 01/21/2013SECTION 14 - TRANSPORTATION / SHIPPING DATACFR / DOT:TDG:IMDG:UN1992, Flammable liquids, toxic, n.o.s. (aliphatic hydrocarbons, Methylene Chloride), 3(6.1), PG IIUN1992, FLAMMABLE LIQUID, TOXIC, N.O.S. (aliphatic hydrocarbons, Methylene Chloride), 3 (6.1), PG IIUN1992, FLAMMABLE LIQUID, TOXIC, N.O.S. (aliphatic hydrocarbons, Methylene Chloride), 3(6.1), PG IIFurther Information:The above shipping description may not be accurate for all container sizes and all modes of transportation.Please refer to Bill of Lading.SECTION 15 - REGULATORY INFORMATIONNorth American Inventories:All components are listed or exempt from the TSCA inventory.This product or its components are listed on, or exempt from the Canadian Domestic Substances List.U.S. Federal Regulations:SARA 313 Components : Dichloromethane (Methylene Chloride) 75-09-2Zinc oxide 1314-13-2SARA 311/312 Hazards : Acute Health HazardFire HazardOSHA Hazardous Components :Dichloromethane (Methylene Chloride) 75-09-2Calcium Carbonate (Limestone) 1317-65-3Zinc oxide 1314-13-2OSHA Status: Consideredhazardous based on thefollowing criteria:: IrritantOSHA Flammability : IBRegulatory VOC (less water andexempt solvent)5/6 48808 805: 246 g/lVOC Method 310 : 12 %U.S. State Regulations:MASS RTK Components : Dichloromethane (Methylene Chloride) 75-09-2Calcium Carbonate (Limestone) 1317-65-3Zinc oxide 1314-13-2

Material Safety Data SheetTREMFAST LV ADHESIVEVersion 2.0 Print Date 01/22/2013REVISION DATE: 01/21/2013Penn RTK Components : Dichloromethane (Methylene Chloride) 75-09-2Calcium Carbonate (Limestone) 1317-65-3Aliphatic Naphtha (Light aliphatic naphtha) 64742-89-8Aromatic hydrocarbon resin NJ TSRN# 51721300-5274PStyrene-butadiene copolymers NJ TSRN# 51721300-5132PRosin ester NJ TSRN# 51721300-5273PZinc oxide 1314-13-2NJ RTK Components : Dichloromethane (Methylene Chloride) 75-09-2Calcium Carbonate (Limestone) 1317-65-3Aliphatic Naphtha (Light aliphatic naphtha) 64742-89-8Aromatic hydrocarbon resin NJ TSRN# 51721300-5274PStyrene-butadiene copolymers NJ TSRN# 51721300-5132PComponents under California Proposition 65:WARNING! Contains chemicals known to the State of California to cause cancer, birth defects and/or otherreproductive harmSECTION 16 - OTHER INFORMATIONHMIS Rating :Health 2 0 = MinimumFlammability 41 = SlightReactivity 02 = ModeratePPE3 = Serious4 = SevereFurther information:For Industrial Use Only. Keep out of Reach of Children. The hazard information herein is offered solely for theconsideration of the user, subject to their own investigation of compliance with applicable regulations, includingthe safe use of the product under every foreseeable condition.Prepared by: Rich MikolLegendACGIH - American Conference of Governmental HygienistsCERCLA - Comprehensive Environmental Response, Compensation, andLiability ActDOT - Department of TransportationDSL - Domestic Substance ListEPA - Environmental Protection AgencyHMIS - Hazardous Materials Information SystemIARC - International Agency for Research on CancerMSHA - Mine Safety Health AdministrationNDSL - Non-Domestic Substance ListNIOSH - National Institute for Occupational Safety and HealthNTP - National Toxicology ProgramOSHA - Occupational Safety and Health AdministrationPEL - Permissible Exposure LimitRCRA - Resource Conservation and Recovery ActRTK - Right To KnowSARA - Superfund Amendments and Reauthorization ActSTEL - Short Term Exposure LimitTLV - Threshold Limit ValueTSCA - Toxic Substances Control ActTWA - Time Weighted AverageV - VolumeVOC - Volatile Organic CompoundWHMIS - Workplace Hazardous Materials InformationSystem6/6 48808 805