SigmaFire Installation Manual, rev. F - Clayton Industries

More documents

Recommendations

Info

Steam Generator & Fluid Heater<strong>Installation</strong> <strong>Manual</strong>NOTE 1: Barometric dampers are recommended on all installations with stack heights over 20 feet (6 meters)and on any low NOx units.NOTE 2: A removable, 4 feet (1.2 meters) minimum, stack section is recommended to facilitate steamgenerator/fluid heater maintenance and repair.NOTE 3: A backdraft damper must be installed in the exhaust stack for installations in cold weather climates.All backdraft dampers must be air-tight and proof-of-position switches.NOTE 4: Oil-fired units require a 2W x 3H feet (0.6W x 0.9H meter) access portal in the stack for inspection andwater washing. A floor drain is required at the bottom of the generator under or close to the burneropening.Figure 2-2 Standard exhaust stack layout for natural gas and light-oil installations only. Notrecommended for heavy-oil machines.Sect02_Genrl-SF_q.fm 2-8 04/21/2015
Section II - General Information*See Notes 1 – 4 in Figure 2-2.Figure 2-3 Alternate multi-unit exhaust stack layout for natural gas and light-oil installations only.Not recommended for heavy-oil machines.04/21/2015 2-9 Sect02_Genrl-SF_q.fm
Page 1 and 2: CoverSigmaFireSteam Generator&Fluid
Page 3 and 4: Title PageSigmaFireSteam Generatora
Page 5 and 6: Table of ContentsSection 1 Introduc
Page 10 and 11: STEAM GENERATOR & FLUID HEATERINSTA
Page 12 and 13: Steam Generator & Fluid HeaterInsta
Page 58 and 59: Steam Generator and Fluid HeaterIns
Page 68 and 69:
Steam Generator and Fluid HeaterIns
Page 70 and 71:
Page 72 and 73:
Page 74 and 75:
Steam Generator & Fluid HeaterInsta
Page 76 and 77:
Page 78 and 79:
Page 80 and 81:
Page 82 and 83:
Page 84 and 85:
Page 86 and 87:
Page 88 and 89:
Page 90 and 91:
ContentsDrawing No. Drawing Title P
Page 92 and 93:
P&ID_SF_a.fm C-10 04/22/2015
Page 94 and 95:
P&ID_SF_a.fm C-12 04/22/2015
Page 96 and 97:
P&ID_SF_a.fm C-14 04/22/2015
Page 98 and 99:
P&ID_SF_a.fm C-16 04/22/2015
Page 100 and 101:
P&ID_SF_a.fm C-18 04/22/2015
Page 102 and 103:
P&ID_SF_a.fm C-20 04/22/2015
Page 104 and 105:
P&ID_SF_a.fm C-22 04/22/2015
Page 106 and 107:
P&ID_SF_a.fm C-24 04/22/2015
Page 108 and 109:
Page 110 and 111:
Page 112:
show all

SigmaFire Installation Manual, rev. F - Clayton Industries

Create successful ePaper yourself

Delete template?

Save as template?