LVWO Waste Oil Boiler - Columbia Heating

More documents

Recommendations

Info

57212 1/8 Brass Street ElbowKey 120V/60DescriptionHZ57213 1/8 Galvanized Street Elbow56400 Screen Suction Strainer ¾ in.56405 Check Valve ¾”57155 Lenz Oil Filter Asm (100 mic) with Gauge57151 Lenz Replacement Element with O-ring57153 Lenz O-Ring (between head and housing)15711 Ball Valve, ½ NPT x ½ NPT (install filter)57263 Flare Ball Valve, ½ FNPT x 3/8 (install at oilregulator)56680 Swivel, ½ x ¼ (install at oil regulator)56681 Swivel, ¾ x ½ (install at Lenz filter)56683 Tee, 1.4 x ¼ x 1/856685 Hex Nipple, ¼ x 1/45 (install at oil regulator)56686 Hex Nipple, ½ x 2 (install at Lenz filter)56688 Nipple, ¼ x 256925 J-Oil Pump Assembly; Motor, Base, Pump Head56934 J-Oil Pump Only less Motor and Housing56923 Gasket for J-Oil Pump Cover56930 1/4 HP Motor only for J-Oil Pump,57261 Coupler for J Oil Transfer Pump57262 Shaft Seal; J-Oil Pump Face (no snap ring)57259 Shaft Seal; J-Oil Pump Lip (has snap ring)LVWO Manual Page 46 of 48
Key 120V/60DescriptionHZ56418 Wall Thermostat, 24 Volt ac57144 Lenz 60# Vacuum/Air GaugeMaintenance RecordDate Service Performed SignedLVWO Manual Page 47 of 48
Page 1 and 2: Columbia Boiler Waste Oil-Fired Boi
Page 3 and 4: PACKING LISTAll units should be ins
Page 5 and 6: 7) If permanent masonry chimney is
Page 7 and 8: The installation of Equipment in Ca
Page 9 and 10: FIELD ASSEMBLY INSTRUCTIONS - BURNE
Page 11 and 12: COMPRESSED AIR SUPPLY1. A minimum 2
Page 13 and 14: Suction Line: Field provides piping
Page 15 and 16: B5 SINGLE NOZZLE BURNER INTERNAL WI
Page 17: INITIAL START UP AND OPERATING SEQU
Page 20 and 21: ROUTINE BURNER MAINTENANCEWeekly Ma
Page 22 and 23: Assembly of NozzleO-RING 57186FERRU
Page 24 and 25: ASSEMBLY OF OIL AND AIR SOLENOID #5
Page 26 and 27: OIL FROM SOLENOID INTOBLOCK AND ON
Page 28 and 29: Monthly boiler check/maintenance li
Page 30 and 31: 2. Remove the refractory by cutting
Page 32 and 33: COLUMBIA LVWO WASTE OIL-FIRED BOILE
Page 34 and 35: USED OIL-FIRED BOILERSSPECIFICATION
Page 36 and 37: BOILER CONTROLS AND SAFETY DEVICESS
Page 38 and 39: • Cleaner, no dust blowing. Used
Page 40 and 41: 3. Water, paint, or antifreeze in o
Page 42 and 43: AL AE AD AC AF X W V ZA (BURNER COM
Page 44 and 45: Key 120V/60HZDescription57181 8-32
Page 48: LVWO Manual Page 48 of 48

LVWO Waste Oil Boiler - Columbia Heating

Create successful ePaper yourself

Delete template?

Save as template?