CSFE IV STEAM Series 4 - Columbia Heating

More documents

Recommendations

Info

TABLE OF CONTENTSDimensions ........................................................2Ratings, Data .....................................................3Safety Symbols ..................................................4Locating The Boiler .............................................5Ventilation And Combustion Air ............................6Supply And Return Piping ....................................8Venting System Inspection & Installation .............12Oil Tank And Piping ...........................................13Electrical Wiring ...............................................14Operating Instructions .......................................16Maintenance Procedures ....................................19Service Checklist ..............................................21IMPORTANT: Read and understand the followinginstructions COMPLETELY before installing.! WARNINGInstallations of boilers and venting shall be doneonly by qualified expert and in accordance with thismanual. Installing or venting a boiler or any othergas appliance with improper methods or materialscould result in serious injury or death due to fireor to asphyxiation from poisonous gases such ascarbon monoxide which is odorless and invisible.! WARNINGKeep boiler area clear and free from combustiblematerials, gasoline and other flammable vapors andliquids.Do not obstruct air openings to boiler room.KEEP THIS MANUAL NEAR BOILERRETAIN FOR FUTURE REFERENCESAFETY SYMBOLSThe following defined symbols are used throughout thismanual to notify reader of potential hazards of varying risklevels.! DANGERIndicates a hazardous situation which, if notavoided, WILL result in death or serious injury.Modification, substitution or elimination of factoryequipped, supplied or specified components couldresult in personal injury or the loss of life.Owner - Installation and service of this boiler mustbe performed by a qualified installer.Installer - Leave all instructions with the boiler forfuture reference.When this product is installed in the Commonwealthof Massachusetts the installation must be performedby a Licensed Plumber or Licensed Gas Fitter.!WARNINGIndicates a hazardous situation which, if not avoided,could result in death or serious injury.!CAUTIONIndicates a hazardous situation which, if notavoided, could result in minor or moderate injury.NOTICEIndicates information which should be followed toensure proper installation and operation.PATENT 7,823,5444
LOCATING THE BOILER• Installations shall conform to the requirements ofthe authority having jurisdiction. Such applicablerequirements take precedence over the generalinstructions of this manual.• Where required by the authority having jurisdiction,the installation must conform to the American Societyof Mechanical Engineers Safety Code for Controls andSafety Devices for Automatically Fired Boilers, ANSI/ASME No. CSD-1.!WARNINGFire hazard. Do not install boiler on combustibleflooring or carpeting. Failure to follow theseinstructions could result in death or serious injury.FOR INSTALLATION ON NON-COMBUSTIBLE FLOORS ONLYBoiler must not be installed on carpeting or vinyl flooring.Minimum clearances to combustible construction are:• Locate boiler in front of final position before removingcrate.• Provide level solid base as near chimney as possibleand centrally located with respect to heat distributionsystem as practical.• Allow 24 inches in front, top and right hand side forservicing and cleaning, or removing tankless waterheating coil.TOPFRONTFLUE CONNECTORREARLEFT SIDERIGHT SIDE24 IN.24 IN.9 IN.24 IN.6 IN.24IN.• Recommend 24 inches be allowed in back of boiler forconvenience when skimming hole is used.• When installed in a utility room, the door should bewide enough to allow largest boiler part to enter, or topermit replacement of another appliance such as waterheater.• Install boiler such that oil ignition system componentsare protected from water (dripping, spraying, rain etc.)during appliance operation and service.NOTE: Clearance for access should exceed fire protectionclearance.Figure #2 - Minimum Clearances To CombustibleConstruction (as seen from above)BACK24"6" BOILER 24"24"FRONT5
Page 3: RATINGS, DATARATINGSWITHOUTTANKLESS
Page 7 and 8: VENTILATION AND COMBUSTION AIR5. Wh
Page 9 and 10: 1. Suggested piping for steam heati
Page 11 and 12: RETURNSUPPLY AND RETURN PIPINGFigur
Page 13 and 14: OIL TANK AND PIPINGTank Installatio
Page 15 and 16: ELECTRICAL WIRINGSTEAM WIRING W/BEC
Page 17: OPERATING INSTRUCTIONSStart-Up And
Page 20 and 21: MAINTENANCE PROCEDURESUsing Cleanin
Page 22: NOTES

CSFE IV STEAM Series 4 - Columbia Heating

Create successful ePaper yourself

Delete template?

Save as template?