Cyclone Electric Start Kit - Vintage Snow

More documents

Recommendations

Info

2. Place battery in battery box withpositive (+) t erminal on battery facingforward .3. Place battery hold-down with boltson top of battery. Hook ends of holddownbolts in s l ot s on front and rearof battery box as shown above.4. Tighten l ock nuts on battery holddownbol ts snug. Do not over-tighten.5. Place s tarter solenoid cable i nJ-clip a t tached to right-hand s i de ofengine . At tach solenoid cable tostar ter mo t or with a 1/4 11 internal toothlock washer and 1/4 11hex. nut.6. Pla ce end of overflow t ube frombattery thr ough hole in bottom of tunnel.7 . At t ach positive (+) battery cableto posi t ive t erminal on batt ery.8. Using 6 mm x l : -mm bolt previouslyremoved i n step l ~ on page 4~ place a9/32" x 5/ 8" x .060" flat washer on boltand attach negative (-) gr ound cable toCAUTION : To avoid aaaident-al- shortairauiting, be sure to atrtaah the positivecable to positive (+) batteryterminal before the ground cable isattached to the negative (-) battery s i de of engine as shown.terminal. Slide rubber boot over positi ve battery terminal- unbi: l t erminal andat taching bolt are conpktely covered.- 6-At t ach otherend of cabl e to negative (-) batteryterminal.
.REINSTALL PARTS REMOVEDYou now have the electric start kitins talled.Now, r ei ns t a l l the primary drivecl utch sheave , drive belt, mufflerand latch the drive belt shield inplace.IMPORTANT: Be sure to tight en theprirrary drive cl-utch: sheave bolt to50 ft-lbs torque ,Lower and latch the hood in place.Refer to the Operator's Manual forcomplete starting instructions andbattery maintenance.TEMPLATEUse the template shown below forlocating the two holes t hat must bedrilled in the tunnel t o install thebattery box assembly.T,-----I IL_----R.H. EDGE OF TUNNELI--FRONT EDGE OF TUNNEL-- .....I + ,...-}-121.344 HOLES;oJ\ t ' _I- 7-
Page 1 and 2: INSTRUC TIONS FOR INSTALLING AM5396
Page 3 and 4: INSTALL TAIL BRACKET ON STARTER MOT
Page 5: ATTACH RECTIFIER WIRE TO TERMINALBO

Cyclone Electric Start Kit - Vintage Snow

Create successful ePaper yourself

Delete template?

Save as template?