SERVICE MANUAL - Toshiba

More documents

Recommendations

Info

1-2-14.Floor Standing Concealed TypeModels: MML-AP0071BH, AP0091BH, AP0121BH, AP0151BH, AP0181BH, and AP0241BHGRNRCWHI9RED BLK ORN BLU YEL9 7 7 5 5 3 3 11R301(BLK)1313131313(GRY)CN304(YEL)CN309(BLK)CN067RY004FUSET5.0A 250V~RY007HM L ULRY0061RY005CN104(YEL)1231231. Indicates the terminal bolock.Letter at inside indicates the terminal number.2. A dotted line and broken line indicatethe wiring at side.3. indicate the control p.c. board.TA12CN102(RED)12TCJ12CN101(BLK)CN100(BRW)CN080(GRN)CN073(RED) 2112123CN070(WHI)121211221 2133 1 2 3 4 5 CN074 1 3 1 2 3 4 5 6 1 2 3 4 5 6 1 2 1 2 3 4 5 6(WHI) 1 3 1 2 3 4 5 6FAN OPTIONDRIVECN081(BLK)1234511221 2 3 4 5 61 2 3 4 5 611221 2 3 4 5 61 2 3 4 5 63321 11 12 2TC212REDClosed-endconnectorIndoor unitearth screwPower supplysingle phase220-240V 50Hz220V 60HzAC IN1 CN0662 (WHI)EMGCN044(BRW)CN040(BLU)CN041(BLU)CN050(WHI)CN061(YEL)CN032(WHI)CN060(WHI)TRCN01(WHI)CN02(BLU)CN03(RED)CN03(RED)Outdoor unitCN1Remote ControllerPNLEXCTFILTERTC1REDWHIFlow selectorunit earthscrewWHIR(L) S(N)GRNFM132456132456WHIREDFANCN083(WHI)RCRED BLK ORN BLU YEL9 7 5 3 19 7 5 3 1FMREDFANCN083(WHI)2456324563CN068(BLU)1133113311CN033(GRN)32 366PMV4 3 1 2 54 3 1 2 51 2 3 4 5 61 2 3 4 5 6PMVFor AP0071BH,AP0091BH,AP0121BHRY002RY001CN030(RED)Control P.C. boardfor undoor unitMCC-1403CN082(BLU)Power supplycircuitCN075(WHI)Sub P.C. boardMCC-1520CN02(YEL)Networkadapter(Option)CN01(WHI)TRU1 U2A B X YU1 U21122MCC-1401ColorindicationRED : REDWHI : WHITEYEL : YELLOWBLU : BLUEBLK : BLACKGRY : GRAYPNK : PINKORN : ORANGEBRW : BROWNGRN : GREENSymbol Parts nameFMFan motorRCRunning capacitorTRTransformerTAIndoor temp sensorTC1,TC2,TCJTemp sensorRY001Louver control relayRY002Drain control relayRY004Heater control releyRY005~007Fan motor control relayPMVPulse motor valve39
1-2-15.Floor Standing TypeModels: MMF-AP0151H, AP0181H, AP0241H, AP0271H, AP0361H, AP0481H, andAP0561HFMBRW1345678134567RCFANCN083(WHI)9RED BLK ORN BLU YEL9 7 7 5 5 3 3 11CN068(BLU)1 3DP11LM2211LM3 CN0333 (GRN)11FS3 CN0302 3 (RED)66PMV4 3 1 2 54 3 1 2 51 2 3 4 5 61 2 3 4 5 6PMVCN082(BLU)P301(BLK)13AC IN13131313(GRY)CN304(YEL)CN309(BLK)CN067RY004FUSET5.0A 250V~RY007HM L ULRY006RY005RY002RY001Control P.C. boardfor Indoor unitMCC-1403CN104(YEL)CN102(RED)CN101(BLK)CN100(BRW)CN080(GRN)CN073(RED) 213112131212121212123PNLEXCTTATCJTC2TC1Indoor unitearth screw Closed-endconnectorPower supplysingle phase220-240V 50Hz220V 60HzCN066(WHI)CN044(BRW)EMGLine Filter1. Indicates the terminal bolock, letter.Letter at inside indicates the terminal number.2. A dotted line and broken line indicatethe wiring at side.3. indicate the control p.c. board.CN070(WHI)CN081(BLK)121212CN040(BLU)112211221122CN041(BLU)1 2133 RC 1 2 3 4 5 CN074 11 2 3 4 5 6 1 2 3 4 5 6 1 2 1 2 3 4 5 6(WHI) 1 3 1 2 3 4 5 6FAN OPTIONDRIVE31 1Outdoor unit Remote ControllerCN132CN050(WHI)CN01(WHI)CN02(BLU)CN03(RED)11X Y1234522CN061(YEL)CN032(WHI)CN060(WHI)FILTERSymbol Parts nameFMFan motorRCRunning capacitorTRTransformerLMLover motorTAIndoor temp sensorTC1,TC2,TCJTemp sensorRY001Louver control relayRY002Drain control relayRY005~007Fan motor control relayPMVPulse motor valveColorindicationRED : REDWHI : WHITEYEL : YELLOWBLU : BLUEBLK : BLACKGRY : GRAYPNK : PINKORN : ORANGEBRW : BROWNGRN : GREENBLUBLUBLKBLKREDWHIR(L) S(N)Flow selectorunit earthscrewTRU1U1 U2U2 A B1122Network Adapter(Option)MCC-14013Power supplycircuit1 2 3 4 5 61 2 3 4 5 6Sub P.C. boardMCC-1520CN075(WHI)CN02(YEL)1 2 3 4 5 61 2 3 4 5 6 CN01(WHI)TR40
Page 1 and 2: FILE No. A10-005AIR CONDITIONER (MU
Page 3 and 4: 4-1. Normal Operation (COOL Mode /
Page 5 and 6: 9-4. Cooling-Season Outdoor Unit Ba
Page 7 and 8: Definition of Protective GearWhen t
Page 9 and 10: Precautions for SafetyThe manufactu
Page 11 and 12: Use specifiedparts.When any of the
Page 13 and 14: Only a qualified installer (*1) or
Page 15 and 16: SpecificationsModelMMY-MAP0804HT8-E
Page 17 and 18: Carrying in the Outdoor UnitCAUTION
Page 19 and 20: Selection of Pipe SizeCoupling size
Page 21 and 22: Table 2Standard typeHigh Efficiency
Page 23 and 24: 4. Tools(1) Required Tools for R410
Page 25 and 26: Models: MMY-MAP1404 and MAP160424
Page 27 and 28: 1-2-2. Compact 4-way Cassette TypeM
Page 29 and 30: 1-2-4. 1-way Air Discharge Cassette
Page 31 and 32: 1-2-6. 2-way Air Discharge Cassette
Page 33 and 34: 1-2-8. Concealed Duct High Static P
Page 35 and 36: 1-2-9. Slim Duct TypeModels: MMD-AP
Page 37 and 38: 1-2-11.High Wall Type 2 seriesModel
Page 39: 1-2-13.Floor Standing Cabinet TypeM
Page 43 and 44: Models: MMD-AP0721HFE and MMD-AP096
Page 45 and 46: 2-2. Outdoor Unit (60Hz model: MMY-
Page 47 and 48: 2-4. Outdoor Inverter (60Hz model:
Page 49 and 50: 2-way Air Discharge Cassette TypeMo
Page 51 and 52: Concealed Duct High Static Pressure
Page 53 and 54: Floor Standing TypeModel MMF-AP 015
Page 55 and 56: 14, 16HPModel: MMY-MAP1404, MAP1604
Page 57 and 58: Outdoor Unit (14, 16HP)Model: MMY-M
Page 59 and 60: 2-8-2. Inverter P.C. board for comp
Page 61 and 62: 3 Refrigerant Piping Systematic Dra
Page 63 and 64: Explanation of Functional PartsFunc
Page 65 and 66: 4 Combined Refrigerant Piping Syste
Page 67 and 68: 4-3. Normal Operation (HEAT Mode)He
Page 69 and 70: 4-5. Emergency Operation (Heating O
Page 71 and 72: 5 Control Outline Indoor UnitContro
Page 73 and 74: NO. Item Specification outline Rema
Page 75 and 76: NO. Item Specification outline Rema
Page 77 and 78: Outdoor UnitItem Description of ope
Page 79 and 80: Item Description of operation, nume
Page 85 and 86: 1 Cooling operation under low outsi
Page 87 and 88: Centralcontrolremotecontroller(opti
Page 89 and 90: 6-1-2. When Wireless Remote Control
Page 91 and 92:
Centralcontrolremotecontroller(opti
Page 93 and 94:
XYDC5VPower supply circuitMain (sub
Page 95 and 96:
6-2. Indoor Printed Circuit BoardMC
Page 97 and 98:
MCC-1403 Power supplyPower supplytr
Page 99 and 100:
6-4. Test Operation of Indoor Unit
Page 101 and 102:
Function CODE No. (DN Code) Table (
Page 103 and 104:
TypeDN code “10”Value Type Mode
Page 105 and 106:
▼ Ventilating fan control from re
Page 107 and 108:
6-7. Applied control for Outdoor Un
Page 109 and 110:
(2) Indoor unit setup method for pr
Page 111 and 112:
6-8-1. Power peak-cut Control (Stan
Page 113 and 114:
6-8-3. Snowfall Fan ControlHeader o
Page 115 and 116:
6-8-6. Operation Mode Selection Con
Page 117 and 118:
6-8-8. Compressor Operation OutputO
Page 119 and 120:
7 TEST OPERATION7-1. Procedure and
Page 121 and 122:
(2) In the case that a central cont
Page 123 and 124:
• Check the additional amount of
Page 125 and 126:
7-4. Address SetupThis product requ
Page 127 and 128:
(Example)Controlling 2 or more refr
Page 129 and 130:
10 Set the central control address.
Page 131 and 132:
Manual address setup from the remot
Page 133 and 134:
To find an indoor unit’s position
Page 135 and 136:
4 Push the TIME / buttons repeatedl
Page 137 and 138:
2) Turn on dip switch 2 of SW30 on
Page 139 and 140:
7-4-4. Check after Address Setup wh
Page 141 and 142:
7-5-2. Operation from the indoor re
Page 143 and 144:
Miswiring exampleFigureRemotecontro
Page 145 and 146:
7-6-2. Cooling/Heating Test Operati
Page 147 and 148:
(2) Test operationSTARTTest operati
Page 149 and 150:
7-7. Service Support Function7-7-1.
Page 151 and 152:
7-7-2. Function to Start/Stop (ON/O
Page 153 and 154:
(2) Heating test operation function
Page 155 and 156:
(4) Individual start/stop (ON/OFF)
Page 157 and 158:
(2)Clearing error by using switches
Page 159 and 160:
7-7-5. Pulse Motor Valve (PMV) Forc
Page 161 and 162:
7-7-8. Fan Operation Check in Outdo
Page 163 and 164:
7-7-10.Manual Adjustment Function o
Page 165 and 166:
7-7-11.Monitor Function of Remote C
Page 167 and 168:
8 TROUBLESHOOTING8-1. Overview(1) B
Page 169 and 170:
(Error detected by main remote cont
Page 171 and 172:
F12 - F12 ALTF15 - F15 ALTF16 - F16
Page 173 and 174:
(Errors detected by IPDU featuring
Page 175 and 176:
Using TCC-LINK central control remo
Page 177 and 178:
Light block Check code Cause of fau
Page 179 and 180:
8-4. Check Codes Displayed on Remot
Page 181 and 182:
MainremotecontrollerCheck codeOutdo
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
Page 189 and 190:
MainremotecontrollerP04P05P07P10Che
Page 191 and 192:
Page 193 and 194:
Errors Detected by TCC-LINK Central
Page 195 and 196:
8-5. Diagnosis procedure for each c
Page 197 and 198:
Check code Check code name CauseChe
Page 199 and 200:
Check code Check code nameCause[E18
Page 201 and 202:
Check code Check code nameCause[E31
Page 203 and 204:
Check code Check code nameCause[F15
Page 205 and 206:
Check code Check code nameCause[H01
Page 207 and 208:
Page 209 and 210:
(*3) Check for solenoid valve of al
Page 211 and 212:
Page 213 and 214:
Page 215 and 216:
Check code Check code nameCause[L17
Page 217 and 218:
Check code Check code nameCause[P04
Page 219 and 220:
Page 221 and 222:
Page 223 and 224:
(C)Heating operationDoes heatingind
Page 225 and 226:
Page 227 and 228:
(1)Display of System Information (D
Page 229 and 230:
(3)Display of Outdoor Cycle Data (D
Page 231 and 232:
(5)Display of Indoor Unit Informati
Page 233 and 234:
8-8. Leakage/Clogging of Refrigerat
Page 235 and 236:
List of Check Codes Generated upon
Page 237 and 238:
8-9. Sensor CharacteristicsOutdoor
Page 239 and 240:
Indoor TC1 sensor200150Resistance[k
Page 241 and 242:
240Outdoor Unit▼ Ps sensor charac
Page 243 and 244:
9-2. Compressor Backup Operation Se
Page 245 and 246:
(6) Turn on the power supply to all
Page 247 and 248:
(8) Set Bits 1 and 2 of SW30 on the
Page 249 and 250:
10OUTDOOR UNIT REFRIGERANTRECOVERY
Page 251 and 252:
[Setup of failed outdoor unit](13)W
Page 253 and 254:
[Setup of outdoor units other than
Page 255 and 256:
10-3.Work procedure after RepairWhe
Page 257 and 258:
11-2.Replacement of Compressors•
Page 259 and 260:
[When replacing normal as well as f
Page 261 and 262:
11-3.Check Procedure to Search Caus
Page 263 and 264:
Check items and procedures to follo
Page 265 and 266:
No. Part to be replaced Work proced
Page 267 and 268:
Page 269 and 270:
Page 271 and 272:
Page 273 and 274:
Page 275 and 276:
Page 277 and 278:
13P.C. BOARD EXCHANGE PROCEDURES In
Page 279 and 280:
Procedure 1: Reading Setting Data f
Page 281 and 282:
Procedure 3: Writing Setting Data i
Page 283 and 284:
CODE No. list (Example)CODE No. (DN
Page 285 and 286:
13-2-3.Interface board (MCC-1606) r
Page 287 and 288:
(6) Set the dip switch (SW800) sett
Page 289 and 290:
13-2-6.Noise Filter P.C. Board (MCC
Page 291 and 292:
(7) Install the service P.C. boards
Page 293 and 294:
040010033046050078045 046 078044 04
Page 295 and 296:
SMMS-i OUTDOOR UNITMMY-MAP1404HT8(Z
Page 297 and 298:
REFRIGERATION CIRCUIT DIAGRAMMMOTOR
Page 299 and 300:
Ref.No.Part No.DescriptionMAP0804HT
Page 301 and 302:
NSW08ONOFFSW10ONSW09ONSW07ONSW06ONB
Page 303 and 304:
SMMS-i OUTDOOR UNITMMY-MAP0804T8(Z)
Page 305 and 306:
Page 307 and 308:
032010026 027(SV41)046 050 078031 (
Page 309 and 310:
Ref.No.Part No.DescriptionMAP0804T8
Page 311 and 312:
NONOFFONONONON3 4211BLKWHIONONONONB
Page 313 and 314:
Page 315 and 316:
040010033046050078045 046 078044 04
Page 317 and 318:
Page 319 and 320:
Page 321 and 322:
Page 323 and 324:
Page 325 and 326:
SMMS-i OUTDOOR UNITMMY-MAP0804T8(Z)
Page 327 and 328:
Page 329 and 330:
032010026 027(SV41)046 050 078031 (
Page 331 and 332:
Page 333 and 334:
Page 335 and 336:
Page 337 and 338:
040010033046050078045 046 078044 04
Page 339 and 340:
Page 341 and 342:
Page 343 and 344:
Page 345 and 346:
Page 347 and 348:
Page 349 and 350:
Page 351 and 352:
032010026 027(SV41)046 050 078046 0
Page 353 and 354:
Page 355 and 356:
Page 357 and 358:
Page 359 and 360:
040010033046050078045 046 078044 04
Page 361 and 362:
SMMS-i OUTDOOR UNITMMY-MAP1404T8-SG
Page 363 and 364:
Page 365 and 366:
Page 367 and 368:
Page 369 and 370:
WARNINGS ON REFRIGERANT LEAKAGEChec
show all

SERVICE MANUAL - Toshiba

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?