Rialta Service Manual - RialtaInfo

More documents

Recommendations

Info

SECTION 1ELECTRICALSYMPTOMTROUBLESHOOTING THE CONVERTER1. Auxiliary battery is not being charged when 1.vehicle is connected to 110-volt AC power.COURSE OF ACTIONTurn ignition key to OFF position. Disconnectvehicle from shoreline or generator 110-volt ACpower.Fully charge auxiliary battery, clean and tightenbattery connections. Proceed to Step 2.2. Access converter, remove converter cover plateby removing (1) retaining screw.Check for 12-volts DC between the positive andnegative lugs on converter. Is voltage present?(Yes) Proceed to Step 7. (No) Proceed to Step 3.3. Check for 12-volts DC on Wire J at load center.Is voltage present? (Yes) Troubleshoot Wire Mback to converter to determine cause of voltageloss. Repair or replace as necessary. (No)Proceed to Step 4.4. Check for 12-volts DC on Wire J at the circuitbreaker located in the auxiliary batterycompartment. Is voltage present? (Yes)Troubleshoot Wire J back to the load center todetermine cause of voltage loss. Repair orreplace as necessary. (No) Proceed to Step S.S. Check for 12-volts DC on Wire A at circuitbreaker located in the auxiliary batterycompartment. Is voltage present? (Yes) Proceedto Step 6. (No) Troubleshoot circuit back tobattery to determine cause of voltage loss.Repair or replace as necessary.6. Reset the circuit breaker by removing Wire A,then reconnect Wi re A.7. Connect vehicle to 110-volt AC power. Checkvoltage at positive and negative lugs of theconverter. Voltage should rise to 13-volts DC orhigher. If it does not, proceed to Step 8.NOTE: In time, the system voltage should rise to14-volts DC with no loads on. Depending onbattery condition, it could take 24 hours tocompletely recharge the battery.8. Check both converter ground circuits. Ifgrounds are good, converter is defective.~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~1-30~~
SECTION 1ELECTRICALCONVERTER REMOVAL~ 1. Turn ignition key to the OFF position.~ 2. Disconnect vehicle from 110-volt AC power.3. Remove left dinette seat. Reference "Dinette Seat Removal" in Interior Section.4. Remove left dinette cover panel. Reference "Left Dinette Cover Panel Removal" in Interior Section.5. U npl ug converter.6. Open converter access panel by removing (1) retaining screw.7. Note location of black wire and green wire for ease of later installation. Disconnect wires, loosen wireconnector at converter, and pull wires free. Disconnect case ground wire.Do NOT let black wire short to ground.CAUTION8. Remove (4) converter retaining screws. Remove converter.CONVERTER REPLACEMENT1. Place converter into position. Secure with (4) retaining screws.2. Insert connector and wires into converter.3. Connect wires as noted in Step 7 of "Converter RemovaL" Secure connector.4. Replace converter access panel and secure with (1) retaining screw.5. PI ug i n converter.6. Replace left dinette cover panel. Reference "Left Dinette Panel Cover Replacement" in Interior Section.7. Replace left dinette seat. Reference "Dinette Seat Replacement" in Interior Section.1-31
Page 1 and 2: RIAL TA SERVICE MANUAL701674-19-000
Page 3: ~~~~~~~~~~~~~fA~~~~~~~~r-'~~~~~~~,.
Page 6 and 7: ~ !
Page 8 and 9: SECTION 0GENERAL INFORMATIONimprope
Page 10 and 11: SECTION 0GENERAL INFORMATIONCONVERS
Page 12 and 13: SECTION 0GENERAL INFORMATIONCONVERS
Page 14 and 15: ~~~~~~~~~~SECTION 0GENERAL INFORMAT
Page 16 and 17: ~~~~~~~~~~~~~~~~SECTION 0GENERAL IN
Page 18 and 19: ~~~~~~~~~~~~~~~~~~~.~~~~~~~~~~~~~~~
Page 20 and 21: ~SECTION 1ELECTRICAL~~~~~~~~~~~~~~~
Page 22 and 23: J J J J J J J J J j ]J J j J J J j
Page 24 and 25: ~~~~~~~~~~SECTION 1ELECTRICALSympto
Page 26 and 27: SECTION 1ELECTRICAL110-VoltCircuit
Page 28 and 29: SECTION 1ELECTRICAL~~~SYMPTOMCOURSE
Page 30 and 31: SECTION 1ELECTRICALLOAD CENTER REMO
Page 32 and 33: ~~~~~~~SECTION 1ELECTRICAL~~i\vc:=a
Page 34 and 35: SECTION 1ELECTRICALNOTE; WHEN INSTA
Page 36 and 37: ~~~-'='i~SECTION 1ELECTRICALGFI TES
Page 38 and 39: ~~~~~SECTION 1ELECTRICALSYMPTON1. I
Page 40 and 41: -INm '" r- mmqq-;QO-z~r-w..-LUl,FII
Page 42 and 43: SECTION 1ELECTRICAL~,~LITMT amr:Hfd
Page 44 and 45: J J J J J J J J J J J J J J J J J J
Page 46 and 47: SECTION 1ELECTRICALAUXILIARY BATTER
Page 50 and 51: SECTION 1ELECTRICALAUXILIARY START
Page 52 and 53: SECTION 1ELECTRICALSYMPTONTROUBLESH
Page 54 and 55: SECTION 1ELECTRICALSYMPTOMCOURSE OF
Page 56 and 57: ~SECTION 1ELECTRICALFor Fresh Water
Page 58 and 59: SECTION 1ELECTRICALREAR WINDOW WIPE
Page 60 and 61: ~~~SECTION 1ELECTRICAL~~TROUBLESHOO
Page 62 and 63: ~~~~~~~~~~~~SECTION 1ELECTRICAL~~~r
Page 64 and 65: SECTION 1ELECTRICAL~~~~~SYMPTOMCOUR
Page 66 and 67: ~~~SECTION 1ELECTRICALREAR WIPER MO
Page 70 and 71: ~~~~SECTION 1ELECTRICAL~~~SYMPTOMCO
Page 72 and 73: ~SECTION 1ELECTRICAL~~SYMPTOMCOURSE
Page 74 and 75: ~SECTION 1ELECTRICALTROUBLESHOOTING
Page 76 and 77: SECTION 1ELECTRICAL~~~~~~~~~~~~~~~~
Page 78 and 79: ~~~~~~~~~~~~~~~~SECTION 1ELECTRICAL
Page 80 and 81: j j J J J J J J J J J J j j J J J J
Page 84 and 85: J J J J J J J J J J J J j J J J J J
Page 86 and 87: ~SECTION 1ELECTRICAL~~WIREAAABACFRO
Page 88 and 89: ~-,SECTION 1ELECTRICAL~~~WIRECAFuse
Page 90 and 91: SECTION 1ELECTRICAL~~~WIREEAEBECEDH
Page 92 and 93: ~SECTION 1ELECTRICAL~~WIREGAFROMWip
Page 94 and 95: SECTION 1ELECTRICAL~~~WIREJAFROMCon
Page 96 and 97: SECTION 1ELECTRICALWIRELALBLCRadioR
Page 98 and 99:
~SECTION 1ELECTRICAL~~WIRENAFROMHea
Page 100 and 101:
SECTION 1ELECTRICALWIRERARBFROMTurn
Page 102 and 103:
~SECTION 1ELECTRICAL~~WIREFROMTA Fu
Page 104 and 105:
~SECTION 1ELECTRICAL~~WIREWAWBFROME
Page 106 and 107:
~~~~~~SECTION 1ELECTRICAL~~WIREYAYB
Page 108 and 109:
~SECTION 2TABLE OF CONTENTS~~SECTIO
Page 110 and 111:
SECTION 2EXTERIOR BODY. '-ROCF ASMW
Page 112 and 113:
J J J J J J J J J j j J J J j J j j
Page 114 and 115:
~SECTION 2EXTERIOR BODYTransition P
Page 116 and 117:
SECTION 2EXTERIOR BODYRear Cap Repl
Page 118 and 119:
SECTION 2EXTERIOR BODYGECTlOM v-v(A
Page 120 and 121:
SECTION 2EXTERIOR BODYRight Wheel L
Page 122 and 123:
SECTION 2EXTERIOR BODYValance Panel
Page 124 and 125:
SECTION 2EXTERIOR BODYSee Panel & T
Page 126 and 127:
Page 128 and 129:
~SECTION 2EXTERIOR BODYSee Panel &
Page 130 and 131:
Page 132 and 133:
PRm)SECTION 2EXTERIOR BODYSee Panel
Page 134 and 135:
Page 136 and 137:
~SECTION 2EXTERIOR BODYSee Panel &
Page 138 and 139:
~SECTION 2EXTERIOR BODY~~~ TCIIII1C
Page 140 and 141:
SECTION 2EXTERIOR BODYRear Bumper R
Page 142 and 143:
SECTION 2EXTERIOR BODY3. Remove dra
Page 144 and 145:
SECTION 2EXTERIOR BODYNOTE : Use of
Page 146 and 147:
SECTION 2EXTERIOR BODY15. Remove ma
Page 148 and 149:
SECTION 2EXTERIOR BODYRoof ReskinA
Page 150 and 151:
SECTION 2EXTERIOR BODYR~3 ~~ !e. ~I
Page 152 and 153:
SECTION 2EXTERIOR BODY~~~~~~~SECTIO
Page 154 and 155:
SECTION 2EXTERIOR BODYRoof Replacem
Page 156 and 157:
SECTION 2EXTERIOR BODYStep 7 • Sa
Page 158 and 159:
SECTION 2EXTERIOR BODY18. Apply adh
Page 160 and 161:
SECTION 2EXTERIOR BODYSidewall Repl
Page 162 and 163:
~SECTION 2EXTERIOR BODYStep 8 • C
Page 164 and 165:
SECTION 2EXTERIOR BODYStep 8 • Sa
Page 167 and 168:
wo~oc-
Page 169 and 170:
SECTION 3BODY OPENINGSStationary an
Page 171 and 172:
SECTION 3BODY OPENINGSEscape Window
Page 173 and 174:
SECTION 3BODY OPENINGSRoof VentThe
Page 175 and 176:
e-',..~"...(P'~~~~~~,...~~~f"'"""
Page 177 and 178:
~~~~F'~~~~~~~~~~~~~~~~F'~~~~~~~~~~~
Page 179:
-~r'"~~~~~~~~~~~r"rr~r'"~r~~,
Page 182 and 183:
SECTION 4INTERIORR~Dome Light 4-16R
Page 185 and 186:
lEA''''tiJ TlQfTllt I III NNI N'mII
Page 187 and 188:
SECTION 4INTERIORREAR EDGE CFFRONT
Page 189 and 190:
SECTION 4INTERIORDriver or Passenge
Page 191 and 192:
~~~(F'~~~~~~~~r'"~~F'~~~~~~(P'Seat
Page 193 and 194:
SECTION 4INTERIOR. RH CABU£ T ASN
Page 195 and 196:
SECTION 4INTERIORDinette Assembly R
Page 197 and 198:
~,.,.~~~~~~~~~F'~~~~~~,.~~.~~~~~~r"
Page 199 and 200:
SECTION 4INTERIORSun VisorsSunvisor
Page 201 and 202:
~~~~~~~~~~~,..~~~~~~~~~~~~F~~~~~~~~
Page 203 and 204:
~~~~~~~(P'~~~~~~~~Soft Cloth Headli
Page 205 and 206:
~~~~""~~~~~~~~~(P'SECTION 4INTERIOR
Page 207 and 208:
SECTION 4INTERIORLOWER BACKWALL PAN
Page 209 and 210:
~~~~~~~~~~~~~~~~~~~~~~~~fP\F'~~~~r'
Page 211 and 212:
SECTION 4INTERIOREntrance Door Vala
Page 213 and 214:
SECTION 4INTERIORLEFT FRONTOVERHEAD
Page 215 and 216:
SECTION 4INTERIORLEFT REAROVERHE AD
Page 217 and 218:
~~SECTION 4INTERIOR~~~~F'r'"~~r-'
Page 219 and 220:
Frr'"~~~(F'~~~~~~~~~Galley Cabinet
Page 221 and 222:
o.~~~~,.~~~~~(P'Galley Countertop R
Page 223 and 224:
~Fr~~~~~~~~~10. Remove motor-aid co
Page 225 and 226:
t-CABJ"U JNSTl-BATK-m""~qm-:::0 0(5
Page 227 and 228:
~~~~~~~~,....f!'A~See art on page 4
Page 229 and 230:
"~r'"~~~~~~~~~~~~~~~~~~r-'~~~~~~~~P
Page 231 and 232:
~~rs'~~~~~r"~~~~~~~~~~~~~~~~~~~~~r"
Page 233 and 234:
SECTION 4INTERIORSee art on page 4-
Page 235 and 236:
SECTION 4INTERIORShower Back Surrou
Page 237:
,..~~~~,..~~~~~~~,...,..~F~~~~~~,..
Page 241 and 242:
SECTION 5LP GAS FUEL SYSTEMI U IU\M
Page 243 and 244:
SECTION 5LIQUID PROPANE SYSTEMLP TA
Page 245 and 246:
SECTION 5LIQUID PROPANE SYSTEM4. Wi
Page 247 and 248:
SECTION 5LIQUID PROPANE SYSTEM3. Co
Page 249 and 250:
SECTION 5LIQUID PROPANE SYSTEM3. Co
Page 251 and 252:
~~~~~~~~~~~~~~f!'"F'F"'"r"F'~~(P>'~
Page 253 and 254:
-'F'~~~~~~~~~f!P'~~~~~~e-'~~~~r'"~r
Page 255 and 256:
~~~fF'F'~~~~~~~~~~~~~~~~~~fP'~e:-
Page 257 and 258:
SECTION 6APPLIANCESRANGERANGEThe tw
Page 259 and 260:
SECTION 6APPLIANCESFURNACEThe furna
Page 261 and 262:
SECTION 6APPLIANCESELECTRONIC IGNIT
Page 263 and 264:
,.~~~~r"'"~r"'"~~~~r-'~~~~~~~~. r"~
Page 265 and 266:
~~~~~~~~~~~~~~~~~"..~~~~~~~(IR'~~~~
Page 267 and 268:
,..~~e-'~(P"~~~~~~~~~~~,...(ff"A,..
Page 269 and 270:
SECTION 6APPLIANCESConditionCourse
Page 271 and 272:
~~~SECTION 6APPLIANCES~~~~~~~5.Cond
Page 273 and 274:
~~~~~r-'~~~~r"~r-'~~~~~~~~~~~~~~~~~
Page 275 and 276:
SECTION 6APPLIANCESLocal Flame Sens
Page 277 and 278:
~,.,..~r'"~~~~r-'~~~~~~F'~~~r'"~~~~
Page 279 and 280:
SECTION 6APPLIANCESLocation of Oper
Page 281 and 282:
SECTION 6APPLIANCESImportant Safety
Page 283 and 284:
~SECTION 6APPLIANCES~~~~~~~~~~~WIRI
Page 285 and 286:
~~~~(P'~~~~~,...(P\~~~~~~~,...~(R'~
Page 287 and 288:
~~~~~~~~~~~~~~~~~,...~f'"~r'"(P'~
Page 289 and 290:
SECTION 6APPLIANCESCondition3. Refr
Page 291 and 292:
m'~R~SECTION 6~APPLIANCESfH""F'~~~~
Page 293 and 294:
~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~
Page 295 and 296:
~~~~~~~F'~~F'~~~~~~~~~~(ffA~~~~~(B'
Page 297 and 298:
~~~~r-'~~~"" ~~~~~~~~f!""~~"...~~~~
Page 299 and 300:
,.~~~~ELECTRIC WATER HEATERSECTION
Page 301 and 302:
SECTION 6APPLIANCESCondition2. Exce
Page 303 and 304:
r'"~~~f!A~~~~~(PI'r'"~~~~~~("'A.
Page 305 and 306:
~~~~(P'~~~~r-'~~f"~~~f"(:P'~r'"e-'~
Page 307 and 308:
SECTION 6APPLIANCESTROUBLESHOOTING
Page 309 and 310:
~~~r-'~r'"~e--~~~ROOF AIR CONDITION
Page 311 and 312:
SECTION 6APPLIANCESTROUBLESHOOTINGC
Page 313 and 314:
~~(F'("A~(PI~(F'~~~~~~~(PI~~~~~~~~(
Page 315 and 316:
SECTION 6APPLIANCESTROUBLESHOOTINGC
Page 317 and 318:
~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~
Page 319 and 320:
~~~~~(""'A~~~fA,...~~"..~~~~~(PJ\,.
Page 321 and 322:
~~~("'AROOF TOP AIR CONDITIONER REM
Page 323 and 324:
SECTION 6APPLIANCESMICROWAVE REMOVA
Page 325:
SECTION 6APPLIANCESTELEVISION ANTEN
Page 329 and 330:
~,....~~~~~~~~~F'r'"~~F'~~~~e!'"~~~
Page 331 and 332:
f!A~~~~~~~~~~~~~(""~~fP"~~~~~~~~~
Page 333 and 334:
SECTION 7PLUMBINGCity Water Hook-Up
Page 335 and 336:
f~~,..~~~~~SECTION 7PLUMBING~~~~~~(
Page 337 and 338:
SECTION 7PLUMBINGBATHROOM FAUCET RE
Page 339 and 340:
SECTION 7PLUMBING(R) Stem(0) Lever(
Page 341 and 342:
SECTION 7PLUMBINGWATER PUMPThe wate
Page 343 and 344:
~~~"'" fPASECTION 7PLUMBING~~~~~e:-
Page 345 and 346:
SECTION 7PLUMBINGBATHROOM SINK REMO
Page 347 and 348:
SECTION 7PLUMBINGTROUBLESHOOTING SH
Page 349 and 350:
~~SECTION 7PLUMBING~~~~~(P"F'r-'~
Page 351 and 352:
SECTION 7PLUMBINGGrey Waste Water T
Page 353 and 354:
SECTION 7PLUMBINGBlack Waste Water
Page 355 and 356:
SECTION 7PLUMBINGBlack Water Tank E
Page 357 and 358:
SECTION 7PLUMBING11. Operate toilet
Page 359 and 360:
SECTION 8AUTOMOTIVETABLE OF CONTENT
Page 361 and 362:
SECTION 8AUTOMOTIVEAUTOMOTIVE AIR C
Page 363 and 364:
~~~~~~~~~,....e-'~~(PA~~r""e-',...~
Page 365 and 366:
SECTION 8AUTOMOTIVEAUTOMOTIVE AIR C
Page 367 and 368:
SECTION 8AUTOMOTIVEREMOVAL AND REPL
Page 369 and 370:
,.,..~~,..~~,.,.~~~~~~~~~~~r-',.~~~
Page 371 and 372:
,.,.~~~(P!'e,.~,....,.~~~"...~~~,
Page 373 and 374:
~f!A~~~~~~,-..~~~~~~~~~(PA~~"..~~~f
Page 375 and 376:
SECTION 8AUTOMOTIVEOVERHEAD EVAPORA
Page 377 and 378:
-~~~~~~~~~~~~~~~~~r"'~~~~~~F'~~~~
Page 379 and 380:
SECTION 8AUTOMOTIVEStep BTest indic
Page 381 and 382:
SECTION 8AUTOMOTIVEWHEELWheel Remov
Page 383 and 384:
~~SECTION 8AUTOMOTIVE~~f!""A~r-'~~W
Page 385 and 386:
e.~~~~~~~(",...r'"~~~~~~~~~~~~~~~~~
Page 387 and 388:
SECTION 8AUTOMOTIVE3253/18-27
Page 389 and 390:
~~~~~~~~~~~~~~~~~~~~~~~~~~r"~F'F'~~
Page 391 and 392:
~~~~~~~~~~rFr'"~~~~~~~~~~~~~~~~F~~~
Page 393 and 394:
~~~SECTION 8AUTOMOTIVE~(PI~~F',..~B
Page 395 and 396:
~~F~~~F~~~~~~~~r'~~~~~~~(F'~~~~F'~~
Page 397 and 398:
BRAKE III$TL-PARK>C-t",oms:q0--to
Page 399 and 400:
SECTION 8AUTOMOTIVECAUTIONAdjusting
Page 401 and 402:
SECTION 8AUTOMOTIVERear Shock Remov
Page 403 and 404:
SECTION 8AUTOMOTIVEREAR AXLE REPLAC
Page 405 and 406:
SECTION 8AUTOMOTIVEREAR AIR BAGSThe
Page 407 and 408:
,..r~r'"~~~~~(F'~~e-''" ~~~~~~~.~(F
Page 409 and 410:
SECTION 8AUTOMOTIVEMETALWASHEORILLA
Page 411 and 412:
~~~F~F'~"" ~~~~~~~~~f'"~~~~~~~~~r-'
Page 413 and 414:
~~~~~~~~~~,...~~~~~~r"~~~~~~~~~~~~e
Page 415 and 416:
APPENDIX ASERVICE TOOLSThe followin
Page 417 and 418:
5. Glass Insert Tool. Used to insta
Page 419 and 420:
APPENDIX CWinnebagoDescription Part
Page 421 and 422:
APPENDIX ECAPACITOR TEST PROCEDUREC
Page 423 and 424:
,..r-'~~~~USE OF GLASS INSERT TOOL1
Page 425 and 426:
~,... APPENDIX H~~ DUPONT PAINT COD
Page 427 and 428:
APPENDIX JBODY BOARD CONSTRUCTIONPL
Page 429 and 430:
DRIVER'S SIDEPASSENGER'S SIDE
Page 431 and 432:
APPENDIX LCOMPRESSOR MOTOR CHECK PR
Page 433 and 434:
Fr'~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~
show all

Rialta Service Manual - RialtaInfo

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?