Piaggio-Typhoon-50-EN _Service Manual

Recommendations

Info

Maintenance Typhoon 50 Hub oil level - check Spark plug/electrode gap - replacement Air filter - cleaning Oil mixer/throttle linkage - adjustment Drive belt - replacement Brake levers - greasing Brake pads - check condition and wear Brake fluid level - check Electrical system and battery - check Tyre pressure and wear - check SAS box (sponge) (**) - cleaning Vehicle test and brake test - Road test (**) See regulations in the «Secondary air system» section Action 110' Hub oil - change Spark plug/electrode gap - replacement Air filter - clean Idling speed (*) - adjustment Cylinder cooling system - check/cleaning Oil mixer/throttle linkage - adjustment Drive belt - check Variable speed rollers - replacement Mixer belt - replacement Odometer gear - greasing Steering - adjustment Brake levers - greasing Brake pads - check condition and wear Brake fluid level - check Transmission - lubrication Safety fasteners - check Suspensions - check Electrical system and battery - check Headlight - adjustment Tyre pressure and wear - check Vehicle test and brake test - Road test (*) See section «Adjusting the idle speed» AFTER 20000 KM AND 40000 KM Action 130' Hub oil - change Spark plug/electrode gap - replacement Air filter - clean Idling speed (*) - adjustment Oil mixer/throttle linkage - adjustment Drive belt - replacement Variable speed rollers - replacement Odometer gear - greasing Steering - adjustment Brake levers - greasing Brake pads - check condition and wear Flexible brake tubes - replacement Brake fluid level - check Transmission - lubrication Safety fasteners - check Suspensions - check Electrical system and battery - check Headlight - adjustment Tyre pressure and wear - check SAS box (sponge) (**) - cleaning Vehicle test and brake test - Road test AFTER 30000 KM Action MAIN - 24
Typhoon 50 Maintenance (*) See regulations in the «Adjusting the idle speed» section (**) See regulations in the «Secondary air system» section 150' Hub oil - change Spark plug/electrode gap - replacement Air filter - clean Idling speed (*) - adjustment Cylinder cooling system - check/cleaning Oil mixer/throttle linkage - adjustment Drive belt - replacement Variable speed rollers - replacement Mixer belt - replacement Odometer gear - greasing Steering - adjustment Brake levers - greasing Brake pads - check condition and wear Flexible brake tubes - replacement Brake fluid level - check Transmission - lubrication Safety fasteners - check Suspensions - check Electrical system and battery - check Headlight - adjustment Tyre pressure and wear - check SAS box (sponge) (**) - cleaning Vehicle test and brake test - Road test (*) See regulations in the «Adjusting the idle speed» section (**) See regulations in the «Secondary air system» section AFTER 60000 KM Action Checking the spark advance -Check to be made at over 4000 rpm with stroboscopic gun. The advanced ignition measured must be 17° before the TDC. - This value is correct when the reference mark on the flywheel hood is aligned with the reference mark on the cooling fan and the phase shifter on the stroboscopic gun is set on 17°. N.B. IN CASE OF MALFUNCTION, CARRY OUT THE CHECKS PROVIDED FOR IN THE ELECTRICAL SYSTEM CHAPTER. CAUTION BEFORE CARRYING OUT THE ABOVE CHECKS, CHECK THE CORRECT KEYING OF THE FLYWHEEL ON THE CRANKSHAFT. Specific tooling 020330Y Stroboscopic light to check timing MAIN - 25
Page 1 and 2: SERVICE STATION MANUAL 633665 - . .
Page 3 and 4: SERVICE STATION MANUAL Typhoon 50 T
Page 5 and 6: INDEX OF TOPICS CHARACTERISTICS CHA
Page 7 and 8: Typhoon 50 Characteristics Vehicle
Page 9 and 10: Typhoon 50 Characteristics Frame an
Page 11 and 12: Typhoon 50 Characteristics Overhaul
Page 13 and 14: Typhoon 50 Characteristics Slot pac
Page 15 and 16: Typhoon 50 Tooling Stores code 0013
Page 23: Typhoon 50 Maintenance Maintenance
Page 27 and 28: Typhoon 50 Maintenance Check Do the
Page 29 and 30: Typhoon 50 Maintenance erence mark
Page 31 and 32: Typhoon 50 Maintenance 2. Turn on t
Page 33 and 34: Typhoon 50 Troubleshooting This sec
Page 35 and 36: Typhoon 50 Troubleshooting High fue
Page 37 and 38: Typhoon 50 Troubleshooting Excessiv
Page 39 and 40: Typhoon 50 Electrical system Key Ke
Page 41 and 42: Typhoon 50 Electrical system Igniti
Page 43 and 44: Typhoon 50 Electrical system Batter
Page 45 and 46: Typhoon 50 Electrical system Turn s
Page 47 and 48: Typhoon 50 Electrical system RECHAR
Page 49 and 50: Typhoon 50 Electrical system to be
Page 51 and 52: Typhoon 50 Electrical system • Re
Page 53 and 54: Typhoon 50 Electrical system Specif
Page 55 and 56: INDEX OF TOPICS ENGINE FROM VEHICLE
Page 57 and 58: INDEX OF TOPICS ENGINE ENG
Page 59 and 60: Typhoon 50 Engine - Remove the seeg
Page 61 and 62: Typhoon 50 Engine - Using a 34 mm s
Page 63 and 64: Typhoon 50 Engine Stationary driven
Page 65 and 66: Typhoon 50 Engine - Reassemble the
Page 67 and 68: Typhoon 50 Engine 4) Check the inte
Page 69 and 70: Typhoon 50 Engine Removing the whee
Page 71 and 72: Typhoon 50 Engine Refitting the whe
Page 73 and 74: Typhoon 50 Engine Removing the stat
Page 75 and 76:
Typhoon 50 Engine Refitting the fly
Page 77 and 78:
Typhoon 50 Engine Inspecting the sm
Page 79 and 80:
Typhoon 50 Engine Removing the pist
Page 81 and 82:
Typhoon 50 Engine Install the speci
Page 83 and 84:
Typhoon 50 Engine Refitting the cra
Page 85 and 86:
Typhoon 50 Engine Lubrication Crank
Page 87 and 88:
Typhoon 50 Engine OF THE TUBE. IN T
Page 89 and 90:
Typhoon 50 Suspensions Front suspen
Page 91 and 92:
Typhoon 50 Suspensions See also Han
Page 93 and 94:
Typhoon 50 Suspensions Steering col
Page 95 and 96:
Typhoon 50 Suspensions 020055Y Wren
Page 97 and 98:
INDEX OF TOPICS BRAKING SYSTEM BRAK
Page 99 and 100:
Typhoon 50 Braking system • Inser
Page 101 and 102:
Typhoon 50 Braking system If the va
Page 103 and 104:
Typhoon 50 Braking system Front -On
Page 105 and 106:
INDEX OF TOPICS CHASSIS CHAS
Page 107 and 108:
Typhoon 50 Chassis Frame central co
Page 109 and 110:
Typhoon 50 Chassis Side fairings
Page 111 and 112:
Typhoon 50 Chassis Helmet bay • R
Page 113 and 114:
INDEX OF TOPICS PRE-DELIVERY PRE DE
Page 115 and 116:
Typhoon 50 Pre-delivery CAUTION TO
Page 117 and 118:
INDEX OF TOPICS TIME TIME
Page 119 and 120:
Typhoon 50 Time Crankcase CRANKCASE
Page 121 and 122:
Typhoon 50 Time Cylinder assy. CYLI
Page 123 and 124:
Typhoon 50 Time Driven pulley DRIVE
Page 125 and 126:
Typhoon 50 Time Final gear assy. FI
Page 127 and 128:
Typhoon 50 Time Transmission cover
Page 129 and 130:
Typhoon 50 Time Flywheel magneto MA
Page 131 and 132:
Typhoon 50 Time Carburettor CARBURE
Page 133 and 134:
Typhoon 50 Time Air cleaner AIR FIL
Page 135 and 136:
Typhoon 50 Time Legshield spoiler F
Page 137 and 138:
Typhoon 50 Time Underseat compartme
Page 139 and 140:
Typhoon 50 Time Mudguard REAR MUDGU
Page 141 and 142:
Typhoon 50 Time Rear shock-absorber
Page 143 and 144:
Typhoon 50 Time Handlebar component
Page 145 and 146:
Typhoon 50 Time Swing-arm SWINGING
Page 147 and 148:
Typhoon 50 Time Instrument panel IN
Page 149 and 150:
Typhoon 50 Time REAR LIGHT Code Act
Page 151 and 152:
Typhoon 50 Time Rear wheel REAR WHE
Page 153 and 154:
Typhoon 50 Time ELECTRICAL SYSTEM C
Page 155 and 156:
Typhoon 50 Time Transmissions SPLIT
Page 157 and 158:
Typhoon 50 Time Front suspension FO
Page 159 and 160:
A Air filter: 28 B Battery: 36, 43,
show all

Piaggio-Typhoon-50-EN _Service Manual

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?