Engine Air Cleaners, Intake Accessories and ... - Giro Servicios CA

Recommendations

Info

Radial Seal Air Cleaners EPG for Light Dust Conditions Airflow pattern “G” Air in the side, out the end EPG Specification Illustrations 11" Models EPG Specifications When spec’ing an EPG Air Cleaner... Determine the airflow requirements of your engine, then find the corresponding cfm airflow in the table at right. The restriction numbers (shown in inches of water) indicate the approximate initial restriction of each model air cleaner at that cfm. If there are two air cleaner models that fit your parameters, choosing the one with the lowest restriction will provide the longest filter service life. When calculating total initial restriction of the entire air intake system, include the restriction caused by ducting, elbows, pre-cleaners, etc. Body Inlet Outlet Part Diameter Diameter Diameter Length Number (C) (A) (B) (D) (G) in mm in mm in mm in mm in mm G110119 10.86 276 5.50 140 5.00 127 12.89 327 8.56 217 G110120 10.86 276 5.50 140 5.00 127 12.89 327 8.56 217 G130079 12.62 321 6.00 152 5.00 127 16.02 407 9.51 242 G130089 12.62 321 6.00 152 5.00 127 16.02 407 9.51 242 G150048 14.62 371 7.00 178 7.00 178 15.75 400 10.19 259 G150049 14.62 371 7.00 178 7.00 178 15.75 400 10.19 259 Part Outlet Length Number (F) (E) (H) (I) (J) (K) (L) in mm in mm in mm in mm in mm in mm in mm G110119 G110120 1.95 1.95 50 50 6.00 6.00 152 152 See drawing above for dimensions on 11" models G130079 3.00 76 5.66 144 7.75 197 2.00 51 8.00 203 4.00 102 6.00 152 G130089 3.00 76 5.66 144 7.75 197 2.00 51 8.00 203 4.00 102 6.00 152 G150048 1.82 46 7.00 178 7.50 191 4.12 105 8.50 216 4.25 108 8.00 203 G150049 1.82 46 7.00 178 7.50 191 4.12 105 8.50 216 4.25 108 8.00 203 Initial Initial Restriction Restriction Restriction Airflow Model No. Models with Primary Filter Only 625 cfm @ 4.25" H20 G110119 650 cfm @ 6" H20 G130089 800 cfm @ 5.5" H20 G150049 Models with Primary & Safety Filter 450 cfm @ 5.5" H20 G110120 950 cfm @ 8" H20 G130079 1325 cfm @ 10" H20 G150048 13" & 15" Models 24 Engine Air Cleaners, Accessories & Service Parts www.donaldson-filters.com
EPG Service Parts G110119 cover ............................................... P529151 fastener kit ..................................... X006452 filter, primary - SM ........................ P527484 ....... 3 filter, primary - ES & HE ............... EAF5067 filter, safety .................................... P527680 ....... 4 thumb screw ................................. P527435 G110120 cover ............................................... P529151 fastener kit ..................................... X006452 filter, primary - SM ........................ P527484 ....... 3 filter, primary - ES & HE ............... EAF5067 filter, safety .................................... P527680 ....... 3 thumb screw ................................. P527435 G130079 cover ............................................... P533916 fastener kit ..................................... X006452 filter, primary ................................. P533930 ....... 3 filter, safety .................................... P533890 ....... 4 thumb screw ................................. P527435 G130089 cover ............................................... P533916 fastener kit ..................................... X006452 filter, primary ................................. P533930 ....... 3 filter, safety .................................... P533890 ....... 3 thumb screw ................................. P527435 G150048 cover ............................................... P523096 fastener kit ..................................... X006452 filter, primary - SM ........................ P527682 ....... 3 filter, primary - ES & HE ............... EAF5069 filter, safety .................................... P527683 ....... 4 thumb screw ................................. P527435 G150049 cover ............................................... P523096 fastener kit ..................................... X006452 filter, primary - SM ........................ P527682 ....... 3 filter, primary - ES & HE ............... EAF5069 filter, safety .................................... P527683 ....... 3 thumb screw ................................. P527435 NOTES: 3 = Shipped with air cleaner initially 4 = Safety filter is designed to fit this air cleaner, but was not originally shipped with it (note that adding a safety filter will decrease the maximum airflow throughput) ES = Extended Service HE = High Efficiency SM= Scheduled Maintenance Air Cleaner Housing Outlet to Engine 11" Model Shown Molded-in Mounting Flange Air Inlet EPG for Light Dust Conditions Primary Filter Safety Filter is inside Primary Filter (not visible in this photo) Thumb Screw Vacuator Valve: The Better Alternative to Drain Holes for Avoiding Moisture Ingestion The Donaldson Vacuator Valve is an optional accessory for the EPG that expels water from the air cleaner before any reaches the filter – thereby extending filter life. Bare drain holes can clog or take in backsplash, but the Vacuator Valve never does! The P525956 is a 1" (25mm) diameter model designed for over-highway applications. Installation is fast and easy: 1. 1. 1. Locate the lowest point of the air cleaner to allow proper drainage through Vacuator Valve. 2. 2. 2. Remove filter(s) before drilling. 3. 3. 3. Drill a 1" (25mm) hole centered at the lowest point of the air cleaner as shown in illustration. Remove debris from drilling. 4. 4. 4. Install Vacuator Valve (part no. P525956) by pushing it into the hole. 5. 5. Reinstall filter(s), reattach cover. Access Cover for filter service Thumb Screw Fastener Kit X006452 (Includes Fasteners and 1 Thumb Screw) www.donaldson-filters.com Engine Air Cleaners, Accessories & Service Parts 25 Radial Seal Air Cleaners
Page 1 and 2: Engine Air Cleaners, Intake Accesso
Page 3 and 4: Donaldson filters are built to prov
Page 5 and 6: Innovative Engineering Air Cleaners
Page 7 and 8: Donaldson Filters Lasting Value Don
Page 9 and 10: Air Cleaner Finishes ...Donaldson a
Page 11 and 12: The objective... 1. Minimize the nu
Page 13 and 14: y Air Flow Pattern A = Air in the E
Page 15 and 16: Engine Data The data shown in this
Page 17 and 18: -- Exhaust -- Engine Intake Temp. F
Page 23 and 24: RadialSeal A Better Approach To Sea
Page 25: EPG for Light Dust Conditions Provi
Page 29 and 30: Airflow pattern “A” Air in the
Page 31 and 32: FPG Offers Advanced Sealing Technol
Page 33 and 34: Airflow pattern “G” Air in the
Page 35 and 36: Donaldson offers two styles of moun
Page 37 and 38: FRG: Superior Protection for Larger
Page 41 and 42: FRG Service Parts Style A Access Co
Page 43 and 44: Axial Seal Air Cleaners Axial seal
Page 45 and 46: EBA Konepac Service Parts (KPII sty
Page 49 and 50: EBB Provides Versatile Mounting Cap
Page 51 and 52: Horizontal Mount, Integral Vacuator
Page 53 and 54: STG Donaclone: Field Proven & Relia
Page 55 and 56: STG Donaclone �� for Heavy D
Page 57 and 58: STG Service Parts Tubular Inlet Sty
Page 59 and 60: SRG Donaclone �� for Heavy Dust
Page 61 and 62: SRG29 Service Parts Body Gasket Str
Page 63 and 64: STB Strata �� for Heavy Dust Co
Page 65 and 66: When spec’ing a DuraLite Air Clea
Page 67 and 68: Donaldson Intake Accessories The ac
Page 69 and 70: Horizontal, In-Line Moisture Skimme
Page 71 and 72: Mounting Bands for Air Cleaners Man
Page 73 and 74: Inlet Hood - Style C Inlet Hoods Fi
Page 75 and 76: The lnformer for Graduated, Contin
Page 77 and 78:
Service Gauge for Instrument Panel
Page 79 and 80:
These flexible rubber adapters and
Page 81 and 82:
Rubber Products Rubber Straight Hum
Page 83 and 84:
Replacement Vacuator Valves Replace
Page 85 and 86:
Standard Style Engine Scavenge Ejec
Page 87 and 88:
Air Stack Extensions Helps Extend F
Page 89 and 90:
Performance Curves Dimensional Spec
Page 91 and 92:
Service Parts by Air Cleaner Model
Page 93 and 94:
Air Cleaner Part No./Style Descript
Page 95 and 96:
Air Cleaner Part No./Style Descript
Page 97 and 98:
Proper Air Cleaner Service is Essen
Page 99 and 100:
Filtration Micron ratings are commo
Page 101 and 102:
Will-Fit Filters are Often Won’t
Page 103 and 104:
Don’t remove filter for inspectio
Page 105 and 106:
Remove the old 1 filter gently “B
Page 107 and 108:
Axial Seal Service Instructions Two
Page 109 and 110:
Positioning the Strata Pre-Cleaner
Page 111 and 112:
Index of All Parts by Part Number W
Page 113 and 114:
Part Page No. No. Product Descripti
Page 116:
Your Your Donaldson Donaldson Distr
show all

Engine Air Cleaners, Intake Accessories and ... - Giro Servicios CA

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?