Aspire 7230/7530/7530G Series Service Guide - tim.id.au

More documents

Recommendations

Info

Memory Card Reader Item Specification Type Realtek RTS5158E (One-LUN USB 2.0 Card Controller) Package 48-pin LQFP (size= 9x9mm) Features • The RTS5158E is an ultimate throughput USB 2.0 compliant card reader controller that integrates USB 2.0 Transceiver, MCU, SIE, regulators and memory card access units into a single chip. • The RTS5158E can support Memory Stick, Memory Stick Pro, Memory Stick PRO-HG Duo, Secure Digital, Multi-Media Card and xD-Picture Card, but only 1-LUN configuration, i.e.only one of these memory cards can be inserted into RTS5158E system at the same time.· • Compliant with Universal Serial Bus Specification Revision 2.0· • Compliant with USB Mass Storage Class Bulk only Transport Specification Rev. 1.0· • Support High-speed (480Mbps) and Full-speed (12Mbps) Data Transfer· • USB bus power operation· • Support Control, Bulk IN / OUT data pipes· • Support the following memory card interfaces: • Secure Digital (SD), • MultiMediaCard (MMC), • Mini-SD, Micro-SD (T-flash), • RS-MMC,Mobile-MMC and MMC-micro-Memory Stick (MS), • Memory Stick PRO (MS-PRO), • MS Duo, MS-PRO Duo and Micro-MS (M2)-MSPRO-HG Duo 8-bit mode • xD-Picture Card (xD) including Type M and Type H· • Support hardware ECC (Error Correction Code) function· • Support hardware CRC (Cyclic Redundancy Check) function· • Programmable clock rate for flash memory card interfaces· • Support MS-PRO v1.02· • Support MS v1.43· • Support MS PRO-HG Duo v1.01· • Support SD version 2.0· Support MMC version 4.2· • Support xD v1.2· • Integrated Fast 8051 microprocessor· • External serial EEPROM interface· • 12MHz crystal oscillator with integrated PLL· • Support 48Mhz directly input from clock generator· • On chip 3.3V to 1.8V regulator· • On chip MOSFET with 250mA capability for direct power control of all types memory cards· • Support Spread Spectrum Clock for SD/MMC and MS/MSPRO/ HG to reduce EMI effect· • Support USB remote wake-up ability with memory card inserted and removal operation· • Provide Selective Suspend driver to reduce power consumption· • 48-pin LQFP package Power • +3.3V • +3V_CARD 26 Chapter 1
IR Item Specification Type EVERLIGHT ELECTRONICS IRM-V038/TR1-P Features • High immunity against ambient light. • Long reception distance. • Suitable burst length =>10 pulses/burst. • Low voltage and low power consumption. Audio Interface Item Specification Audio Controller Realtek ALC888 Azadia Codec and Amplifier GMT G1441&G1412 Features • HD Audio • 97dB SNR DACs & 90dB SNR ADCs • Ten DAC channels support 16/20/24-bit PCM format for 7.1 sound playback, plus 2channels of independent stereo sound output (multiple streaming) through the front panel output • Two stereo ADCs support 16/20/24-bit PCM format, one for stereo microphone, one for legacy mixer recording • All DACs supports 44.1k/48k/96k/192kHz sample rate • All ADCs support 44.1k/48k/96k sample rate • Two independent 16/20/24-bit S/PDIF-OUT converters support 44.1k/48k/96k/192kHzsample rate, one for nominal digital audio, the other one for digital audio output to HDMI transmitter • Enable VoIP function • Subwoofer support LAN Interface Item Specification LAN Chipset BroadCom Lan controller BCM5764 Features • PCI-E interface LAN controller • PCIE V1.1 compliant. • Support wake on LAN meeting the ACPI requirements. • 68-pin QFN package. Bluetooth Interface Item Specification Chipset FOXCON T60H928.11 Bluetooth miniUSB module Features • Internal Mini USB solution with antenna • Bluetooth 2.0+EDR • Bluetooth control for BT optical mouse Keyboard Item Specification Type Aspire series: New Acer Non-Ergo Keyboard Total number of keypads 104-key Windows logo key Yes Internal & external keyboard work simultaneously Plug USB keyboard to the USB port directly: Yes Chapter 1 27
Page 1 and 2: Aspire 7230/7530/7530G Series Servi
Page 3 and 4: Copyright Copyright © 2008 by Acer
Page 5: Preface Before using this informati
Page 8 and 9: Table of Contents VIII Removing the
Page 10 and 11: Table of Contents X
Page 12 and 13: Audio • Dolby®-certified surroun
Page 14 and 15: System Block Diagram CPU CORE ISL62
Page 16 and 17: No. Icon Item Description 8 Click b
Page 18 and 19: Right View No. Icon Item Descriptio
Page 20 and 21: Indicators The computer has several
Page 22 and 23: Using the Keyboard The keyboard has
Page 24 and 25: Hot Keys The computer employs hotke
Page 26 and 27: Using the System Utilities Acer Bio
Page 28 and 29: Hardware Specifications and Configu
Page 30 and 31: Features (continued) • Fast ATA-1
Page 32 and 33: Hard Disk Drive Item Specifications
Page 34 and 35: LCD 17.0” Item Specification Vend
Page 38 and 39: MDC Card Item Specification Chipset
Page 40 and 41: Information The Information screen
Page 42 and 43: Advanced The Advanced screen allows
Page 44 and 45: Security The Security screen contai
Page 46 and 47: Changing a Password 1. Use the ↑
Page 48 and 49: Power The Power screen allows the u
Page 50 and 51: Exit The Exit screen allows you to
Page 52 and 53: Remove HDD/BIOS Utility This sectio
Page 54 and 55: 3. Reboot the system and key in the
Page 56 and 57: General Information Pre-disassembly
Page 58 and 59: Removing the Battery Pack 1. Turn c
Page 60 and 61: Removing the Lower Covers 1. See
Page 62 and 63: Removing the MXM Module 1. Remove t
Page 64 and 65: 5. Remove the TV Tuner module. NOTE
Page 66 and 67: Removing the Hard Disk Drive Module
Page 68 and 69: Removing the Optical Drive Module 1
Page 70 and 71: Main Unit Disassembly Process Main
Page 72 and 73: Removing the Switch Cover CAUTION:
Page 74 and 75: Removing the Keyboard 1. Remove the
Page 76 and 77: Removing the Antenna, MIC and Speak
Page 78 and 79: Removing the LCD Module 1. Remove t
Page 80 and 81: Removing the Upper Cover 1. See “
Page 82 and 83: Release the securing latches and di
Page 84 and 85: Removing the Finger Print Reader 1.
Page 86 and 87:
Removing the Touch Pad 1. Remove th
Page 88 and 89:
Removing the Speaker Module 1. Remo
Page 90 and 91:
Removing the Bluetooth board 1. Rem
Page 92 and 93:
4. Grasp the Subwoofer Module and l
Page 94 and 95:
4. Lift the ExpressCard module away
Page 96 and 97:
Removing the CPU Fan Module 1. See
Page 98 and 99:
Removing the CPU 1. Remove the CPU
Page 100 and 101:
Removing the LCD Bezel 1. Remove th
Page 102 and 103:
Removing the Inverter Board 1. Remo
Page 104 and 105:
Removing the LCD Panel 1. Remove th
Page 106 and 107:
Removing the LCD Brackets and FPC C
Page 108 and 109:
LCD Module Reassembly Procedure Rep
Page 110 and 111:
8. Connect the left and right Inver
Page 112 and 113:
Main Module Reassembly Procedure Re
Page 114 and 115:
Replacing the Mainboard 1. Pull the
Page 116 and 117:
Replacing the Subwoofer Module 1. G
Page 118 and 119:
4. Connect the two FFC cables as sh
Page 120 and 121:
Replacing the Touch Pad IMPORTANT:T
Page 122 and 123:
4. Connect the two FFC cables as sh
Page 124 and 125:
5. Connect the five cables to the m
Page 126 and 127:
Replacing the LCD Module 1. Replace
Page 128 and 129:
4. Place the computer upside down,
Page 130 and 131:
Replacing the Keyboard 1. Replace t
Page 132 and 133:
Replacing the Switch Cover 1. Repla
Page 134 and 135:
3. Replace the four screws (two eac
Page 136 and 137:
3. Replace the two securing screws.
Page 138 and 139:
Replacing the SD Dummy Tray 1. Inse
Page 140 and 141:
Power On Issue If the system doesn
Page 142 and 143:
Abnormal Video Display If video dis
Page 144 and 145:
Touch Pad Failure If the Touch Pad
Page 146 and 147:
Internal Microphone Failure If the
Page 148 and 149:
ODD Failure If the ODD fails, perfo
Page 150 and 151:
. Double-click IDE ATA/ATAPI contro
Page 152 and 153:
Wireless Function Failure If the WL
Page 154 and 155:
Thermal Unit Failure If the Thermal
Page 156 and 157:
Intermittent Problems Intermittent
Page 158 and 159:
POST Code Function Phase Component
Page 160 and 161:
Page 162 and 163:
Page 164 and 165:
Page 166 and 167:
Page 168 and 169:
Bottom View No. Jumper Description
Page 170 and 171:
BIOS Recovery by Crisis Disk BIOS R
Page 172 and 173:
Aspire 7230/7530/7530G Exploded Dia
Page 174 and 175:
Cable Category Description Acer Par
Page 176 and 177:
Category Description Acer Part No.
Page 178 and 179:
Category Description Acer Part No.
Page 180 and 181:
MainBoard Memory Heatsink Category
Page 182 and 183:
Model Definition and Configuration
Page 184 and 185:
Model RO Country Acer Part No Descr
Page 186 and 187:
Page 188 and 189:
Page 190 and 191:
Page 192 and 193:
Model LCD Memory1 Memory2 HDD1 HDD2
Page 194 and 195:
Page 196 and 197:
Page 198 and 199:
Page 200 and 201:
Microsoft ® Windows ® Vista Envir
Page 202 and 203:
Vendor Type Description 60001994 WD
Page 204 and 205:
Vendor Type Description VGA Test 60
Page 206 and 207:
196 Appendix C
Page 208:
M N O P S 198 LCD Brackets 96 LCD F
show all

Aspire 7230/7530/7530G Series Service Guide - tim.id.au

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?