MATERIAL SAFETY DATA SHEET - Whip Mix

MATERIAL SAFETY DATA SHEET (Revision: 08/04/2008)1. Identification of the Substance/Preparation and of the Company/Undertaking.• Product Type: Paint-On Die Spacer• Trade Name: P.D.Q. Die Spacer, Grey and BlueP.D.Q. Thinner• Company: Whip Mix Corporation361 Farmington Ave.Louisville, Kentucky, USA 40209Emergency Telephone Number: (502)-637-1451Fax Number: (502) 634-4512TransportationEmergencies:CHEMTREC 1(800) 424-9300 (U.S. and Canada)International Calls: 1- 703-527-3887 (Collect calls accepted)2. Hazard Identification.• Flammable liquid: UN 1193.Class 3. Use in well ventilated area. Solvent vapors can travel to an ignition source,such as a Bunsen burner and flash back.• Vapor may cause irritation to eyes and respiratory tract.• Liquid may cause irritation to skin and eyes.3. Composition/Information on Ingredients.Substance CAS EINECS Concentration, % R Symbols SMethyl Ethyl 78-93-3 201-159-0 >50% +F: R11, Xi,S2, S9, S16KetoneR36, R66,R67Trimethylbenzene 25551-13-7 247-099-9 >3% N/A N/APM Acetate 108-65-6 203-603-9 >4% Xi, R10, R26 S2, S254. First-Aid Measures.• Skin contact: Wash with soap and water.• Inhalation: Move to fresh air.• Eye contact: Flush eyes(s) with water. Contact a physician if irritation occurs.• Ingestion: Do not induce vomiting. Get medical attention immediately.5. Fire-Fighting Measures.• Use water fog, Alcohol foaming@ CO 2 , or dry chemical.• For small bottle, smother with a water wet blanket or towel. Keep area isolated.• Hazardous decomposition product: Carbon Monoxide6. Accidental Release Measures.• For small quantities, cleanup with paper towel and dispose of properly.7. Handling and Storage.• Keep away from heat, spark or open flame.• Keep container closed.8. Exposure Controls/Personal Protection.• None required under normal use in a well ventilated area.• Exposure Limits OSHA-PEL ACGIH-TLV, 2008Methyl Ethyl Ketone 200 ppm 200 ppmTrimethylbenzene Not Established 25 ppmPM Acetate Not Established Not Established** AIHA recommends 50 ppm.Use NIOSH approved respirator to avoid exposure above the recommended limits.Page: 1 of 2

9. Physical and Chemical Properties.• Clear, light yellow liquid with low viscosity.Vapor pressure (mm Hg): 70mm @ 20ºCVapor density (air-1): > 1Evaporation rate: > 1Boiling point (ºC): 80ºCSpecific gravity (water=1): approximately 1.0Flash point (S.F.C.C.): - 4ºCUpper flammability limit (% by volume): 12%Lower flammability limit (% by volume): 1%Auto ignition temperature (ºC): 516ºC10. Stability and Reactivity.• Flammable when exposed to heat, spark or open flame.• Vapors can travel to a source if ignition such as a Bunsen burner or furnace and flash back. Use in well ventilatedarea only.11. Toxicological Information.• Route of entry: skin contact, eye contact, inhalation or ingestion.• Effects of acute over exposure:Inhalation: Vapors can cause headache, nausea, dizziness, and irritation of nose, throat and lungs.Skin contact: Prolonged or repeated contact can cause skin irritation. Chronic exposure may cause de-fattingtype dermatitis.Eye contact: Direct eye contact can cause eye irritation and temporary damage. May cause conjunctivitis.• Carcinogenicity: Not listed as carcinogen by OSHA, NTP or IARC.• Prop 65 California: Warning: This product contains trace amounts of heavy metal which the State of Californiahas determined are carcinogens or cause reproductive toxicity. (As, Cd, Pb, Hg, and/or Ni are present in tracePPM).12. Ecological Data.• Small quantities (1/2 oz.) do not pose an ecological concern.13. Disposal Considerations.• Small quantities of material can be allowed to evaporate in well ventilated area.• Small quantities of dry material may be disposed in local land fill. Check local regulations.14. Transport Information.• DOT hazard class: Flammable liquid ORM-D consumer commodity.15. Regulatory Information.• This product is considered hazardous under OSHA Hazardous Communications Standard (29CFR 1910.1200).• This product is a “controlled product” under Canadian WHMIS.• Under SARA Title 3: Section 311/312, this product is a hazardous chemical under 29CFR 1910.1200.• Under SARA Title 3: Section 313 (40CFR371) above de minims concentrations: Methyl Ethyl Ketone,Trimethylbenzene, Pseudocumene, Cumene. Refer to Section II.16. Other Information.• HMIS Rating: Health=1 Flammability=3 Reactivity=0Hazard: 4-Severe; 3-Serious; 2-Moderate; 1-Slight; 0-MinimumPrepared By: Donna Ringo, CIHDate: 8/4/2008CPL90514i :\msds\pdqdie.spa(rev. 08/04/2008)Translated By:Date:Page: 2 of 2