Dometic AES Service Manual (2134KB) - Bryant RV Services

More documents

Recommendations

Info

(21)To let the customer know that the switch isproperly turned on and that there is sufficientDC power to energize the system, L.E.D. lampwill illuminate green.(22)After the refrigerator has reached the desiredcabinet temperatures, the customer then canload the refrigerator with pre-chilled food.(23)When the <strong>RV</strong> family is ready to begintravelling, coach’s owner disconnects the shoreline from the power source, which willdiscontinue the operation of the 120 voltheating element.(24)At this time the refrigerator’s controls willautomatically light the burner assembly andthe unit will be fully functional on the LP gasmode. This automatic mode selection isaccomplished without the need to manuallyreset the refrigerator. What could be easier?A-6-7
(25)When the driver gets in the vehicle and turnson the ignition key, the gas flame will shut offand the 12 volt heating element will beenergized to operate the refrigerator whiletraveling.(26)This automatic switching to the 12 volt DCheating element mode is accomplished by thecorrect field wiring of the ignition lockterminal on the rear of the refrigerator, whichwe will discuss in further detail later in theprogram.(27)When the vehicle’s ignition switch is turnedoff when stopping to refuel, there is no needto manually turn off the refrigerator toprevent the gas flame from lighting.Incorporated into the electronic controls is asafety delay. This will prevent the burner fromlighting for approximately 25 minutes after theignition key is turned off.(28)After this delay time and the ignition key hasnot been turned on or 120 volts has not beensupplied, the refrigerator will then re-light onLP gas.A-6-8
Page 8 and 9: OPERATION AND DIAGNOSISDOMETIC AES
Page 10 and 11: (5)Shown here is the RM1303 that is
Page 12 and 13: (13)Just above the burner assembly,
Page 16 and 17: (29)NOTE: The 120 volt mode is not
Page 18 and 19: (36)Second, the control system inco
Page 20 and 21: (42)The L.E.D. lamp assembly contai
Page 22 and 23: From the front there are two notabl
Page 24 and 25: (57)If the gas only pushbutton is d
Page 26 and 27: (64)Another significant change in t
Page 28 and 29: (70) TAG LINE ENERGIZEDSecondly, su
Page 30 and 31: (77)For proper cooling on the AC mo
Page 32 and 33: As seen in the chart on page A-6-26
Page 34 and 35: REFRIGERATORTERMINAL BLOCKPOSITIVEN
Page 36: PROPER WIRING OF AN AES WITH A BATT
Page 39 and 40: (88)If the refrigerator has not bee
Page 41 and 42: (96)Check the 3 amp. DC fuse at the
Page 43 and 44: (103)Refer to the RM3801 switch dia
Page 45 and 46: (111)After we have determined that
Page 47 and 48: (118)Next, diagnose the switch by f
Page 49 and 50: (125)DC voltage should not be prese
Page 51 and 52: (132)To diagnose a gas operational
Page 53 and 54: (139)You should hear a sharp click
Page 55 and 56: (147)A very important function of t
Page 57 and 58: AES RefrigeratorGLOSSARY OF TERMSA
Page 59 and 60: AES Refrigerator GLOSSARY OF TERMS
Page 65 and 66:
AES Refrigerator CONTINUITY READING
Page 67 and 68:
AES Refrigerator CONTINUITY READING
Page 69 and 70:
Operation of the AES System (Automa
Page 71 and 72:
Bulletin #46 continuedThe thermosta
Page 73 and 74:
Bulletin #46 continuedIn closing, t
Page 75 and 76:
AES REFRIGERATOR WIRING DIAGRAMSRM1
Page 77 and 78:
ometiclquality leisure line product
Page 79 and 80:
Bulletin #R56/7A continued3-WAY AES
Page 81 and 82:
REPLACEMENT OF CIRCUIT BOARDSModels
Page 83 and 84:
Bulletin #R58/7A continuedLastly, t
Page 85 and 86:
PDI(PRE- DELIVERY INSPECTION)PDI in
Page 87 and 88:
Bulletin #R60/7A continuedAESPRE-DE
Page 89 and 90:
Bulletin #R60/7A continued9.When sw
Page 91 and 92:
GENERAL INFORMATIONFOR MODELS RM260
Page 93 and 94:
OS1160-A AES Refrigerator Diagnosti
show all

Dometic AES Service Manual (2134KB) - Bryant RV Services

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?