TremLastic® SP - Tremco Roofing

Material Safety Data SheetTREMLASTIC SP 5 GALVersion 3. Print Date 08/05/2010REVISION DATE: 03/26/2010SECTION 1 - PRODUCT IDENTIFICATION / PREPARATION INFORMATIONProduct InformationTrade name : TREMLASTIC SP 5 GALProduct code : 344640 805Supplier : Tremco Canada division220 Wicksteed AvenueToronto, ON M4H 1G7Telephone : (416) 421-3300Emergency Phone: : (613) 996-6666Preparation InformationPrepared by: : Sewnauth RaghunandanDate: : 03/26/2010Telephone : (416) 421-3300SECTION 2 - HAZARDS IDENTIFICATIONEmergency OverviewBrown to Black. Liquid. May cause slight irritation to the respiratory system. Leave area to breathe fresh air.Avoid further overexposure. If symptoms persist, get medical attention.Acute Potential Health Effects/ Routes of EntryInhalation : May cause slight irritation to the respiratory system.Eyes : Direct contact may cause mild irritation.Ingestion : May cause gastrointestinal irritation, nausea, and vomiting.Skin : May cause mild irritation. May cause sensitization resulting in irritation, itching andredness. May cause a rash.Aggravated Medical ConditionsPre-existing eye, skin and respiratory disorders may be aggravated by exposure.Chronic Health EffectsProlonged or repeated skin contact with asphalt may result in skin sensitivity, such as irritation, rashes, anddermatitis. Prolonged or repeated exposure to polycyclic aromatic hydrocarbons and other volatiles which arecontained in trace amounts in asphalt have been shown to cause cancer or respiratory damage in animals.Fillers are encapsulated and not expected to be released from product under normal conditions of use.Target Organs: Skin, Eye, LungSECTION 3 : HAZARDOUS INGREDIENTSChemical Name CAS-No. Weight % RangeAsphalt 8052-42-4 40.0 - 70.0The ingredients listed above are hazardous as defined in the controlled products regulation. (CPR).SECTION 4 - FIRST AID MEASURESGet immediate medical attention for any significant overexposure.1/5

Material Safety Data SheetTREMLASTIC SP 5 GALVersion 3. Print Date 08/05/2010REVISION DATE: 03/26/2010Inhalation : Leave area to breathe fresh air. Avoid further overexposure. If symptoms persist, getmedical attention.Eye contact : Flush with water for at least 15 minutes while holding eye lids apart. Get medicalattention immediately.Skin contact : Clean area of contact thoroughly using soap and water. If irritation, rash or otherdisorders develop, get medical attention immediately.Ingestion : Do not induce vomiting unless advised by a physician. Call nearest Poison ControlCenter or Physician immediately.SECTION 5: FIRE / EXPLOSION HAZARDSFlash point : Not available.Method : Not applicable.Lower explosion limit : Not available.Upper explosion limit : Not available.Autoignition temperature : Not available.Extinguishing media : If water fog is ineffective, use carbon dioxide, dry chemical or foam.Hazardous combustionproductsProtective equipment forfirefighters: Carbon monoxide and carbon dioxide can form.Oxides of sulfur canform.: Not applicable. Product is not expected to burn.Fire and explosion conditions : Not applicable, not expected to burn.SECTION 6 - SPILLS / LEAKS / ACCIDENTAL RELEASE MEASURESUse appropriate protective equipment. Avoid contact with material. Stop flow. Contain spill. Keep out of watercourses. Absorb spill in sand, earth or other suitable material. Transfer to appropriate container for disposal.SECTION 7 - HANDLING AND STORAGEPrevent inhalation of vapor, ingestion, and contact with skin eyes and clothing. Keep container closed whennot in use. Precautions also apply to emptied containers. Store in sealed containers in a dry, ventilatedwarehouse location above freezing.SECTION 8 - PREVENTIVE MEASURES/EXPOSURE CONTROLS/PERSONAL PROTECTIONPersonal protection equipmentRespiratory protection : Not required under normal conditions of use.Hand protection : Use suitable impervious rubber or vinyl gloves and protective apparel toreduce exposure.Eye protection : Wear chemical safety goggles and/or face shield to prevent eye contact. Donot wear contact lenses. Do not touch eyes with contaminated body parts ormaterials. Have eye washing facilities readily available.Protective measures : Use professional judgment in the selection, care, and use.Other equipmentnot normally required.2/5

Material Safety Data SheetTREMLASTIC SP 5 GALVersion 3. Print Date 08/05/2010REVISION DATE: 03/26/2010Engineering measures : General ventilation is sufficient.Use local exhaust when the generalventilation is inadequate.Exposure LimitsChemical Name CAS Number Regulation Limit FormAsphalt 8052-42-4 ACGIH TWA: 0.5 mg/m3 Inhalable fraction.asbenzene solublesOntario TWAEV: 0.5 mg/m3 Inhalable fumeasbenzene solublesSECTION 9 - PHYSICAL AND CHEMICAL PROPERTIESPhysical State: LiquidForm: LiquidColor: Brown to BlackOdor: AsphaltpH : 9 - 10Vapour pressure: Not available.Vapor density: Heavier than airMelting point/range: Not available.Freezing point : 32 °F, 0 °CBoiling point/range: Not available.Water solubility: DispersibleEvaporation Rate:: Not available.Specific Gravity : 1.03% Volatile Weight : 48 %SECTION 10 - REACTIVITY / STABILITYSubstances to avoidStabilityHazardous polymerization: Oxidizing agents.: Material is stable under normal storage, handling, and use.: Will not occur under normal conditions.SECTION 11 - TOXICOLOGICAL INFORMATIONNo Data Available3/5

Material Safety Data SheetTREMLASTIC SP 5 GALVersion 3. Print Date 08/05/2010REVISION DATE: 03/26/2010SECTION 12 - ECOLOGICAL INFORMATIONNo Data AvailableSECTION 13 - WASTE DISPOSAL CONSIDERATIONSDisposal Method : Dispose as hazardous waste according to all local, state, federal and provincialregulations.SECTION 14 - TRANSPORTATION / SHIPPING DATATDG / DOT Shipping Description:NOT REGULATEDSECTION 15 - REGULATORY INFORMATIONNorth American Inventories:All components are listed or exempt from the TSCA inventory.This product or its components are listed on, or exempt from the Canadian Domestic Substances List.Canadian Regulations:WHMIS Classification : D2BThis is a "controlled product" under the Canadian Workplace Hazardous Materials Information System(WHMIS).This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations(CPR) and the MSDS contains all of the information required by the CPR.Other Regulations:Regulatory VOC (less water andexempt solvent): 5 g/lSECTION 16 - OTHER INFORMATIONHMIS Rating :Health 1Flammability 1Reactivity 0PPE0 = Minimum1 = Slight2 = Moderate3 = Serious4 = SevereFurther information:For Industrial Use Only. Keep out of Reach of Children. The hazard information herein is offered solely for theconsideration of the user, subject to their own investigation of compliance with applicable regulations, includingthe safe use of the product under every foreseeable condition.Prepared by: Sewnauth Raghunandan4/5

Material Safety Data SheetTREMLASTIC SP 5 GALVersion 3. Print Date 08/05/2010REVISION DATE: 03/26/2010LegendACGIH - American Conference of Governmental HygienistsDOT - Department of TransportationDSL - Domestic Substance ListEPA - Environmental Protection AgencyHMIS - Hazardous Materials Information SystemIARC - International Agency for Research on CancerMSHA - Mine Safety Health AdministrationNDSL - Non-Domestic Substance ListNIOSH - National Institute for Occupational Safety and HealthNTP - National Toxicology ProgramOSHA - Occupational Safety and Health AdministrationPEL - Permissible Exposure LimitRCRA - Resource Conservation and Recovery ActSTEL - Short Term Exposure LimitTLV - Threshold Limit ValueTSCA - Toxic Substances Control ActTWA - Time Weighted AverageV - VolumeVOC - Volatile Organic CompoundWHMIS - Workplace Hazardous Materials Information System5/5