IG4300 Owner's Manual NTP Edit 2 - Kipor Power Systems

More documents

Recommendations

Info

$H:\drawings\IG3000\KG205GETi(EPA)(CARB)å¾å.dwg Model (1)$

13.2 Emission Control System WarrantyWarranty Statement• The U.S. Environmental Protection Agency (EPA) and the California Air Resources Board (CARB) requiremanufacturers of small off-road engines to warranty their products with a two year warranty for thosecomponents that are specified as being part of the emission control system. Kipor Power Equipment, EPA,CARB offer the following explanation of the Emission Control Warranty.• In the United States and California, new small off-road engines must be designed, built, and equipped to meetstringent emission standards. Kipor must warrant the emission control system on your generator engine for theperiods of time listed below provided there has been no abuse, neglect, improper maintenance, orunauthorized application of your small off-road engine.• If a warrantable condition is determined, Kipor Power Equipment will repair your small off-road engine at nocost to you including diagnosis, parts, and labor.CoverageEmissions control parts on the engine are warranted for a period of two years, subject to provisions set below. If anycovered part on your engine is defective, the part will be repaired or replaced by Kipor Power Equipment.Owner’s ResponsibilitiesYou are responsible to maintain the engine as defined in your Kipor Generator Owner’s Manual. Kipor recommends thatyou retain all record/receipts covering maintenance on your engine but Kipor Power Equipment cannot deny warrantyclaims based on the lack of receipts or for your failure to perform all scheduled maintenance. You may be deniedwarranty coverage if a part has failed due to abuse, neglect, improper maintenance, or unapproved applications.You are required to bring your generator to an authorized Kipor generator dealer for repairs as soon as a problem exists.For emissions warranty service, contact your nearest dealer. A listing is available fromservice@kiporpowersytems.com or by calling (503) 445-0199.Emission Control System PartsCoverage under this warranyt extends only to the emissions control parts listed below:1. Fuel SystemA. Carburetor gasketsB. Fuel lines, fittings, and clampsC. Fuel filter (if equipped)D. Fuel pump (if equipped)E. Carburetor2. Intake SystemA. Air cleaner assemblyB. Intake manifold3. Ignition SystemA. Ignition coilB. Spark plug4. Exhaust SystemA. Catalytic converter (if equipped)B. Exhaust manifold38
C. Gaskets5. Crankcase Breather SystemA. Breather assemblyB. Breather tube6. Air Injection SystemA. Secondary air injection valve7. Fuel Tank Evaporative Emissions Control SystemA. Fuel tankB. Fuel capC. Carbon canister and brackets8. Miscellaneous Items used in aboveA. Hoses, connectors, and fittingsB. Electrical switchesWarranty Provisions1. Claims Warranty claims shall be filed in accordance with the provisions of the Kipor warranty and policiesestablished with the authorized repair center network.2. Exclusions Warranty coverage shall be denied for failure of an emissions control system part caused by abuse,neglect, improper maintenance or application as described in the Kipor Generator Owner’s Manual. Additionally,coverage may be denied for the use of add-on parts, modified parts, or parts that are not equivalent to original Kiporgenerator parts in performance and durability.3. Length of Coverage Kipor Power Equipment warrants to the original retail purchaser and each subsequent ownerthat the emissions control system shall be free of defects in materials and workmanship for a period of two years fromthe date of the original retail customer.4. Repair or Replacement Cost Repair or replacement of any emissions control system part will be repaired at nocharge to the owner including diagnostic labor which would determine an emissions control system defect exists if therepair is performed at an authorized Kipor repair center.5. Consequential Damage Repairs will extend to any other engine part damaged by the failure of any emission controlsystem part.6. Maintenance The emissions control system and associated parts are warranted for defects during the warrantyperiod only.The warranty does not cover any replacement of parts that are replaced as required by the maintenance schedule in theKipor Generator Owner’s Manual. Any replacement part that is equivalent in function and durability may be used formaintenance or repairs.QuestionsIf you have any questions regarding your rights and responsibilities under this emissions system warranty, you maycontact the Kipor Aftermarket Support office.By email: service@kiporpowersystems.comBy phone: (503) 445-0199By mail: Kipor Power EquipmentAttn: Aftermarket Support12021 NE Airport Way Ste. EPortland, OR 9722039
Page 1 and 2: SINEMASTERDIGITAL GENERATORIG4300OW
Page 3: Thank you for purchasing a Kipor Ge
Page 6 and 7: 8. TRANSPORTING/STORAGE ·····
Page 8 and 9: To ensure safe operation: Gasoline
Page 12 and 13: 3. PRE-OPERATION CHECKBe sure to ch
Page 14 and 15: Gasoline containing alternate fuels
Page 16 and 17: 4.1(b) Pull the choke knob out to t
Page 18 and 19: 4.2 High altitude operationAt high
Page 20 and 21: When an extension cable is required
Page 22: Be sure that all appliances are in
Page 25 and 26: The battery contains sulfuric acid
Page 27 and 28: With the voltage switch in the 120/
Page 29 and 30: 7. MAINTENANCEThe purpose of the ma
Page 31 and 32: 7.2 Maintenance Schedule(1) REGULAR
Page 33 and 34: Air Filter BaseFilter Element Air F
Page 35 and 36: 1. Remove the generator rear cover
Page 37 and 38: 9. TROUBLESHOOTINGWhen the engine w
Page 39 and 40: 10. SPECIFICATIONSModelIG4300TypeIn
Page 41 and 42: 12. WHEEL KIT1. Axle shaft2. 2.5’
Page 43: 13. WARRANTY13.1 Kipor Power Equipm
Page 48 and 49: Fuel System42
Page 50: Exhaust System44

IG4300 Owner's Manual NTP Edit 2 - Kipor Power Systems

Create successful ePaper yourself

Delete template?

Save as template?