Snapper Lawn Tractor Hydrostatic Drive Electric Clutch Series G ...

More documents

Recommendations

Info

Section 3 - MAINTENANCE3.3.4. TRACTOR LUBRICATION(Continued From Previous Page)3. <strong>Clutch</strong>/Brake PivotThe clutch/brake pivot is located on the L.H.underside of the tractor and is lubricated with oneshot of general purpose grease. See Figure 3.6.DRAG LINKLUBRICATIONPOINTCLUTCH/BRAKEPIVOT LUBRICATIONFITTINGFIGURE 3.87. Steering Tie RodLubricate both ends of steering tie rod with a smallamount of 30 wt. motor oil from an oil can. SeeFigure 3.9.LUBRICATEBOTH ENDSOF TIE RODFIGURE 3.64. Steering Sector GearLubricate with a light coat of general purpose grease.See Figure 3.7.LUBRICATESTEERINGSECTOR GEARFIGURE 3.98. Park Brake LeverUsing 30 wt. motor oil, lubricate the park brake levermechanism pivot points, which are located on the lefthand underside of tractor. See Figure 3.10. Lubricatemechanism with a thin coat of 30 wt. motor oil.LUBRICATESTEERINGSHAFT GEARPARK BRAKELEVERFIGURE 3.75. Steering ShaftLubricate steering shaft wear points with a light coatof 30 wt. Motor oil.6. Steering Drag LinkLubricate both ends of steering drag link with a smallamount of 30 wt. motor oil from an oil can. SeeFigure 3.8.LUBRICATECOMPONENTS ONUNDERSIDE OFTRACTORFIGURE 3.109. Deck Lift MechanismLubricate all wear and pivot points of the deck lift.14
Section 3 - MAINTENANCE3.4 ANNUALLY (END OF EACH SEASON)Perform all maintenance as described in Section“SERVICE - EVERY 25 OPERATING HOURS”. Alsosee Service Schedule.3.4.1. ENGINE1. Service engine according to engine owner'smanual.3.4.2. FUEL FILTER1. Service fuel filter as instructed below, on COLDENGINE ONLY!NOTE: It may be necessary to drain the fuel tank beforeremoving fuel filter to prevent spillage of gasoline.2. Locate fuel filter. Remove hose clamps and fuelhoses from both sides of fuel filter.3. Install new fuel filter part number 1-4359. SeeFigure 3.11.NEW FUEL FILTERPART NUMBER 1-4359FIGURE 3.114. Fill fuel tank with fresh gasoline. Refer to engineowner's manual for fuel specifications.3.4.3. SPARK PLUGRemove and replace engine spark plug. Refer toengine owner's manual for correct replacement plugand gap specifications.3.4.4. HYDROSTATIC TRANSMISSION OILThe hydrostatic transmission does not requiremaintenance. If any problems arise returnimmediately to a <strong>Snapper</strong> dealer.15
Page 6 and 7: Section 2 - OPERATING INSTRUCTIONS2
Page 13: Section 3 - MAINTENANCE3.2.4. CHECK
Page 17 and 18: Section 4 - ADJUSTMENT & REPAIRWARN
Page 33 and 34: Section 4 - ADJUSTMENT & REPAIRAVAI
Page 35 and 36: TROUBLESHOOTING GUIDEPROBLEM PROBAB
Page 37 and 38: MAINTENANCE SCHEDULESUBJECTSERVICER
Page 39 and 40: PRIMARY MAINTENANCE39
Page 41 and 42: PRIMARY MAINTENANCE41
Page 43 and 44: SERVICE NOTES______________________

Snapper Lawn Tractor Hydrostatic Drive Electric Clutch Series G ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?