Series 100 Single Package Units, Engineering Guide, 100.50-EG7

More documents

Recommendations

Info

Features and Benefi ts (continued) YPAL070-105 MODEL 10 Angled evaporator coil for lower face velocities 00567VIP Factoryinstalled single package unit controller V-banked condenser coils to protect from hail damage Complete double-wall construction of walls, fl oors, ceiling, and panels Double-sloped stainless steel IAq drain pan and intermediate drain pan Doors on both sides of unit and tie backs for unit servicing Centrifugal fan powered exhaust fan or optional plenum return fan Optional replaceable core fi lter driers Condenser wire screen Optional louvers available Optional horizontal supply air openings Distributor tubes protected in plastic sleeves Angled or rigid fl at fi lter section Optional airfl ow measurement station Rainhoods to prevent moisture from entering the unit FORM 100.50-EG7 (1110) JOHNSON CONTROLS
YPAL120-130 MODEL • Integrated JOHNSON CONTROLS ISNConneXsys control solution • Standard BACnet MS/TP and Modbus communications Advanced Single Package Units Controller • Multimedia card for updates (no EPROM) • Multimedia card used for data logging • Fast and easy setup JOHNSON CONTROLS Collapsible OA hoods • Collapsible for shipping to reduce freight • Single-piece shipment 24:1 modulating gas heat • Induced draft furnace • Accepts gas pressures down to 3.5" • 6-stage base design Shared-Fan Design • Standard low-ambient to 0°F • Control to discharge pressure • Quiet part load operation FORM 100.50-EG7 (1110) Exhaust & return fans • Horizontal return for all confi gurations • DWDI centrifugal exhaust fans • SWSI plenum return fans • Variable-frequency drive options • Standard Stainless steel drain pan Mixing box • OA from two sides • Facilitates mixing Side discharge with heat • Does not require an elevated structure or curb • Flexible solution for building application Evaporator • Angled coil to reduce risk of carryover Single supply fan • Eliminates stratifi cation • Fewer moving parts • Solid steel shaft • Isolated assembly • Laser aligned and balanced Blower VFDs • Located in conditioned space • Remote keypad in control section • In fi ltered air stream to prevent dust and dirt build-up 11
Page 1 and 2: Series 100 Single Package Units 70
Page 3 and 4: Table of Contents Nomenclature ....
Page 5 and 6: Features and Benefi ts AIRFLOW CONF
Page 7 and 8: FILTER OPTIONS Filter Options - two
Page 9: ROOF CURBS Full perimeter roof curb
Page 13 and 14: For ground level installations, pre
Page 15 and 16: over ceiling-based systems occur du
Page 17 and 18: JOHNSON CONTROLS This page intentio
Page 19 and 20: TABLE 3 - PHYSICAL DATA - MODELS 70
Page 21 and 22: TABLE 4 - PHYSICAL DATA - MODELS 12
Page 23 and 24: TABLE 8 - COMPONENT WEIGHTS (LBS) (
Page 25 and 26: TABLE 8 - COMPONENT WEIGHTS (LBS) (
Page 27 and 28: TABLE 9 - COOLING PERFORMANCE DATA*
Page 29 and 30: TABLE 9 - COOLING PERFORMANCE DATA*
Page 31 and 32: TABLE 10 - COOLING PERFORMANCE DATA
Page 55 and 56: JOHNSON CONTROLS This page intentio
Page 57 and 58: TABLE 20 - YPAL070-105 : 32" AIRFOI
Page 59 and 60: Rigid Filter Rack, No Media Filters
Page 61 and 62:
Rigid Filter Rack, No Media Filters
Page 63 and 64:
JOHNSON CONTROLS This page intentio
Page 65 and 66:
TABLE 25 - ELECTRIC HEAT AIR PRESSU
Page 67 and 68:
TABLE 28 - YPAL070-105 : 20X18 FORW
Page 69 and 70:
TABLE 32 - YPAL120-130 : 445 PLENUM
Page 71 and 72:
TABLE 34 - SUPPLY AND EXHAUST FAN M
Page 73 and 74:
Controls GENERAL The control system
Page 75 and 76:
EXHAUST CONTROL SEQUENCES Barometri
Page 77 and 78:
This graphic shows what the UNIT MO
Page 79 and 80:
TABLE 40 - THREE PHASE POWER SUPPLY
Page 81 and 82:
JOHNSON CONTROLS UNIT POWER SUPPLY
Page 83 and 84:
Field Power Supply JOHNSON CONTROLS
Page 85 and 86:
Field Control Wiring FIG. 8 - FIELD
Page 87 and 88:
JOHNSON CONTROLS FORM 100.50-EG7 (1
Page 89 and 90:
LEFT SUPPLY / FRONT RETURN SECTION
Page 91 and 92:
LEFT SUPPLY / LEFT RETURN SECTION D
Page 93 and 94:
EXTENDED CABINET / BOTTOM SUPPLY /
Page 95 and 96:
EXTENDED CABINET / LEFT SUPPLY / LE
Page 97 and 98:
EXTENDED CABINET / BOTTOM SUPPLY /
Page 99 and 100:
EXTENDED CABINET / LEFT SUPPLY / BO
Page 101 and 102:
LEFT SUPPLY / FRONT RETURN / POWERE
Page 103 and 104:
BOTTOM SUPPLY / FRONT RETURN / BARO
Page 105 and 106:
JOHNSON CONTROLS This page intentio
Page 107 and 108:
CURB LAYOUT DRAWING / 120-130 TON M
Page 109 and 110:
Lifting Lug Locations JOHNSON CONTR
Page 111 and 112:
Guide Specifi cations GENERAL Scope
Page 113 and 114:
[SELECT ONE OF THE FOLLOWING TYPES
Page 115 and 116:
3. Modulating Gas Heat: The heating
Page 117 and 118:
a unit shutdown or alarm, the opera
Page 119 and 120:
Notes JOHNSON CONTROLS FORM 100.50-
show all

Series 100 Single Package Units, Engineering Guide, 100.50-EG7

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?