automazione zenith - Faac

ENGLISHThese instructions apply to the following models:ZENITH 619 - ZENITH 625ZENITH 1225 - ZENITH 1231Automatic systems ZENITH are designed to automateoverhead spring-balanced, sectional, andcounterbalanced (with special accessory) doors forresidential garages.They consist of an electro-mechanical operator,electronic control appliance and courtesy lamp builtinto a single unit. The unit is fitted to the ceiling andopens the door by means of a transmission chain.The system is non-reversing and, therefore, the doorlocks mechanically when the motor is not operatingand, consequently, no other lock is necessary; twomanual releases on the inside and outside (optional)make it possible to move the door manually in case ofa power cut or fault.Any obstacles are certain to be detected by acontrolling electronic device which comes into actionwhile the automatic system is in operation.AUTOMATIC SYSTEM ZENITH2. TECHNICAL SPECIFICATIONSMODEL ZENITH 619 ZENITH 625Power supply 230Vac 50 (60)HzElectric motor 24VdcMaximum absorbed power 220WMaximum cycles per hour 20(with load of 28K gat 20°C)Maximum consecutive cycles 6 (at 20°C)Minimum distance from ceiling 35mm (Fig.4 and 5 )Maximum available travel 1900 mm 2500 mmPulling/thrust power600N(~60Kg)Courtesy light 230Vac 40W maxCourtesy light timer 2 minutesCarriage speed (load free) 12 cm/secDeceleration speed 6 cm/secDeceleration travel Varies according to set-upDoor max width 3000 mmResponse time of built-in 150 msecsafety deviceDoor max heightSee max available travelProtection class IP20Ambient temperature -20 / +55°CThe ZENITH automatic systems were designed and builtfor indoor use and for controlling vehicle access.Avoidany other use.1. DIMENSIONS2740 (619) / 3340 (625-1225) / 3940 (1231)415MODEL ZENITH 1225 ZENITH 1231Power supply 230Vac 50 (60)HzElectric motor 24VdcMaximum absorbed power 350WMaximum cycles per hour 20(with load of 56K gat 20°C)Maximum consecutive cycles 6 (at 20°C)Minimum distance from ceiling 35mm (Fig.4 and 5 )Maximum available travel 2500 mm 3100 mmPulling/thrust power1200N(~120Kg)Courtesy light 230Vac 40W maxCourtesy light timer 2 minutesCarriage speed (load free) 12 cm/secDeceleration speed 6 cm/secDeceleration travel Varies according to set-upDoor max width 5000 mmResponse time of built-in 150 msecsafety deviceDoor max heightSee max available travelProtection class IP20Ambient temperature -20 / +55°C3. ANCILLARY ELECTRICAL EQUIPMENTDimensions in mm328 157Fig.11) Cable 2 x 0,5 (TX photocell)2) Cable 4 x 0,5 (RX photocell)3) Cable 3x0.5 (Radio receiver)4) Power pipe (230V)5) Low voltage pipe6) Cable 2 x 1.5 + earth (power supply)Fig.212