TEV Kit for A/C and Heat Pumps - Sporlan Online
TEV Kit for A/C and Heat Pumps - Sporlan Online
TEV Kit for A/C and Heat Pumps - Sporlan Online
You also want an ePaper? Increase the reach of your titles
YUMPU automatically turns print PDFs into web optimized ePapers that Google loves.
INCREASE SEER up to 40% SAVE ENERGY up to 40%<br />
<strong>TEV</strong> <strong>Kit</strong> <strong>for</strong> A/C <strong>and</strong> <strong>Heat</strong> <strong>Pumps</strong><br />
Studies Show the Installation of a <strong>TEV</strong><br />
Increases SEER on Mismatched Systems<br />
With energy rates skyrocketing<br />
40% over the last decade, it’s no<br />
surprise homeowners are seeking<br />
energy savings. This coupled<br />
with the sluggish economy leaves<br />
consumers reluctant to invest in<br />
installing expensive, government<br />
m<strong>and</strong>ated, 13 SEER equipment <strong>and</strong><br />
compelling some to maintain old<br />
units.<br />
While a homeowner may be under<br />
the impression that installing a<br />
new 13 SEER outdoor unit will<br />
increase the efficiency of their<br />
existing 10 SEER indoor unit, this<br />
is not the case. These two units<br />
combined will actually reduce<br />
capacity by up to 40% <strong>and</strong> leave the<br />
homeowner with an 8.46 SEER rating.<br />
Efficiency savings can only be<br />
realized if a <strong>TEV</strong> is installed on the<br />
indoor unit.<br />
Installing a <strong>TEV</strong> allows efficiency<br />
savings <strong>and</strong> increases SEER by:<br />
✓ Reducing compressor run time<br />
by closing within seconds of<br />
cycling off.<br />
✓ Controlling refrigerant flow<br />
by adjusting itself to load<br />
requirements.<br />
✓ Protecting the compressor<br />
by preventing refrigerant<br />
flood back during changes in<br />
operating conditions.<br />
✓ Improving evaporator<br />
per<strong>for</strong>mance by compensating<br />
<strong>for</strong> under- or overcharge.<br />
Graph 1 - Bristol Compressors’ Mismatched Systems Testing (1)<br />
Capacity (Btuh)<br />
40,000<br />
35,000<br />
30,000<br />
25,000<br />
20,000<br />
15,000<br />
10,000<br />
5,000<br />
0<br />
13.62<br />
SEER<br />
Matched 13 SEER<br />
Indoor <strong>and</strong><br />
Outdoor Units<br />
8.46<br />
SEER<br />
Mismatched 13 SEER<br />
Outdoor Unit <strong>and</strong><br />
10 SEER Indoor Unit<br />
11.85<br />
SEER<br />
Mismatched 13 SEER<br />
Outdoor Unit <strong>and</strong><br />
10 SEER Indoor Unit<br />
with <strong>TEV</strong> Installed<br />
Cents per kWh<br />
13<br />
12<br />
11<br />
10<br />
9<br />
8<br />
7<br />
1998<br />
2000<br />
2002<br />
2004<br />
For<br />
R-410A <strong>and</strong><br />
R-22<br />
<strong>Sporlan</strong> provides an<br />
energy saving solution<br />
in one convenient kit!<br />
Graph 2 - Residential Electricity Cost<br />
(Annual United States Average)<br />
Average Annual Cost<br />
Average Summer Cost<br />
2006<br />
2008<br />
2010<br />
U.S. Energy In<strong>for</strong>mation Administration<br />
Electric Power Monthly, February 2012<br />
While <strong>Sporlan</strong> always suggests<br />
installing ARI approved matched<br />
systems, studies (1) have shown<br />
that replacing a fixed restrictor<br />
with a <strong>TEV</strong> on mismatched<br />
systems can improve efficiency<br />
<strong>and</strong> increase efficiency ratings<br />
from 8.46 SEER to 11.85 SEER.<br />
This could equate to an average<br />
annual savings of $160.
INCREASE SEER up to 40% SAVE ENERGY up to 40%<br />
<strong>TEV</strong> <strong>Kit</strong> <strong>for</strong> A/C <strong>and</strong> <strong>Heat</strong> <strong>Pumps</strong><br />
Table 1 - <strong>Kit</strong> Contents<br />
Refrigerant Valve Type<br />
R-22<br />
R-410A<br />
© 2012 Parker Hannifin Corporation<br />
Type<br />
RC Valve Chatleff<br />
■ Easily retrofit existing low<br />
grade SEER <strong>and</strong> mismatched<br />
systems.<br />
■ Built-in check valve allows<br />
reverse flow on heat pump<br />
applications.<br />
Item<br />
Number<br />
Nominal<br />
Capacity<br />
Aero-Style<br />
Valve Connections<br />
Inches (ODF Solder)<br />
Parker Hannifin Corporation<br />
<strong>Sporlan</strong> Division<br />
206 Lange Drive • Washington, MO 63090 USA<br />
phone 636 239 1111 • fax 636 239 9130<br />
www.sporlan.com<br />
Adaptors Included in <strong>Kit</strong><br />
Chatleff Aero-Style<br />
RCVE-2-GA <strong>Kit</strong> 20083-000 2 3/8 X 1/2 1/2” 1/2”<br />
RCVE-3-GA <strong>Kit</strong> 20083-009 3 3/8 X 1/2 1/2” 1/2”<br />
RCVE-4-GA <strong>Kit</strong> 20083-001 4 1/2 X 1/2 1/2” 1/2”<br />
RCVE-5-GA <strong>Kit</strong> 20083-002 5 1/2 X 1/2 1/2” 1/2”<br />
RCVE-6-GA <strong>Kit</strong> 20083-003 6 1/2 X 1/2 1/2” 1/2”<br />
RCZE-2-GA <strong>Kit</strong> 20083-004 2 3/8 X 1/2 1/2” 1/2”<br />
RCZE-3-GA <strong>Kit</strong> 20083-005 3 3/8 X 1/2 1/2” 1/2”<br />
RCZE-4-GA <strong>Kit</strong> 20083-006 4 1/2 X 1/2 1/2” 1/2”<br />
RCZE-5-GA <strong>Kit</strong> 20083-007 5 1/2 X 5/8 5/8” 5/8”<br />
RCZE-6-GA <strong>Kit</strong><br />
1/4” Equalizer line; 30” Capillary tube length<br />
20083-008 6 1/2 X 5/8 5/8” 5/8”<br />
INCREASE ENERGY EFFICIENCY. REDUCE OPERATING COSTS.<br />
■ Externally adjustable<br />
valve with balanced port<br />
construction.<br />
■ Available <strong>for</strong> both R-22 <strong>and</strong><br />
R-410A applications.<br />
■ 3 connection options in<br />
every kit. Choose from:<br />
- St<strong>and</strong>ard ODF<br />
- Chatleff<br />
- Aero-Style<br />
For more in<strong>for</strong>mation on the <strong>TEV</strong> <strong>Kit</strong> <strong>for</strong> A/C <strong>and</strong> <strong>Heat</strong> <strong>Pumps</strong>, contact your local <strong>Sporlan</strong> Sales Engineer.<br />
(1) Byrom, Brian. “When 13+10=8.” RSES Journal August 2007: 21-23. Print.<br />
42012 / Form 10-363