MDH-302/402 & Icepic / Selectable Ice Series - Manitowoc ...

More documents

Recommendations

Info

Installation Instructions Section 2 MDH-402 20 VALVE PLUMBING DIAGRAM 3-1-2-1-3 FLEX LEFT TO RIGHT FOR ASSISTANCE CALL (812) 246-7000 PLAIN WATER A (TO CARBONATOR FROM CARB PUMP) COLD CARB MDH-402 20 VALVE SERVEND RECOMMENDED PLUMBING PLAIN WATER (B) SYRUP #11 SYRUP #12 MANIFOLD COLDPLATE INLET LINES SYRUP #13 CARBONATOR 5010862-0 NOTE: SYRUP LINES NOT SHOWN MDH-402 20 VALVE FLEX MANIFOLD (1 PER SIDE) SYRUP #14 SYRUP #15 SYRUP #16 A. PLAIN WATER TO THE CARBONATOR B. PLAIN WATER TO MANIFOLD C. CARB WATER TO MANIFOLD SYRUP #17 SYRUP #18 SYRUP #19 SYRUP #20 3-1-2-1-3 FLEX LEFT TO RIGHT FOR ASSISTANCE CALL (812) 246-7000 PLAIN WATER A (TO CARBONATOR FROM CARB PUMP) COLD CARB MDH-402 20 VALVE SERVEND RECOMMENDED PLUMBING MANIFOLD COLDPLATE INLET LINES LEFT RIGHT A. PLAIN WATER TO THE CARBONATOR B. PLAIN WATER TO MANIFOLD C. CARB WATER TO MANIFOLD CARBONATOR 5010859-0 NOTE: SYRUP LINES NOT SHOWN 2-12 Part Number 020003999 4/12 PLAIN WATER (B) MANIFOLD TO CHANGE TO CARBONATED OR NON-CARBONATED WATER 8,9,10 7 VALVES 5,6 4 1,2,3 SYRUP #1 SYRUP #2 SYRUP #3 SYRUP #4 CARB WATER PLAIN WATER 5010676-0 SYRUP #5 SYRUP #6 SYRUP #7 SYRUP #8 SYRUP #9 SYRUP #10
Section 2 Installation Instructions CO2 System ROUTING INTERNAL CARB TANK PURGE TUBE Some models are equipped with an internal carbonation tank.These models require that the purge/pressure relief tubing be routed to a drain. 1. Remove the splash panel. 2. Uncoil tubing and route between the front of the dispenser and the drain pan. DRAINS Radiator Clamp 90° Elbow Fitting Radiator Clamp 3. Depending on drain location route the tubing through the tubing bundle cutout or out the back of the dispenser. To Drain Flexible Tubing Straight Fitting Radiator Clamp Flexible Tubing Rear of Unit 4. Verify the tubing is not kinked and then secure tubing to maintain a minimum 1" (2.5 cm) air gap at the drain. Follow any applicable local or national codes. Part Number 020003999 4/12 2-13 A Holes for beverage lines Holes for drain pan drain Drainage Through Bottom Drainage Through Back Rear View
Page 1 and 2: MDH-302/402 & Icepic / Selectable I
Page 3 and 4: Section 1 General Information Secti
Page 5 and 6: Section 4 Maintenance Section 5 Bef
Page 7 and 8: Section 1 General Information Read
Page 9 and 10: General These instructions are prov
Page 11 and 12: Section 2 Installation Instructions
Page 19: Section 2 Installation Instructions
Page 25 and 26: Section 3 Operation General System
Page 27 and 28: Section 3 Operation MDH-302 Cold Ca
Page 29 and 30: Section 3 Operation Component Ident
Page 31 and 32: Section 3 Operation Syrup Delivery
Page 33 and 34: Section 3 Operation Operation Check
Page 35 and 36: Section 4 Maintenance Cleaning DAIL
Page 37 and 38: Section 4 Maintenance Preventive Ma
Page 39 and 40: Section 4 Maintenance 2. Remove the
Page 41 and 42: Section 4 Maintenance 4. Rinse all
Page 43 and 44: Section 4 Maintenance Front Service
Page 45 and 46: Section 4 Maintenance 5. Draw rinse
Page 47 and 48: Section 5 Before Calling for Servic
Page 54: © 2012 Manitowoc Continuing produc

MDH-302/402 & Icepic / Selectable Ice Series - Manitowoc ...

Create successful ePaper yourself

Delete template?

Save as template?