Owner's Manual - TNG Motor Scooters

More documents

Recommendations

Info

Gasoline & Exhaust Fumes ! WARNING Gasoline is highly flammable and exhaust fumes are poisonous: • Turn off engine before refueling. • Do not to spill any gasoline on the engine, exhaust system or the plastic body. • Do not refuel while smoking or near any open flame. • Do not operate your scooter in a closed area as the exhaust fumes may cause loss of consciousness or death within a short time. • Do not park the scooter near any flammable source. • If you swallow gasoline, inhale gasoline vapor or spill gasoline into your eyes, see doctor immediately or call American Association of Poison Control Centers at 1-800-222-1222 for assistance. • If you spill gasoline on your clothes, change and wash the affected area immediately with soap. Modification Any modifications to this scooter or removal of original equipment without approval from TNG Scooters may cause it to be unsafe for use and may trigger severe accident. Modifications may also make your scooter illegal to use and will void any and all warranty coverage. ACCESSORIES • We recommend ISS Soft Storage scooter bags for your scooter. See www.cmsiinc.com for the ISS website and information. • TNG custom accessories are also available on the www.tngscooters.com website. 12
E: SPECIFICATIONS Model Grand Sport 150cc Tire Size (Rear) 100/80-16 Model Number GS150 Tire Pressure (Front) 29psi Length 70.4 inches Tire Pressure (Rear) 33psi Width 26.9 inches Idle RPM 1500 Height 43.7 inches Exhaust Valve Gap (Cold) 0.15mm / 0.006 inch Dry Weight (no fuel) 250 lbs. Intake Valve Gap (Cold) 0.10mm / 0.004 inch Max. Load 330 lbs Spark Plug Type Autolight 4194 Most Economical Speed 20 mph Battery Type 12V 6Ah Noise 80dB(A) Headlight (Hi/Lo Beam) 35W / 35W Engine Type Air Cooled - 4 Stroke Front Running Light 3W Cylinder Arrangement Single Cylinder Brake/Tail Lights 21W / 5W Displacement 150cc Turn Signal Light 10W Ignition Type CDI Turn Signal Indicators ( Dash) 3W Transmission CVT Instrument Illumination 3W Front Brake Disc Fuses 15 Amps Rear Brake Disc Fuel Type 90 Octane Tire Size (Front) 100/80-13 Fuel Capacity 2.4 gals. Lubricating Oil SAE 10W40 Opti-4 Required for Engine Warranty 13
Page 1 and 2: Owner’s Manual Grand Sport 150cc
Page 3 and 4: A: INTRODUCTION Thank you for purch
Page 5 and 6: B: TABLE OF CONTENTS A: INTRODUCTIO
Page 7 and 8: D: SAFETY INSTRUCTIONS RIDING SCOOT
Page 9 and 10: Safe Riding • Keep enough distanc
Page 11: • Hold firmly to your waist, hips
Page 15 and 16: 4 5 6 3 2 1 9 10 7 8 1. Horn Button
Page 17 and 18: ! WARNING DO NOT CHANGE THE KEY POS
Page 19 and 20: Electric Starter (see page 15) •
Page 21 and 22: ! WARNING: • Always turn the engi
Page 23 and 24: 5. Check the Brakes Front Brake- Co
Page 25 and 26: • If the fuel has run dry . • I
Page 27 and 28: ! WARNING: • Do not apply the bra
Page 29 and 30: I: SERVICE MAINTENANCE SCHEDULE Ite
Page 31 and 32: CAUTION: This scooter uses tubeless
Page 33 and 34: CAUTION: • Incorrect gap can caus
Page 35 and 36: ! WARNING: Use caution when changin
Page 37 and 38: 4. 5. terminal and the BLACK wire i
Page 39 and 40: 1. BATTERY Maintaining the state of
Page 41 and 42: B. WET FUEL SYSTEM This technique i
Page 43 and 44: K. TROUBLESHOOTING ENGINE WON’T S
Page 45 and 46: 5. Carburetor Carburetor Defective
Page 47 and 48: POOR FUEL ECONOMY Causes Solutions
Page 49 and 50: WARRANTY RESPONSIBILITY THE MANUFAC
Page 51 and 52: WARRANTY COVERAGE TABLE COVERAGE BE
Page 53 and 54: YOUR LEGAL RIGHTS These warranties
Page 55 and 56: Replacement parts refer to Distribu
Page 57 and 58: YOUR OBLIGATION To practice proper
Page 59 and 60: WARRANTY COVERAGE • CMSI Inc will
Page 61 and 62: YOUR WARRANTY RIGHTS AND OBLIGATION
Page 63 and 64:
If you have any questions regarding
Page 65 and 66:
the remedying of defects in materia
Page 67:
Inc. Motorsports CMSI Inc., Motorsp
show all

Owner's Manual - TNG Motor Scooters

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?