Owner's Manual - TNG Motor Scooters

More documents

Recommendations

Info

9. Check the TRANSMISSION Oil Page 34 H: PROPER OPERATIONS & TECHNIQUES ! WARNING: • Be sure you have read this owner manual completely and understand all operating features. • Do not start the engine or operate the scooter in closed areas , as the exhaust fumes are poisonous and inhaling them can cause loss of consciousness and /or even death shortly. • This scooter is rated for two persons, total weight with rider and passenger must not exceed 330 lbs. 1. ENGINE STARTING PROCEDURE • Normal Start - Place scooter on the center stand • Turn the ignition key to the “ON” position. • While holding brake lever, firmly push the electric start. • Repeat 5 second intervals of starter motor activation and 5 second rest. Do NOT twist throttle open to start. NOTE: • It is recommended to always “prime” the fuel system by kick-starter when starting the scooter in the following situation (DO NOT ADVANCE THE THROTTLE WHILE KICK STARTING): • Cold or wet weather . 24
• If the fuel has run dry . • If the scooters has been stored for any length of time . • If electric start does not work. If bike does not start, please refer to trouble shooting section. ! WARNING: Do not change the position of the ignition switch while the vehicle is in motion, only when the vehicle has come to a complete stop. CAUTION: • When scooter is not running, do not leave the ignition switch in the “ON” position for extended periods of time. The battery may become depleted to the point that the vehicle cannot be started. • To preserve the scooter, each starting attempt should be less than 5 seconds. • To maximize the engine life, warm up the engine for 2 to 3 minutes prior to riding. No fast acceleration when the engine is still cold. NOTE: The engine will not start unless either the front or rear brake is activated. 25
Page 1 and 2: Owner’s Manual Grand Sport 150cc
Page 3 and 4: A: INTRODUCTION Thank you for purch
Page 5 and 6: B: TABLE OF CONTENTS A: INTRODUCTIO
Page 7 and 8: D: SAFETY INSTRUCTIONS RIDING SCOOT
Page 9 and 10: Safe Riding • Keep enough distanc
Page 11 and 12: • Hold firmly to your waist, hips
Page 13 and 14: E: SPECIFICATIONS Model Grand Sport
Page 15 and 16: 4 5 6 3 2 1 9 10 7 8 1. Horn Button
Page 17 and 18: ! WARNING DO NOT CHANGE THE KEY POS
Page 19 and 20: Electric Starter (see page 15) •
Page 21 and 22: ! WARNING: • Always turn the engi
Page 23: 5. Check the Brakes Front Brake- Co
Page 27 and 28: ! WARNING: • Do not apply the bra
Page 29 and 30: I: SERVICE MAINTENANCE SCHEDULE Ite
Page 31 and 32: CAUTION: This scooter uses tubeless
Page 33 and 34: CAUTION: • Incorrect gap can caus
Page 35 and 36: ! WARNING: Use caution when changin
Page 37 and 38: 4. 5. terminal and the BLACK wire i
Page 39 and 40: 1. BATTERY Maintaining the state of
Page 41 and 42: B. WET FUEL SYSTEM This technique i
Page 43 and 44: K. TROUBLESHOOTING ENGINE WON’T S
Page 45 and 46: 5. Carburetor Carburetor Defective
Page 47 and 48: POOR FUEL ECONOMY Causes Solutions
Page 49 and 50: WARRANTY RESPONSIBILITY THE MANUFAC
Page 51 and 52: WARRANTY COVERAGE TABLE COVERAGE BE
Page 53 and 54: YOUR LEGAL RIGHTS These warranties
Page 55 and 56: Replacement parts refer to Distribu
Page 57 and 58: YOUR OBLIGATION To practice proper
Page 59 and 60: WARRANTY COVERAGE • CMSI Inc will
Page 61 and 62: YOUR WARRANTY RIGHTS AND OBLIGATION
Page 63 and 64: If you have any questions regarding
Page 65 and 66: the remedying of defects in materia
Page 67: Inc. Motorsports CMSI Inc., Motorsp

Owner's Manual - TNG Motor Scooters

Create successful ePaper yourself

Delete template?

Save as template?