Owner's Manual - TNG Motor Scooters

More documents

Recommendations

Info

3. Check Compression 4. Spark Plug No Compression With Compression No Spark Spark Plug Wet or Fouled Intermittent Spark Plug Lead Spark Plug Dirty or Wrong Gap Loose Spark Plug Spark Plug OK Have <strong>TNG</strong> Dealer Inspect the Scooter Check Spark Plug Remove Plug & Prime Kick the Start Pedal without Fuel & Ignition. Re-install Spark Plug Replace Lead Replace Plug or Correct Gap Tighten Spark Plug Check Carburetor 44
5. Carburetor Carburetor Defective Blocked Idle Jet Dirty Float Bowl Low Fuel in Bowl Carburetor OK Engine Overheated Air Inlet System Blocked or Leaky Clean Jet Clean Bowl Adjust Bowl Check & Replace Lubricating Oil Remove Blockage or Leak KNOCKING SOUND IN CYLINDER Causes Solutions 1. Engine Overheating Check & Replace Lubricating Oil 2. Spark Plug Defective Replace the Spark Plug 3. Ignition Timing Too Early Adjust Ignition Timing 4. Carbon Build-up In Cylinder Remove Carbon Build-up In Exhaust Pipe & Muffler Remove Carbon Build-up 45
Page 1 and 2: Owner’s Manual Grand Sport 150cc
Page 3 and 4: A: INTRODUCTION Thank you for purch
Page 5 and 6: B: TABLE OF CONTENTS A: INTRODUCTIO
Page 7 and 8: D: SAFETY INSTRUCTIONS RIDING SCOOT
Page 9 and 10: Safe Riding • Keep enough distanc
Page 11 and 12: • Hold firmly to your waist, hips
Page 13 and 14: E: SPECIFICATIONS Model Grand Sport
Page 15 and 16: 4 5 6 3 2 1 9 10 7 8 1. Horn Button
Page 17 and 18: ! WARNING DO NOT CHANGE THE KEY POS
Page 19 and 20: Electric Starter (see page 15) •
Page 21 and 22: ! WARNING: • Always turn the engi
Page 23 and 24: 5. Check the Brakes Front Brake- Co
Page 25 and 26: • If the fuel has run dry . • I
Page 27 and 28: ! WARNING: • Do not apply the bra
Page 29 and 30: I: SERVICE MAINTENANCE SCHEDULE Ite
Page 31 and 32: CAUTION: This scooter uses tubeless
Page 33 and 34: CAUTION: • Incorrect gap can caus
Page 35 and 36: ! WARNING: Use caution when changin
Page 37 and 38: 4. 5. terminal and the BLACK wire i
Page 39 and 40: 1. BATTERY Maintaining the state of
Page 41 and 42: B. WET FUEL SYSTEM This technique i
Page 43: K. TROUBLESHOOTING ENGINE WON’T S
Page 47 and 48: POOR FUEL ECONOMY Causes Solutions
Page 49 and 50: WARRANTY RESPONSIBILITY THE MANUFAC
Page 51 and 52: WARRANTY COVERAGE TABLE COVERAGE BE
Page 53 and 54: YOUR LEGAL RIGHTS These warranties
Page 55 and 56: Replacement parts refer to Distribu
Page 57 and 58: YOUR OBLIGATION To practice proper
Page 59 and 60: WARRANTY COVERAGE • CMSI Inc will
Page 61 and 62: YOUR WARRANTY RIGHTS AND OBLIGATION
Page 63 and 64: If you have any questions regarding
Page 65 and 66: the remedying of defects in materia
Page 67: Inc. Motorsports CMSI Inc., Motorsp

Owner's Manual - TNG Motor Scooters

Create successful ePaper yourself

Delete template?

Save as template?