Owner's Manual - TNG Motor Scooters

More documents

Recommendations

Info

CAUTION: If the scooter is being used under more severe conditions such as gravel roads or lots of stop & go traffic, then the oil should be changed more frequently than every 4000 km. CHECK THE TRANSMISSION OIL Inspect the transmission oil after the first 300 km and then after every 4000 km or six months which ever comes first. NOTE: Must use Opti-4 oil in transmission to maintain warranty 1. Place the scooter on its center stand on a level surface. Let the engine warm up for three minutes and then shut the engine off. 2. Remove the transmission belt cover so that the oil drain plug is visible. 3. Remove the oil fill plug and the oil drain plug and allow the oil to drain completely. 4. Inspect the sealing washer on the drain plug, and if it’s OK reinstall the drain plug. 5. Refill the gearbox until full. Oil Fill Plug 6. Reinstall the oil fill plug. Transmission Belt Cover Oil Drain Plug 34
! WARNING: Use caution when changing oil to avoid burns! CAUTION: • If the scooter is used in excessively wet areas, or used in severe conditions replace the transmission oil more often than recommended. • Make sure that the fill and drain plugs are tight and not leaking. • Make sure that no foreign substances fall into the transmission box. AIR FILTER MAINTENANCE • The air filter should be inspected and cleaned every 1000 km interval. • Remove left body cover. • Remove the screws that hold the cover of the air cleaner in place and lift off the air cleaner cover. (See page 14 for air box location) • Lift out the air filter screen and cartridge. • Clean the screen and cartridge with compressed air. • Reassemble the air filter components and back end of the scooter. CAUTION: • If riding in an excessively dusty location, the air filter should be inspected more often than the recommended. • When remounting the air cleaner cover components onto the scooter. Be careful to fit all pieces into their correct place. Failure to achieve proper fit will cause leaks in the air intake system that can cause 35
Page 1 and 2: Owner’s Manual Grand Sport 150cc
Page 3 and 4: A: INTRODUCTION Thank you for purch
Page 5 and 6: B: TABLE OF CONTENTS A: INTRODUCTIO
Page 7 and 8: D: SAFETY INSTRUCTIONS RIDING SCOOT
Page 9 and 10: Safe Riding • Keep enough distanc
Page 11 and 12: • Hold firmly to your waist, hips
Page 13 and 14: E: SPECIFICATIONS Model Grand Sport
Page 15 and 16: 4 5 6 3 2 1 9 10 7 8 1. Horn Button
Page 17 and 18: ! WARNING DO NOT CHANGE THE KEY POS
Page 19 and 20: Electric Starter (see page 15) •
Page 21 and 22: ! WARNING: • Always turn the engi
Page 23 and 24: 5. Check the Brakes Front Brake- Co
Page 25 and 26: • If the fuel has run dry . • I
Page 27 and 28: ! WARNING: • Do not apply the bra
Page 29 and 30: I: SERVICE MAINTENANCE SCHEDULE Ite
Page 31 and 32: CAUTION: This scooter uses tubeless
Page 33: CAUTION: • Incorrect gap can caus
Page 37 and 38: 4. 5. terminal and the BLACK wire i
Page 39 and 40: 1. BATTERY Maintaining the state of
Page 41 and 42: B. WET FUEL SYSTEM This technique i
Page 43 and 44: K. TROUBLESHOOTING ENGINE WON’T S
Page 45 and 46: 5. Carburetor Carburetor Defective
Page 47 and 48: POOR FUEL ECONOMY Causes Solutions
Page 49 and 50: WARRANTY RESPONSIBILITY THE MANUFAC
Page 51 and 52: WARRANTY COVERAGE TABLE COVERAGE BE
Page 53 and 54: YOUR LEGAL RIGHTS These warranties
Page 55 and 56: Replacement parts refer to Distribu
Page 57 and 58: YOUR OBLIGATION To practice proper
Page 59 and 60: WARRANTY COVERAGE • CMSI Inc will
Page 61 and 62: YOUR WARRANTY RIGHTS AND OBLIGATION
Page 63 and 64: If you have any questions regarding
Page 65 and 66: the remedying of defects in materia
Page 67: Inc. Motorsports CMSI Inc., Motorsp

Owner's Manual - TNG Motor Scooters

Create successful ePaper yourself

Delete template?

Save as template?