Owner's Manual - TNG Motor Scooters

More documents

Recommendations

Info

! WARNING: • The storage compartment can carry 6.5 lbs max. • Do not exceed maximum 17.5 lbs for cargo. • Ensure the storage compartment is locked before riding. CAUTION: • Do not store anything susceptible to heat inside storage compartments. • Do not let humidity spread from storage compartment. • Do not put anything valuable or breakable in storage compartment. • The compartment is not waterproof. Use plastic bags to store stuff when washing the scooter. Luggage Rack ! WARNING: • Luggage rack can carry 11 lbs max. • Do not exceed maximum 17.5 lbs for cargo. Fuel Tank Cap (see page 14 for location) • To remove the fuel tank cap, slide the lock cover open, insert the ignition key into the fuel tank cap lock, and turn ¼ counterclockwise. The fuel tank cap is released and can be removed. • To install the fuel tank cap, insert the fuel tank cap to the tank, turn the key ¼ clockwise to the original position and removed the key. Slide back the lock cover. 20
! WARNING: • Always turn the engine off prior to refueling the scooter. • Ensure the fuel tank cap is properly installed before riding. • Do not overfill the tank as it may overflow when the fuel warms up and expands. • Avoid spilling fuel on a hot engine. CAUTION: • Wipe off the spilled fuel immediately as fuel may deteriorate the paint on the scooter or any plastic parts. • Always use 90 octane or higher gasoline when refueling the scooter. Do not use E85 or fuel containing more than 10% ethanol. G: PRE-RIDE CHECKLIST 1. Check the fuel level • Remove the gas cap by turning the cap counterclockwise. • Fill the tank up to the bottom of the filler tube. Do not fill past that point. • Replace the gas cap and turn it clockwise until it is secure. NOTE: Always turn the engine off prior to refueling the scooter. Always use 90 octane or higher gasoline to refuel the scooter. Do not use E85 or fuel containing more than 10% ethanol. 21
Page 1 and 2: Owner’s Manual Grand Sport 150cc
Page 3 and 4: A: INTRODUCTION Thank you for purch
Page 5 and 6: B: TABLE OF CONTENTS A: INTRODUCTIO
Page 7 and 8: D: SAFETY INSTRUCTIONS RIDING SCOOT
Page 9 and 10: Safe Riding • Keep enough distanc
Page 11 and 12: • Hold firmly to your waist, hips
Page 13 and 14: E: SPECIFICATIONS Model Grand Sport
Page 15 and 16: 4 5 6 3 2 1 9 10 7 8 1. Horn Button
Page 17 and 18: ! WARNING DO NOT CHANGE THE KEY POS
Page 19: Electric Starter (see page 15) •
Page 23 and 24: 5. Check the Brakes Front Brake- Co
Page 25 and 26: • If the fuel has run dry . • I
Page 27 and 28: ! WARNING: • Do not apply the bra
Page 29 and 30: I: SERVICE MAINTENANCE SCHEDULE Ite
Page 31 and 32: CAUTION: This scooter uses tubeless
Page 33 and 34: CAUTION: • Incorrect gap can caus
Page 35 and 36: ! WARNING: Use caution when changin
Page 37 and 38: 4. 5. terminal and the BLACK wire i
Page 39 and 40: 1. BATTERY Maintaining the state of
Page 41 and 42: B. WET FUEL SYSTEM This technique i
Page 43 and 44: K. TROUBLESHOOTING ENGINE WON’T S
Page 45 and 46: 5. Carburetor Carburetor Defective
Page 47 and 48: POOR FUEL ECONOMY Causes Solutions
Page 49 and 50: WARRANTY RESPONSIBILITY THE MANUFAC
Page 51 and 52: WARRANTY COVERAGE TABLE COVERAGE BE
Page 53 and 54: YOUR LEGAL RIGHTS These warranties
Page 55 and 56: Replacement parts refer to Distribu
Page 57 and 58: YOUR OBLIGATION To practice proper
Page 59 and 60: WARRANTY COVERAGE • CMSI Inc will
Page 61 and 62: YOUR WARRANTY RIGHTS AND OBLIGATION
Page 63 and 64: If you have any questions regarding
Page 65 and 66: the remedying of defects in materia
Page 67: Inc. Motorsports CMSI Inc., Motorsp

Owner's Manual - TNG Motor Scooters

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?