Download Owner's manual - Royal Enfield

More documents

Recommendations

Info

D O I T Y O U R S E L F DRIVE CHAIN Clean the drive chain carefully of dirt. Apply few drops of 90 grade oil while simultaneously rotating the rear wheel. Wipe off the excess oil. OIL LEVEL INSPECTION Place motorcycle on its center stand on a firm surface. Warm up engine for a few minutes & switch off before checking oil level. The level is correct if the oil level is in the middle of the oil level window. Top up with recommended oil if required. BRAKE FLUID Check if oil is below ‘MIN’ level. To top up, Remove cover and diaphragm. CAUTION : Use of wrong grade or spurious oil can seriously affect m o t o r c y c l e performance & damage to moving parts M AX MIN Top up with DOT 3 or DOT 4 as specified. CAUTION : Don’t mix DOT 3 & DOT 4 fluid. 33
D O I T Y O U R S E L F ENGINE - OIL CHANGE Secondary Drain Plug Primary Primary Drain Bolt Drain Cap (Refer Periodical Maintenance Chart for frequency) Place motorcycle on its center stand on a firm flat surface. Start engine and warm up for 2 minutes. Keep a clean tray below the engine Remove primary drain cap, to drain oil & clean suction filter, magnet. Then remove secondary drain plug to drain oil & clean the magnet. Finally remove primary drain bolt to drain the complete oil. 34 Remove the oil filter element on the Crankcase Cover RH. Allow the oil to drain by tilting the motorcycle to both sides. Wash the drain plug and the suction filter thoroughly and refit on the crankcase after all the oil is drained out. Soak a new oil filter element in the oil and refit on the Crankcase Cover RH. Assembly 3 bolts and tighten them. Ensure ‘O’ Ring and gaskets are taken seat properly. • Fill recommended oil to engine till the oil level is upto “MAX” level mark in the oil window in Crankcase Cover RH. Max Min NOTE : Replace oil filter element whenever oil is being replaced. CAUTION : Filling up oil over “MAX” mark may cause smoke and / or loss of power. Do NOT allow oil level to fall below “MIN” mark. Doing so may result in engine internal damage or malfuncton.
Page 2 and 3: RELOADED Get ready for the adventur
Page 4 and 5: C O N T E N T S Personal and vehicl
Page 6 and 7: F R E E S E R V I C E R E C O R D I
Page 8 and 9: S P E C I F I C A T I O N S Final d
Page 10 and 11: S A F E T Y D E F I N I T I O N S T
Page 12 and 13: V E H I C L E I D E N T I F I - C A
Page 14 and 15: L O C A T I O N O F K E Y P A R T S
Page 16 and 17: O P E R A T I O N O F C O N T R O L
Page 22 and 23: P R E O P E R A T I O N A L C H E C
Page 24 and 25: USING KICK START Ensure gear is in
Page 26 and 27: G E A R S H I F T I N G , R I D I N
Page 28 and 29: T O O L S & F I R S T A I D K I T 1
Page 30 and 31: S. No. DESCRIPTION 29 P E R I O D I
Page 32 and 33: R E C O M M E N D E D L U B R I C A
Page 36 and 37: SPARK PLUG Cleaning and adjusting P
Page 38 and 39: D O I T Y O U R S E L F Place a 4
Page 40 and 41: D O I T Y O U R S E L F REAR WHEEL
Page 42 and 43: D O I T Y O U R S E L F WHEEL ALIGN
Page 44 and 45: BATTERY & MAINTENANCE The vehicle
Page 46 and 47: TAIL LAMP BULB Remove the tail lam
Page 48 and 49: S T O R A G E P R E C A U T I O N S
Page 50 and 51: L O N G T R I P P R E C A U T I O N
Page 52 and 53: C A R I N G F O R M I L E A G E Pr
Page 54: Vehicle Starting Procedure COMPLETE
Page 57 and 58: CAUSES REMEDIES - Loose spark plug
Page 59 and 60: T R O U B L E S H O O T I N G VI. E
Page 61 and 62: CAUSES REMEDIES XI. Electricals Bul
Page 63 and 64: W A R R A N T Y T E R M S & C O N D
Page 65 and 66: 63 E M I S S I O N W A R R A N T Y
Page 67 and 68: test during which the failure is di
Page 69 and 70: 67 A L L I N D I A R O A D S I G N
Page 71 and 72: L O G B O O K Sl. No. Date Kms. Det
Page 73 and 74: 1 s t F R E E S E R V I C E 1st Fre
Page 75 and 76: 2 n d F R E E S E R V I C E 2nd Fre
Page 77 and 78: 3 r d F R E E S E R V I C E 3rd Fre
Page 79 and 80: 4 t h F R E E S E R V I C E 4th Fre
Page 81 and 82: PA I D S E RV I C E / M A I N T E N
Page 83 and 84: PA I D S E RV I C E / M A I N T E N
Page 85 and 86:
PA I D S E RV I C E / M A I N T E N
Page 87 and 88:
PA I D S E RV I C E / M A I N T E N
Page 89 and 90:
87 N O T E S
Page 91:
Telephone Residence Bike Regn. No.
Page 94 and 95:
AESTHETICS 36 Mudguards - Paint / P
Page 96 and 97:
13 Control Switches & Disc Brake Sy
show all

Download Owner's manual - Royal Enfield

Create successful ePaper yourself

Delete template?

Save as template?