Download Owner's manual - Royal Enfield

More documents

Recommendations

Info

SPARK PLUG Cleaning and adjusting Plug gap Two spark plugs are provided in your vehicle Remove spark plug using the plug spanner and tommy bar. Clean the insulator tip and electrodes of the plug carefully using a pointed scraper or spark plug cleaner. Set the gap between 0.70 to 0.80 mm. Refit the spark plug on the cylinder head. Gap 0.70 to 0.80 mm. Repeat the above procedure for the secondary sparkplug. D O I T Y O U R S E L F INSPECTION OF TYRES AND WHEELS Inspect the tyres periodically for tread wear, cracks and cuts. Minimum tread depth : Front tyre : 1mm Rear tyre : 2 mm Check and remove stone, splinters, nails or other particles embedded in the tyre treads. Bald spots / swelling may be caused by internal damage. Replace the tyres, if defective. Replace tyres when the tread depth has reached the minimum as specified. Periodically inspect wheels for spokes breakage and wheel rim run out. Check proper seating of the tyre beading on the rim whenever the tyre is reassembled. Whenever a new tyre is installed, ensure rim and spokes do not get damaged on account of using wrong levers. Use only standard tyres & tubes inflated to correct pressure. 35
D O I T Y O U R S E L F Tyre Pressure Remove the axle nut along with washer. Front Rear Solo 1.41 kg/cm 2 (20 PSI) 2.11 kg/cm 2 (30 PSI) With Pillion 1.55 kg/cm 2 (22 PSI) 2.20kg/cm 2 (32 PSI) FRONT WHEEL REMOVAL Place the vehicle on center stand Place a wooden block the front end of engine to support the vehicle. Disconnect speedo cable. Loosen the pinch bolt on the RH fork guide. 36 Tap and remove the front wheel spindle Tilt the vehicle to RH Side and take out the wheel along with speedo drive and RH side spacer. Take out Speedo drive and bush on the RH side.
Page 2 and 3: RELOADED Get ready for the adventur
Page 4 and 5: C O N T E N T S Personal and vehicl
Page 6 and 7: F R E E S E R V I C E R E C O R D I
Page 8 and 9: S P E C I F I C A T I O N S Final d
Page 10 and 11: S A F E T Y D E F I N I T I O N S T
Page 12 and 13: V E H I C L E I D E N T I F I - C A
Page 14 and 15: L O C A T I O N O F K E Y P A R T S
Page 16 and 17: O P E R A T I O N O F C O N T R O L
Page 22 and 23: P R E O P E R A T I O N A L C H E C
Page 24 and 25: USING KICK START Ensure gear is in
Page 26 and 27: G E A R S H I F T I N G , R I D I N
Page 28 and 29: T O O L S & F I R S T A I D K I T 1
Page 30 and 31: S. No. DESCRIPTION 29 P E R I O D I
Page 32 and 33: R E C O M M E N D E D L U B R I C A
Page 34 and 35: D O I T Y O U R S E L F DRIVE CHAIN
Page 38 and 39: D O I T Y O U R S E L F Place a 4
Page 40 and 41: D O I T Y O U R S E L F REAR WHEEL
Page 42 and 43: D O I T Y O U R S E L F WHEEL ALIGN
Page 44 and 45: BATTERY & MAINTENANCE The vehicle
Page 46 and 47: TAIL LAMP BULB Remove the tail lam
Page 48 and 49: S T O R A G E P R E C A U T I O N S
Page 50 and 51: L O N G T R I P P R E C A U T I O N
Page 52 and 53: C A R I N G F O R M I L E A G E Pr
Page 54: Vehicle Starting Procedure COMPLETE
Page 57 and 58: CAUSES REMEDIES - Loose spark plug
Page 59 and 60: T R O U B L E S H O O T I N G VI. E
Page 61 and 62: CAUSES REMEDIES XI. Electricals Bul
Page 63 and 64: W A R R A N T Y T E R M S & C O N D
Page 65 and 66: 63 E M I S S I O N W A R R A N T Y
Page 67 and 68: test during which the failure is di
Page 69 and 70: 67 A L L I N D I A R O A D S I G N
Page 71 and 72: L O G B O O K Sl. No. Date Kms. Det
Page 73 and 74: 1 s t F R E E S E R V I C E 1st Fre
Page 75 and 76: 2 n d F R E E S E R V I C E 2nd Fre
Page 77 and 78: 3 r d F R E E S E R V I C E 3rd Fre
Page 79 and 80: 4 t h F R E E S E R V I C E 4th Fre
Page 81 and 82: PA I D S E RV I C E / M A I N T E N
Page 87 and 88:
PA I D S E RV I C E / M A I N T E N
Page 89 and 90:
87 N O T E S
Page 91:
Telephone Residence Bike Regn. No.
Page 94 and 95:
AESTHETICS 36 Mudguards - Paint / P
Page 96 and 97:
13 Control Switches & Disc Brake Sy
show all

Download Owner's manual - Royal Enfield

Create successful ePaper yourself

Delete template?

Save as template?