OWNERS MANUAL - BR250-DN250 Go Kart - Baja Motorsports

More documents

Recommendations

Info

BATTERY INSTALLATIONINITIAL SERVICE AND INSTALLATION OF BATTERY:!WARNINGThe following procedure is very dangerous and should be performed withutmost care and attention. Wear protective eye wear, rubber gloves, andhave water available should electrolyte come in contact with skin or eyes.KEEP ALL CHILDREN AWAY FROM THE AREA WHILE THIS PROCEDURE ISBEING PERFORMED.POISON – CAUSES SEVERE BURNSContains sulfuric acid.Avoid contact with skin, eyes, or clothingTo prevent accidents, rinse empty container with water.ANTIDOTE:External – flush with waterInternal – Call physician immediately. Drink large quantities of water or milk.Follow with milk of magnesia, beaten eggs or vegetable.Eyes – Flush with water for 15 minutes and get prompt medical attention.KEEP OUT OF REACH OF CHILDREN.27
BATTERY INSTALLATIONNote: The following page is for vehicles with battery’s containing separateelectrolyte pack. Most battery’s will come with the electrolyte already sealedinto the battery.Preparing the battery:· Place battery on level surface. Remove sealing tapefrom top. (see figure A)· Take the electrolyte container out of the plastic bag.· Place electrolyte container upside down with thesealed silver mouths of the electrolyte bottles in linewith the six filler holes of the battery. (see figure B)· Push the container down strongly enough to breakthe silver seals. (see figure B)· As electrolyte starts flowing into battery, airbubbles will come up from the mouths of the plasticelectrolyte bottles.· Leave bottles upside down in battery holes untilelectrolyte is completely drained.· Never leave children unattended around battery.· If air bubbles cease to float to the top of theelectrolyte bottles, tap lightly on top.· DO NOT remove container from battery while it isdraining.· Never cut or pierce electrolyte container.· After all the electrolyte has drained from the bottlesinto the battery, pull plastic electrolyte bottles gentlyout of the battery.· Discard empty electrolyte bottles in a waste areathat is inaccessible to children and animals.· After filling let battery stand for at least 30 minutesbefore charging. This allows the electrolyte topenetrate plates for optimum performance andensures longer battery life.· After 30 minutes the battery is ready for its initialcharge. Place cap strip loosely over the filling holesas shown in the picture. (see figure C)Figure AFigure BFigure C28
Page 1 and 2: BR250/DN250 Go-KartRead this manual
Page 3 and 4: !WARNINGThis manual should be consi
Page 5 and 6: FORWARDPlease read this manual and
Page 7 and 8: NOTICE TO USERSIMPORTANT RULES FOR
Page 9 and 10: NOTICE TO USERS13. LOOSE CLOTHING,
Page 11 and 12: NOTICE TO USERS26. This manual, alo
Page 13 and 14: FUEL AND OILFUELThe proper fuel is
Page 15 and 16: WARNING LABELSLocated on brush guar
Page 17 and 18: CONTROL PANEL AND IGNITION SWITCHLi
Page 19 and 20: SEAT ADJUSTMENTPull seat adjustment
Page 21 and 22: INSPECTION BEFORE RIDINGITEM TO CHE
Page 23 and 24: SAFETY GEARA DOT approved motorcycl
Page 25 and 26: DRIVE SELECT LEVERThe drive select
Page 27 and 28: CHAIN AND SHOCK ADJUSTMENTCHAIN ADJ
Page 29: MAINTENANCE SCHEDULE!WARNINGImprope
Page 34: To check oil level:1. Park vehicle
Page 38 and 39: AIR FILTERThe air filter element mu
Page 41 and 42: !Overfilling the air to the tires c
Page 43 and 44: FRONT AND REAR HYDRAULIC DISKBRAKE
Page 45 and 46: IGNITION SYSTEM CHECK1. Remove the
Page 47 and 48: CLEANING PROCEDUREA thorough cleani
Page 49 and 50: STORAGE PROCEDUREIf you do not use
Page 51 and 52: WIRE DIAGRAMTemperature switchHeadl
Page 53 and 54: EMISSION CONTROL SYSTEM WARRANTYBAJ
Page 55: Baja, INC.P.O. Box 61150Phoenix, AZ

OWNERS MANUAL - BR250-DN250 Go Kart - Baja Motorsports

Create successful ePaper yourself

Delete template?

Save as template?