ASSEMBLY MANUAL - Hobie Cat

More documents

Recommendations

Info

STEPPING THE MASTPlace the mast foot on the1mast base and place the pin init. This prevents the mast fromleaving its base when lifted.Check that the wires are not tangled.Then, with one person on the trampoline, the2second person lifts the mast by the top andmoves down the mast until the person on thetrampoline can take the mast on their shoulder.Then this person pushes his feet against the rearcrossbar and pushes the mast forward with theweight of his body.The first person is to push the mast up as far as possible,walking ahead on the trampoline as the mast israised.The second person can3now take the forestay,make sure it is not tangledand pin it into one of thetop holes of the furler mountedstay adjuster.Once the mast is secure remove the bolt from4 the base of the mast and stow it in a secureplace. You will need the bolt later for safe loweringof the mast.5Now you can affix the cunninghamblocks to the bracketson each side of the mast.NB: FOR THE FIRST FEW TIMES YOURAISE THE MAST IT IS RECOMMENDEDYOU USE 3 PEOPLE FOR EXTRA SAFETY.12
TRAPEZE1Release the trapeze wires from the base of the mast. The crew’s trapeze has the clamcleat swaged tothe wire. The skipper’s trapeze has the small block swaged on. Ensure that the crews trapeze wire is positionedin front of the shroud.Attach the trapeze handles and kits to the trapeze wires.CREW TRAPEZESKIPPER TRAPEZE2Pass the trapeze shock cords (the crews is slightly longer than the skippers) underneath the trampolineand up through the grommets at the side of the trampoline. Attach to the trapeze system as shown in thephotographs.13
Page 1 and 2: ASSEMBLY MANUALTABLE OF CONTENT1Lis
Page 3 and 4: LIST OF PARTS213WIRES :459106 71. S
Page 5 and 6: TRAMPOLINE ASSEMBLY1 Unfold the tra
Page 7 and 8: RUDDER ASSEMBLY1Identify the right
Page 9 and 10: MAST SET UPTrapeze wiresTrapeze wir
Page 11: PREPARATION FOR MAST ASSEMBLY1 Lay
Page 15 and 16: MAINSAIL1* Always point your Hobie
Page 17 and 18: JIB2Shackle the two clew blocks tot
Page 19 and 20: MAIN SHEET SYSTEM1Your mainsheet sy
Page 21 and 22: SPINNAKER KITYour spinnaker kit inc
Page 23 and 24: Spi SheetSPINNAKER KITSCHEMATIC OF

ASSEMBLY MANUAL - Hobie Cat

Create successful ePaper yourself

Delete template?

Save as template?