ASSEMBLY MANUAL - Hobie Cat

More documents

Recommendations

Info

BOOM1Connect the boom to the mast using the hingevertex, clevis pin and split ring.Tie one end of the rotation line to the front of the2clamcleat on top of the boom. Pass the otherend of the line through the end of the rotationarm on the mast. Take the line back through the clamcleatand fit a plastic ball stopper at the end.14
MAINSAIL1* Always point your <strong>Hobie</strong> into the wind before raising the sails. *Unfold the mainsail on a clean surface and insert each batten into its respective pocket. The battens arenumbered from 1 to 7. Number 1 goes at the top and number 7 at the bottom of the sail. Secure the battens inthe pockets with the batten ties – as shown in the photographs.2Undo the halyard rope, which is attached to themast. Pass the end through the hole in theheadboard and tie off with a figure «8» knot.Feed the luff of the mainsail into the opening of3the mast track ensuring that the hook is on oneside of the mast and the halyard on the otherside. Ensure that the halyard inside the track stays insidethe track.Raise the sail by pulling the halyard and feeding thesail into the opening. When the sail is all the way upturn the mast slightly so that the hook will engage inthe halyard lock when you pull down on the sail. Insertthe bottom part of the luff into the lower section of themast track. Roll up the halyard and place it in thetrampoline pocket.4Attach the clew of the mainsail to the shackle onthe boom outhaul car assembly.15
Page 1 and 2: ASSEMBLY MANUALTABLE OF CONTENT1Lis
Page 3 and 4: LIST OF PARTS213WIRES :459106 71. S
Page 5 and 6: TRAMPOLINE ASSEMBLY1 Unfold the tra
Page 7 and 8: RUDDER ASSEMBLY1Identify the right
Page 9 and 10: MAST SET UPTrapeze wiresTrapeze wir
Page 11 and 12: PREPARATION FOR MAST ASSEMBLY1 Lay
Page 13: TRAPEZE1Release the trapeze wires f
Page 17 and 18: JIB2Shackle the two clew blocks tot
Page 19 and 20: MAIN SHEET SYSTEM1Your mainsheet sy
Page 21 and 22: SPINNAKER KITYour spinnaker kit inc
Page 23 and 24: Spi SheetSPINNAKER KITSCHEMATIC OF

ASSEMBLY MANUAL - Hobie Cat

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?