Banks Six-GunÂ® Diesel Tuner - Bankspower - Banks Power

More documents

Recommendations

Info

Section 8Clearing Learned InformationIf the Six-Gun Diesel Tuner has beenmoved to a different vehicle, or youare instructed to do so by BanksTechnical Staff, it is possible to resetall of the parameters that the Six-Gunhas ‘learned’ - presence of an EGTthermocouple or Speed-Loader, etc.CAUTION: The following procedurescan only be carried out with theengine OFF!1. Turn the vehicle key to ON but DONOT start the engine.2. Fully depress the throttle pedaland then release it completely.Repeat 5 times. The Tuner’s GREENLED will flash when this is completedsuccessfully.3. Turn the key OFF. Wait 60 secondsand make sure the GREEN LED goesoff and stays off. Turn the key back tothe ON position but DO NOT start theengine.4. Fully depress the throttle pedal andthen release it completely. Repeat 5times.-END, SECTION 8-Section 9Removal of the Six-Gun Diesel TunerIf the Six-Gun Diesel Tuner should everneed to be removed from the vehicle,perform the following:1. Disconnect the negative (ground)cable from the battery (or batteries, ifthere are two) before beginning work.2. Disconnect the Six-Gun’s grayconnector from the factory harness.3. Re-connect the vehicle’s grayconnector back into the factoryharness.4. Disconnect the Six-Gun’s blackconnector from the factory harness.5. Re-connect the vehicle’s blackconnector back into the factoryharness.6. Disconnect the EGT thermocoupleconnector. The thermocouple may beleft in place or removed if a suitableplug is used.7. Disconnect the ‘In-Cab Cable’ andgently pull the cable back through thefirewall.8. Remove the Six-Gun Diesel Tuner.Failure to follow the above instructionswhen removing the Tuner will resultin a “Check Engine” light on the dashand a Diagnostic Trouble Code beingstored in the factory computer, inaddition to the engine not running.9. Re-connect the negative (ground)cable(s).-END, SECTION 9-26 96819 v.3.0
Section 10Placement of the Banks Power DecalsFigure 24TYPICAL LEFT FENDER PLACEMENTTYPICAL RIGHT FENDER PLACEMENT96819 v.3.0 27
Page 1 and 2: Banks Six-Gun ®Diesel TunerCompati
Page 3 and 4: Please see enclosed warrantyinforma
Page 5 and 6: General Installation PracticesTOOLS
Page 7 and 8: Section 1Installation of Wiring Har
Page 9 and 10: 9. From inside the cab locate thegr
Page 11 and 12: Figure 7 Chevy LMM ShownFuseAccessP
Page 13 and 14: Figure 10 Banks Bridge ModuleWARNIN
Page 15 and 16: Figure 13 Figure 14Figure 1596819 v
Page 17 and 18: Figure 17- Rear template usedFigure
Page 19 and 20: Section 4Optional Thermocouple Inst
Page 21 and 22: Section 6Checking Engine Performanc
Page 23 and 24: Figure 22Figure 23Six-Gun Troublesh
Page 25: • The GREEN LED will flash if all

Banks Six-GunÂ® Diesel Tuner - Bankspower - Banks Power

Create successful ePaper yourself

Delete template?

Save as template?